Ford Galaxy - 2016 Fuse Box Diagram

Ford Galaxy - 2016 Fuse Box Diagram

12 Volt DC Power Point
WARNING
Do not plug electrical accessories
into the cigar lighter socket. Incorrect
use of the lighter can cause damage
not covered by your warranty, and can
result in fire or serious injury.
Note:
When you switch the ignition on, you
can use the socket to power 12 volt
appliances with a maximum current rating
of 15 amps. After you switch the ignition off,
the power supply works only for a maximum
of 75 minutes.
Note:
Do not insert objects other than an
accessory plug into the power point. This
damages the outlet and blows the fuse.
Note:
Do not hang any type of accessory or
accessory bracket from the plug.
Note:
Do not use the power point over the
vehicle capacity of 12 volt DC 180 watt or a
fuse may blow.
Note:
Do not use the power point for
operating a cigar lighter element.
Note:
Incorrect use of the power point can
cause damage not covered by your
warranty.
Note:
Always keep the power point caps
closed when not in use.
Run the engine for full capacity use of the
power point.
To prevent your vehicle battery from
running out of charge:
Do not use the power point longer than
necessary when your engine is not
running.
Do not leave devices plugged in
overnight or when your vehicle is in park
(P) for extended periods.
Location
Power points may be found:
On the center console.
Inside the center console.
On the rear of the console.
In the cargo area.
230 Volt Power Point
(If Equipped)
WARNING
Do not keep electrical devices
plugged in the power point whenever
the device is not in use. Do not use
any extension cord with the 230 volt power
point, since it will defeat the safety
protection design. Doing so may cause the
power point to overload. Powering multiple
devices can reach beyond the 150 watt
load limit and could result in fire or serious
injury.
Note:
Keep the vehicle running to use the
power point.
You can use the power point for powering
electrical devices that require up to 150
watts. It is on the rear of the center
console.
The power point indicator light, located on
the power point, shows when the power
point is ready for use.
When the power point indicator light is:
On
the power point is ready to supply
power.
Off
the power point power supply is
off and so is the ignition.
Flashing
the power point is in fault
mode.
The power point temporarily turns off its
power if the electrical load exceeds the
150 watt limit. The power point can also
switch to a fault mode if it detects
overloading, overheating or shorting
conditions.
139
Galaxy / S-MAX (CDR) , CG3646en enGBR, Edition date: 01/2015, First Printing
Auxiliary Power Points
If equipped with steering wheel
paddles, pull the + paddle on the
steering wheel to activate SelectShift.
Pull the right paddle (+) to upshift.
Pull the left paddle (
) to downshift.
The instrument cluster displays your
currently selected gear. If a gear is
requested but not available due to vehicle
conditions (low speed, too high engine
speed for requested gear selection), the
current gear will flash three times.
Emergency Park Position Release
Lever
WARNINGS
Do not drive your vehicle until you
verify that the brake lamps are
working.
This procedure requires you to shift
the gearshift lever out of park (P)
causing your vehicle to roll. Make
sure you fully set the parking brake before
attempting to release the gearshift lever.
If you release the parking brake and
the brake warning lamp remains
illuminated, the brakes may not be
working correctly. The system has
detected a fault that requires service.
Note:
For some markets this feature will be
disabled.
Your vehicle is equipped with a brake-shift
interlock feature that prevents moving the
gearshift lever from park (P) when the
ignition is in the on position and the brake
pedal is not pressed.
If you cannot move the gearshift lever out
of park (P) position with the ignition in the
on position and the brake pedal pressed,
a malfunction may have occurred. It is
possible that a fuse has blown or your
vehicle
s brake lamps are not operating
properly. See
Fuse Specification Chart
(page 233).
If the fuse is not blown and the brake
lamps are working properly, the following
procedure will allow you to move the
gearshift lever from park (P):
1.
Remove the side panel on the right side
of the gearshift lever.
2.
Locate the access hole.
161
Galaxy / S-MAX (CDR) , CG3646en enGBR, Edition date: 01/2015, First Printing
Transmission
FUSE SPECIFICATION CHART
Power Distribution Box
WARNINGS
Always disconnect the battery before
servicing high-current fuses.
To reduce risk of electrical shock,
always replace the cover to the
power distribution box before
reconnecting the battery or refilling fluid
reservoirs.
The power distribution box is located in
the engine compartment. It has
high-current fuses that protect your
vehicle's main electrical systems from
overloads.
If the battery has been disconnected and
reconnected, some features will need to
be reset. See
Changing the 12V Battery
(page 250).
Protected components
Fuse amp rating
Fuse or relay number
Wiper motor.
25A
3
1
Starter relay.
-
2
Rear wiper.
15A
1
3
Rain sensor
233
Galaxy / S-MAX (CDR) , CG3646en enGBR, Edition date: 01/2015, First Printing
Fuses
Protected components
Fuse amp rating
Fuse or relay number
Blower motor relay.
4
Power point 3 - Back of console.
20A
3
5
Auxiliary heater #2 relay.
6
Powertrain control module - vehicle power
1.
20A
1
7
Powertrain control module - vehicle power
2.
20A
1
8
Powertrain control module relay.
9
Power point 1 - driver front.
20A
3
10
Powertrain control module - vehicle power
4.
15A
2
11
Powertrain control module - vehicle power
3.
15A
2
12
Not used (spare).
10A
2
13
Not used (spare).
10A
2
14
Run-start relay.
15
Power point 2 - console.
20A
3
16
Power point 4 - luggage compartment.
20A
3
17
Not used (spare).
10A
1
18
Run-start electronic power assist steering.
10A
1
19
Run/start lighting.
10A
1
20
Run/start transmission control.
15A
1
21
Transmission oil pump start/stop.
Air conditioner clutch solenoid.
10A
1
22
Run-start.
15A
1
23
Blind spot information system.
Rear view camera.
Adaptive cruise control.
234
Galaxy / S-MAX (CDR) , CG3646en enGBR, Edition date: 01/2015, First Printing
Fuses
Protected components
Fuse amp rating
Fuse or relay number
Heads-up display.
Voltage stability module.
Run-start 7.
10A
1
24
Run-start anti-lock brake system.
10A
2
25
Run-start powertrain control module.
10A
2
26
Not used.
27
Rear washer pump.
10A
1
28
Not used.
29
Not used.
30
Not used.
31
Electronic fan 1 relay.
32
A/C clutch relay.
33
Electric steering column lock.
15A
1
34
Not used.
35
Not used.
36
Not used.
37
Electronic fan 2 relay
38
Electric fan 2 and 3 relay.
39
Headlamp washer relay.
40
Horn relay.
41
Fuel pump relay.
42
Not used (spare).
10A
1
43
Heated washer nozzle.
5A
1
44
Not used.
45
Alternator sensor.
10A
2
46
235
Galaxy / S-MAX (CDR) , CG3646en enGBR, Edition date: 01/2015, First Printing
Fuses
Protected components
Fuse amp rating
Fuse or relay number
Brake on/off switch.
10A
2
47
Horn.
20A
1
48
Diesel fuel heater.
20A
1
49
Power transfer unit fan.
10A
1
50
Not used.
51
Not used.
52
Power seats.
10A
1
53
Fuel operated heater.
5A
2
54
Fuel operated heater.
5A
2
55
1
Micro fuse.
2
Dual micro fuse.
3
M-type fuse.
Power Distribution Box - Bottom
There are fuses located on the bottom of
the fuse box. To access the bottom of the
fuse box, do the following:
1.
Release the two latches, located on
both sides of the fuse box.
236
Galaxy / S-MAX (CDR) , CG3646en enGBR, Edition date: 01/2015, First Printing
Fuses
2.
Raise the inboard side of the fuse box
from the cradle.
3.
Move the fuse box toward the center
of the engine compartment.
4.
Pivot the outboard side of the fuse box
to access the bottom side.
Protected components
Fuse amp rating
Fuse or relay number
Headlamp washer.
20A
1
56
Diesel vaporizer.
20A
1
57
Fuel pump feed.
30A
1
58
600W Electronic fan 3.
40A
2
59
600W Electronic fan 1.
40A
2
60
Left hand side windshield defrost.
40A
1
61
Body control module 1.
50A
2
62
237
Galaxy / S-MAX (CDR) , CG3646en enGBR, Edition date: 01/2015, First Printing
Fuses
Protected components
Fuse amp rating
Fuse or relay number
600W Electronic fan 2.
25A
1
63
Auxiliary heater #3.
30A
1
64
Front heated seat.
20A
1
65
Right hand side windshield defrost.
40A
1
66
Body control module 2.
50A
2
67
Heated rear window.
40A
1
68
Anti-lock brake system valves.
30A
1
69
Passenger seat.
30A
1
70
Auxiliary heater #2.
60A
2
71
Rear power seats.
30A
1
72
Rear heated seats.
20A
1
73
Driver seat module.
30A
1
74
Auxiliary heater #1.
30A
1
75
Transmission oil pump.
20A
1
76
Climate control seat module.
30A
1
77
Trailer tow module.
40A
1
78
Blower motor.
40A
1
79
Power liftgate module.
40A
1
80
220 volt inverter.
40A
1
81
Anti-lock brake system pump.
60A
2
82
Wiper motor #1.
25A
1
83
Starter solenoid.
30A
1
84
238
Galaxy / S-MAX (CDR) , CG3646en enGBR, Edition date: 01/2015, First Printing
Fuses
Protected components
Fuse amp rating
Fuse or relay number
Fuel fire heater.
20A
1
85
Not used.
86
Auxiliary blower motor.
50A
2
87
1
M-type fuse.
2
J-type fuse.
Passenger Compartment Fuse
Panel
The fuse panel is located under the
instrument panel to the left of the steering
column.
Note:
It may be easier to access the fuse
panel if you remove the finish trim piece.
239
Galaxy / S-MAX (CDR) , CG3646en enGBR, Edition date: 01/2015, First Printing
Fuses
Protected components
Fuse amp rating
Fuse or relay number
Lighting (ambient, glove box, vanity, dome,
liftgate).
10A
1
1
Memory seats, lumbar, power mirror.
7.5A
1
2
Driver door unlock.
20A
1
3
Aftermarket electronic trailer brake on/off
switch.
5A
1
4
Ignition switch.
20A
1
5
Push-button ignition switch.
Heated seat relay coil.
10A
2
6
Not used (spare).
10A
2
7
Not used (spare).
10A
2
8
Not used (spare).
10A
2
9
Keypad.
5A
2
10
Power liftgate module.
Not used.
5A
2
11
Climate control.
7.5A
2
12
Steering wheel column lock.
7.5A
2
13
Cluster.
Datalink logic.
Not used.
10A
2
14
Datalink gateway module.
10A
2
15
Child lock.
15A
1
16
Liftgate release.
Not used (spare).
5A
2
17
Ignition.
5A
2
18
Push button stop start switch.
Passenger airbag disabled indicator.
7.5A
2
19
Transmission range indicator.
240
Galaxy / S-MAX (CDR) , CG3646en enGBR, Edition date: 01/2015, First Printing
Fuses
Protected components
Fuse amp rating
Fuse or relay number
Not used (spare).
7.5A
2
20
Humidity and in
car temperature sensor.
5A
2
21
Blind spot information system.
Rear video camera.
Adaptive cruise control.
Occupant classification sensor.
5A
2
22
Delayed accessory (power inverter logic,
moonroof logic).
10A
1
23
Central lock unlock.
20A
1
24
Driver door (window, mirror).
30A
1
25
Front passenger door (window, mirror).
30A
1
26
Moonroof.
30A
1
27
Amplifier.
20A
1
28
Rear driver side door (window).
30A
1
29
Rear passenger side door (window).
30A
1
30
Not used (spare).
15A
1
31
Global positioning system.
10A
1
32
Display.
Voice control.
Adaptive cruise control.
Radio frequency receiver.
Radio.
20A
1
33
Run-start bus (fuse 19, 20, 21, 22, 35, 36,
37, circuit breaker).
30A
1
34
Restraints control module.
5A
1
35
Auto-dimming rear view mirror.
15A
1
36
Heated seat.
All-wheel drive.
241
Galaxy / S-MAX (CDR) , CG3646en enGBR, Edition date: 01/2015, First Printing
Fuses
Protected components
Fuse amp rating
Fuse or relay number
Voltage stability module logic power.
15A
1
37
Not used (spare).
30A
38
1
Micro fuse.
2
Dual micro fuse.
CHANGING A FUSE
Fuses
WARNING
Always replace a fuse with one that
has the specified amperage rating.
Using a fuse with a higher amperage
rating can cause severe wire damage and
could start a fire.
If electrical components in the vehicle are
not working, a fuse may have blown. A
break in the fuse wire will indicate a blown
fuse. Check the appropriate fuses before
replacing any electrical components.
242
Galaxy / S-MAX (CDR) , CG3646en enGBR, Edition date: 01/2015, First Printing
Fuses
Battery. See
Changing the 12V Battery
(page 250).
F
Power distribution box. See
Fuses
(page 233).
G
Air filter assembly.
H
Windshield washer fluid reservoir. See
Washer Fluid Check
(page 250).
I
UNDER HOOD OVERVIEW - 2.0L ECOBOOST
Engine coolant reservoir. See
Engine Coolant Check
(page 248).
A
Brake fluid reservoir (right-hand drive). See
Brake Fluid Check
(page 249).
B
Engine oil dipstick. See
Engine Oil Dipstick
(page 247).
C
Engine oil filler cap. See
Engine Oil Check
(page 247).
D
Brake fluid reservoir (left-hand drive). See
Brake Fluid Check
(page 249).
E
Battery. See
Changing the 12V Battery
(page 250).
F
Power distribution box. See
Fuses
(page 233).
G
Air filter assembly.
H
Windshield washer fluid reservoir. See
Washer Fluid Check
(page 250).
I
245
Galaxy / S-MAX (CDR) , CG3646en enGBR, Edition date: 01/2015, First Printing
Maintenance
UNDER HOOD OVERVIEW - 2.0L DURATORQ-TDCI (DW) DIESEL
Engine coolant reservoir. See
Engine Coolant Check
(page 248).
A
Brake fluid reservoir (right-hand drive). See
Brake Fluid Check
(page 249).
B
Engine oil filler cap. See
Engine Oil Check
(page 247).
C
Engine oil dipstick. See
Engine Oil Dipstick
(page 247).
D
Brake fluid reservoir (left-hand drive). See
Brake Fluid Check
(page 249).
E
Battery. See
Changing the 12V Battery
(page 250).
F
Power distribution box. See
Fuses
(page 233).
G
Air filter assembly.
H
Windshield washer fluid reservoir. See
Washer Fluid Check
(page 250).
I
246
Galaxy / S-MAX (CDR) , CG3646en enGBR, Edition date: 01/2015, First Printing
Maintenance