Ford Windstar - 2002 Fuse Box Diagram

Ford Windstar - 2002 Fuse Box Diagram

With the ON/OFF control in the OFF position, either sliding door can be
closed by pulling the inside or outside handle and sliding the door all the
way forward to the latched position manually.
Safety/Obstructions
If anything obstructs the Power Sliding Door while it is closing, the door
will automatically reverse to the open position, provided it meets
sufficient resistance.
Resetting the PSD
The power sliding door may operate incorrectly or not at all because of
the following condition:
a low voltage or dead battery
disconnecting the battery
if the PSD fuse (fuse #6) is removed or blown. Refer to
Fuses and
relays
in the
Roadside emergencies
chapter.
If any of these conditions occur, reset the PSD by:
1. Check to see if power sliding door is unlocked and securely closed.
2. Make sure the gearshift is in (P) Park.
3. Push the power door control on the overhead console to open the
door.
4. Wait five (5) seconds and close the door by pressing the power door
control on the overhead console.
5. Wait five (5) seconds and repeat Steps 3 and 4 and go on to step 6.
6. Repeat steps 3–5 for opposite door.
If the door does not rest in the fully open position, repeat Steps 1–4
again. If the door still does not operate correctly:
7. Turn the ignition switch to OFF.
8. Remove the PSD fuse (fuse #6) from the passenger fuse panel and
leave it out for thirty (30) seconds. Refer to
Fuses and relays
in the
Roadside emergencies
chapter.
9. Reinstall the fuse and wait ten (10) seconds.
10. Repeat steps 1–6 above.
If the door still does not operate correctly, see your dealer for service.
Driver Controls
85
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the air bag
supplemental restraint systems or its fuses. See your Ford or
Lincoln Mercury dealer.
Modifications to the front end of the vehicle, including frame,
bumper, front end body structure and tow hooks may affect the
performance of the air bag sensors increasing the risk of injury. Do not
modify the front end of the vehicle.
Children and air bags
For additional important safety
information, read all information on
safety restraints in this guide.
Children must always be properly
restrained. Accident statistics
suggest that children are safer when
properly restrained in the rear
seating positions than in the front
seating position. Failure to follow
these instructions may increase the
risk of injury in a collision.
Air bags can kill or injure a
child in a child seat.
NEVER
place a rear-facing child
seat in front of an active air bag. If
you must use a forward-facing
child seat in the front seat, move
the seat all the way back.
Seating and Safety Restraints
157
a readiness light and tone.
diagnostic module.
and the electrical wiring which connects the components.
The diagnostic module monitors its own internal circuits and the
supplemental air bag electrical system warning (including the impact
sensors), the system wiring, the air bag system readiness light, the air
bag back up power and the air bag ignitors.
Side air bag system (if equipped)
Do not place objects or mount equipment on or near the air bag
cover on the side of the seatbacks of the front seats or in front
seat areas that may come into contact with a deploying air bag. Failure
to follow these instructions may increase the risk of personal injury in
the event of a collision.
Do not use accessory seat covers. The use of accessory seat
covers may prevent the deployment of the side air bags and
increase the risk of injury in an accident.
Do not lean your head on the door. The side air bag could injure
you as it deploys from the side of the seatback.
Do not attempt to service, repair, or modify the air bag
supplemental restraint system, its fuses or the seat cover on a
seat containing an air bag. See your Ford or Lincoln Mercury dealer.
All occupants of the vehicle including the driver should always
wear their safety belts even when an air bag SRS is provided.
Seating and Safety Restraints
160
Do not operate the vehicle with a low power steering pump fluid level
(below the MIN mark on the reservoir).
If the power steering system breaks down (or if the engine is turned
off), you can steer the vehicle manually, but it takes more effort.
If the steering wanders or pulls, the condition could be caused by any of
the following:
underinflated tire(s) on any wheel(s)
uneven vehicle loading
high crown in center of road
high crosswinds
wheels out of alignment
loose or worn suspension components
AUTOMATIC TRANSAXLE OPERATION
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) unless the brake
pedal is depressed.
If the gearshift lever cannot be moved from P (Park) with the brake
pedal depressed, it is possible that a fuse has blown or the vehicle’s
brakelamps are not operating properly. Refer to
Fuses and relays
in the
Roadside emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
If your vehicle gets stuck in mud or snow it may be rocked out by
shifting between forward and reverse gears, stopping between shifts, in a
steady pattern. Press lightly on the accelerator in each gear.
Do not rock the vehicle if the engine is not at normal operating
temperature or damage to the transaxle may occur.
Do not rock the vehicle for more than a few minutes or damage
to the transaxle and tires may occur or the engine may overheat.
Driving
186
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
15
Roadside Emergencies
203
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the panel cover to access the fuses.
To remove a fuse use the fuse puller tool provided on the fuse panel
cover.
Your vehicle is equipped with a Pull Fuse feature that when used, can
extend the duration of your battery life while your vehicle is parked for
long periods of time. This time will be increased from 31 days to 45 – 55
days (based on option content). You should use this feature when your
vehicle will be parked for long periods of times to ensure the vehicle
starts upon your return.
The pull fuse is located under the instrument panel and is visible from
the exterior of the fuse panel cover.
The fuse holder is designed to allow you to pull the fuse (#6) from the
fuse panel circuit without having to completely remove it from the fuse
panel. The fuse and fuse holder will remain in the fuse panel.
If the fuse (#6) must be replaced, the fuse and fuse holder can be
removed by pulling it completely out from the fuse panel cover.
With the fuse (#6) removed, the following systems will not be functional:
radio
power sliding door(s) – (if equipped)
keyless entry system– (if equipped)
When the pull fuse is reinstalled, the following features will need to be
reset.
radio pre-sets
power sliding door(s) – (if equipped)
Please refer to the
Entertainment
chapter and
Power Sliding Door
section in the
Driver controls
chapter for instructions to reset these
features.
Roadside Emergencies
204
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
1
10A
Right Stepwell Lamp, Left
Stepwell Lamp, Right Puddle
Lamp, Left Puddle Lamp, Left 2nd
Row Reading Lamp, Right 2nd
Row Reading Lamp, Left 3rd Row
Reading Lamp, Right 3rd Row
Reading Lamp, Cargo Lamp,
Dome Lamp, Map Lamp, LH
Visor/Vanity Lamp, RH
Visor/Vanity Lamp, Remote
Keyless Entry Keypad, Left Turn
Signal Mirror, Right Turn Signal
Mirror
2
25A
Glove Box Lamp, LH I/P Courtesy
Lamp, RH I/P Courtesy Lamp,
Video Cassette Player
RELAY 1
RELAY 2
RELAY 3
RELAY 4
RELAY 5
RELAY 6
FUSE 1
FUSE 7
FUSE 12
FUSE 18
FUSE 24
FUSE 8
FUSE 13
FUSE 19
FUSE 25
FUSE 9
FUSE 14
FUSE 20
FUSE 26
FUSE 10
FUSE 15
FUSE 21
FUSE 27
FUSE 11
FUSE 16
FUSE 22
FUSE 28
FUSE 17
FUSE 23
FUSE 29
FUSE 2
FUSE 3
FUSE 4
FUSE 5
FUSE 6
Roadside Emergencies
205
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
3
15A
LH Power Mirror Motor, RH
Power Mirror Motor, Adjustable
Pedal Motor, Memory Module (if
equipped)
4
Not Used
5
20A
Console Power Point
6
15A
Radio, Compact Disc Changer,
Remote Keyless Entry Module,
PSD (Power Sliding Door) Module
RH and LH, Rear Seat Radio
Controller (if equipped), Rear
Seat Entertainment Module (if
equipped)
7
15A
Left Rear Turn Lamp, Right
Backup Lamp, Right Stop Lamp,
Right Rear Park Lamp, Right
License Lamp, Left License Lamp,
LH Backup Lamp
8
20A
Rear Electronic Module (RHF/RH
Sliding/LH Sliding/Liftgate Door
Lock Motors, Aux. Air Blend Door
Motor, Aux. Air Mode Door
Motor)
9
10A
Cluster, Powertrain Control
Module Relay (coil)
10
15A
Heated Backlite Relay (coil),
Speed Control Module, ABS
Module or IVD Module, Heat Seat
Switch (RH/LH) (if equipped),
Heated Seat Module (RH/LH) (if
equipped), Cluster, Front Temp
Blend Door Actuator, Brake Shift
Interlock Solenoid, Powertrain
Control Module, Power Sliding
Door Module RH and LH, Reverse
Sensing System, Front A/C
Control Head, Steering Wheel
Angle Sensor (if equipped)
Roadside Emergencies
206
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
11
15A
Electric Brake Controller, Brake
Shift Interlock Solenoid, Rear
Electronic Module
12
20A
Center High-Mount Stop Lamp
13
10A
Right Rear Turn Lamp, Left Stop
Lamp, Left Rear Park Lamp
14
10A
Autolamp Sensor, Transmission
Overdrive Cancel Switch, Front
Electronic Module, Compass
Module, Electrochromatic Mirror,
Power Sliding Door Overhead
Console Switch
15
20A
Console Power Point
16
10A
Cluster
17
20A
Cigar Lighter/Powerpoint, Datalink
Connector
18
15A
LH Quarter Window Motor, RH
Quarter Window Motor, RH
Window Switch Backlighting, RH
Lock Switch Backlighting, Master
Control Switch (LH) Backlighting,
Radio, Video Cassette Player,
Liquid Crystal Display, Front
Electronic Module
19
10A
Starter Interrupt Relay (coil)
20
Not Used
21
Not Used
22
10A
LH Heated Mirror, RH Heated
Mirror
23
20A
Body Powerpoint, Auxiliary
Blower Relay #1 and #2 Coils
24
Not Used
25
10A
Radio (Anti-theft)
Roadside Emergencies
207
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
26
10A
Airbag Module, Passenger airbag
deactivated indicator, Passenger
Seat Weight Pressure sensor ECU
27
Not Used
28
10A
Cluster
29
Not Used
Relay 1
Switched System Power Relay #4
Relay 2
Accessory Delay Relay
Relay 3
Front Blower Motor Relay
Relay 4
Switched System Power Relay #3
Relay 5
Rear Defrost Relay
Relay 6
Auxiliary Blower Motor Relay
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
Always replace the cover to the power distribution box before
reconnecting the battery or refilling fluid reservoirs
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and specifications
chapter.
Roadside Emergencies
208
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
1
30A*
Powertrain Control Module Relay
2
10A*
Powertrain Control Module, Front
Electronic Module
3
10A*
A/C Compressor Clutch
4
25A*
Horns, Horn Relay (coil)
5
15A*
Fuel Pump Motor, Powertrain
Control Module
6
30A*
Front Wiper Motor, Front Wiper
Relay, Front Washer Pump, FEM
7
25A*
Rear Wiper Motor, Rear Washer
Pump, Rear Wiper Relay (coil)
8
Not Used
9
15A*
Right Headlamp (Low and High
Beam)
10
15A*
Right Front Park Lamp, Right
Front Turn Lamp, Right Front
Cornering Lamp, Right Front
Auxiliary Driving Lamp
503
304
303
302
301
502
501
207
201
202
203
204
122
118
114
110
106
102
121
117
113
109
105
101
120
116
112
108
104
119
115
111
107
103
24
209
206
208
18
16
14
12
10
8
6
4
2
17
15
13
11
9
7
5
3
1
205
23
22
21
401
20
19
Roadside Emergencies
209
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
11
15A*
Left Front Park Lamp, Left Front
Turn Lamp, Left Front Cornering
Lamp, Left Front, Auxiliary
Driving Lamp
12
15A*
Left Headlamp (Low and High
Beam)
13
10A*
Alternator Field Sense
14
10A*
Front Electronic Module (LH
Door Lock Motor)
15
20A*
T/T park Lamps
16
20A*
T/T Turn Lamps
17
Not Used
18
Not Used
19
15A*
AX4S Transaxle, Vapor
Management Valve, A/C Clutch
Relay Coil, EGR Control Solenoid,
Engine Fuel Control HO2S #11
Sensor, Engine Fuel Control HO2S
#21 Sensor, Catalyst Monitor
HO2S #12 Sensor, Catalyst
Monitor HO2S #22 Sensor,
Canister Vent Solenoid, Intake
Manifold Runner Control
20
15A*
Ignition Coil, Intake Air Control
Valve, Fuel Injectors #1, #2, #3,
#4, #5, #6, Mass Air Flow Sensor,
Fuel Pump Relay Coil, Intake
Manifold Runner Control,
HI-Speed Cooling Fan Relay Coil,
LO-Speed Cooling Fan Relay Coil,
Powertrain Control Module,
Passive Anti-Theft Receiver
21
Not Used
22
Not Used
23
Not Used
24
Not Used
Roadside Emergencies
210
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
101
40A**
ABS Module or IVD Module
102
40A**
ABS Module or IVD Module
103
40A**
SSP4 Relay, SSP4 Relay (coil)
104
30A**
LH Power Seat Motors (if
equipped), LH Power Lumbar
Motor (if equipped), Driver Seat
Memory Module (if equipped)
105
30A**
Starter Motor Solenoid, Ignition
Switch
106
30A**
Delayed Accessory Relay, Delayed
Accessory Relay (coil), Front
Electronic Module, RHF Window
Motor
107
50A**
RH/LH Engine Cooling Fan
Motors, Cooling Fan Dropping
Resistor
108
Not Used
109
30A**
Heated Seat Modules (RH/LH)
110
50A**
RH Power Sliding Door Module
111
40A**
Fuse Junction Box
112
30A**
Trailer Tow, Electric Brake
Controller
113
30A**
Front Electronic Module (LH
Window Motor)
114
40A**
SSP3 Relay, SSP3 Relay (coil)
115
50A**
Fuse Junction Box Bus #2
116
30A**
Heated Backlight Relay
117
40A**
Auxiliary Blower Relay (coil),
Auxiliary Blower Motor
118
50A**
LH Power Sliding Door Module
119
30A**
Fuse Junction Box Bus #1
120
40A**
Front Blower Relay (coil), Front
Blower Motor
Roadside Emergencies
211
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
121
20A**
Ignition Switch, Rear Defrost
Relay (coil)
122
40A**
RH Power Seat Motors, RH Power
Lumbar Motor
201
Not Used
202
Front Wiper ON/OFF Relay
203
Rear Wiper Relay
204
A/C Clutch Relay
205
Horn Relay
206
Not Used
207
Fuel Pump Relay
208
Not Used
209
Front Wiper Hi/Low Relay
301
Starter Interrupt Relay
302
High Speed Engine Cooling Fan
Relay
303
Low Speed Engine Cooling Fan
Relay
304
Powertrain Control Module Relay
401
Not Used
501
Powertrain Control Module Diode
502
Not Used
503
Not Used
* Mini Fuses ** Maxi Fuses
CHANGING THE TIRES
If you get a flat tire while driving, do not apply the brake heavily.
Instead, gradually decrease your speed. Hold the steering wheel firmly
and slowly move to a safe place on the side of the road. If your Low tire
warning light is on, refer to
Low tire warning
in the
Maintenance and
specifications
chapter.
Roadside Emergencies
212