Ford Transit Connect - 2010 Fuse Box Diagram

Ford Transit Connect - 2010 Fuse Box Diagram

OVERHEAD STORAGE SHELF
The storage shelf above the
windshield can be used for storing
light objects such as safety jackets,
coats, etc.
WARNING:
Do not place heavy or hard objects in the overhead
storage, which may fall while driving, and could cause serious
injury.
AUXILIARY POWER POINTS (12VDC)
Power outlets are designed for accessory plugs only. Do not insert
any other object in the power outlet as this will damage the
outlet and blow the fuse. Do not hang any type of accessory or
accessory bracket from the plug. Improper use of the power
outlet can cause damage not covered by your warranty.
The auxiliary power point(s) is
located near the transmission shift
lever.
Your vehicle may also include an auxiliary power point located in the
rear cargo area.
Do not use the power point for operating a cigarette lighter element.
To prevent the fuse from being blown, do not use the power point(s)
over the vehicle capacity of 12 VDC/180W. If the power point or cigar
lighter socket is not working, a fuse may have blown. Refer to
Fuses and
relays
in the
Roadside Emergencies
chapter for information on
checking and replacing fuses.
Driver Controls
52
WARNING:
All occupants of the vehicle, including the driver,
should always properly wear their safety belts, even when an air
bag supplemental restraint system (SRS) is provided.
WARNING:
Always transport children 12 years old and under in
a rear seating position, and always properly use appropriate child
restraints. Never place a rear-facing child seat in front of an active
airbag. If you must transport a forward-facing child in the front seat,
move the seat all the way back and use appropriate restraints.
WARNING:
National Highway Traffic Safety Administration
(NHTSA) recommends a minimum distance of at least 10 inches
(25 cm) between an occupant’s chest and the driver airbag module.
WARNING:
Never place your arm over the air bag module as a
deploying air bag can result in serious arm fractures or other
injuries.
To properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly one or two degrees from the upright position.
WARNING:
Do not put anything on or over the air bag module.
Placing objects on or over the air bag inflation area may cause
those objects to be propelled by the air bag into your face and torso
causing serious injury.
WARNING:
Do not attempt to service, repair, or modify the
airbag supplemental restraint systems or its fuses. Contact your
authorized dealer as soon as possible.
WARNING:
Modifying or adding equipment to the front end of
the vehicle (including frame, bumper, front end body structure
and tow hooks) may affect the performance of the airbag system,
increasing the risk of injury. Do not modify the front end of the
vehicle.
Seating and Safety Restraints
93
A difficulty with the system is indicated by one or more of the following:
The readiness light will either
flash or stay lit.
The readiness light will not
illuminate immediately after
ignition is turned on.
A series of five beeps will be heard. The tone pattern will repeat
periodically until the problem and/or light are repaired.
If any of these things happen, even intermittently, contact your
authorized dealer as soon as possible. Unless serviced, the system may
not function properly in the event of a collision.
Seat-mounted side airbag system
WARNING:
Do not place objects or mount equipment on or
near the airbag cover on the side of the seatbacks of the front
seats or in front seat areas that may come into contact with a
deploying airbag. Failure to follow these instructions may increase the
risk of personal injury in the event of a collision.
WARNING:
Do not use accessory seat covers. The use of
accessory seat covers may prevent the deployment of the side
airbags and increase the risk of injury in an accident.
WARNING:
Do not lean your head on the door. The side airbag
could injure you as it deploys from the side of the seatback.
WARNING:
Do not attempt to service, repair, or modify the
airbag SRS, its fuses or the seat cover on a seat containing an
airbag. Contact your authorized dealer as soon as possible.
WARNING:
All occupants of the vehicle should always wear
their safety belts even when an airbag SRS is provided.
Seating and Safety Restraints
101
BRAKE-SHIFT INTERLOCK
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the on position unless the brake pedal is pressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the on position and the brake pedal pressed:
1. Apply the parking brake, turn ignition key to off, then remove the key.
2. Using a flat head screwdriver, remove the plastic cover.
3. Insert the ignition key and push it
straight down to release the
interlock.
4. Apply the parking brake, then
shift to N (Neutral).
5. Start the vehicle.
Note:
Starting
the vehicle in N (Neutral) still
requires following the steps in the
Preparing to start your vehicle
section.
6. To drive, with the brake pedal
still pressed, release the parking
brake and shift to D (Drive) or R (Reverse).
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
Emergencies
chapter.
WARNING:
Do not drive your vehicle until you verify that the
brakelamps are working.
WARNING:
Always set the parking brake fully and make sure
the gearshift is latched in P (Park). Turn the ignition to the off
position and remove the key whenever you leave your vehicle.
WARNING:
If the parking brake is fully released, but the brake
warning lamp remains illuminated, the brakes may not be
working properly. See your authorized dealer.
Driving
166
FUEL PUMP SHUT-OFF SWITCH
This device stops the electric fuel pump from sending fuel to the engine
when your vehicle has had a substantial jolt.
After an accident, if the engine cranks but does not start, this switch
may have been activated.
The fuel pump shut-off switch is
accessible from behind the glove
box. The button will be raised when
the switch is activated.
To reset the switch:
1. Turn the ignition off.
2. Check the fuel system for leaks.
3. If no leaks are apparent, open the
glove box then push in the sides
and swing the glove box down.
4. Reset the switch by pushing in
the reset button.
5. Turn the ignition on.
6. Wait a few seconds and return
the key to off.
7. Make another check for leaks.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
15
Roadside Emergencies
174
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
Yellow
70A
Tan
Brown
80A
Natural
Black
Black
Roadside Emergencies
175
Passenger compartment fuse panel
The fuse panel and relay box are located below the instrument panel to
the left of the steering wheel.
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
120
Headlamps, Daytime Running
Lamps (DRL) relay
121
Not used
122
Rear window defroster relay
123
Heater blower relay
124
Interior lamps relay
125
Windshield wipers relay
126
Rear unlock relay
130
15A
Hazard flashers
Roadside Emergencies
176
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
131
5A
Power mirrors
132
10A
Light switch, Exterior lighting
133
Not used
134
Not used
135
Not used
136
15A
Horn
137
7.5A
Tire Pressure Monitor System
(TPMS), Radio, Instrument
cluster
138
Not used
139
Not used
140
Not used
141
10A
Rear fog lamps
142
15A
Brake lamps
143
15A
Cigar lighter, Front power point
144
Not used
145
Not used
146
20A
Windshield wipers, Wiper switch
147
Not used
148
7.5A
Recirculation, Instrument cluster
149
Not used
150
Not used
151
15A
Radio, Bluetooth/Voice command
module
152
7.5A
A/C switch, Park aid module
153
7.5A
Interior lamps, Battery saver
154
Not used
155
Not used
156
7.5A
Right parking lamp/tail lamps
157
7.5A
License plate lamps
158
10A
Light switch, Turn signal switch
Roadside Emergencies
177
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
159
Not used
160
Not used
161
7.5A
Anti-lock Brake System
(ABS)/Traction control, Steering
angle sensor
162
7.5A
Airbag module, Passenger airbag
off indicator
163
20A
Locks
164
Not used
165
Not used
166
25A
Front power windows
167
7.5A
Rear window defroster/heated
mirror switch
168
Not used
169
15A
Second power point
170
Not used
171
Not used
172
Not used
173
Not used
174
15A
Rear power point
175
7.5A
Left park lamps/tail lamps
176
Not used
177
Not used
178
25A
Rear window defroster
179
7.5A
Instrument cluster, Passive
anti-theft system (PATS),
Accelerator pedal sensor, TPMS
180
20A
Front and rear window washer
181
Not used
182
Not used
Roadside Emergencies
178
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
WARNING:
Always disconnect the battery before servicing high
current fuses.
WARNING:
To reduce risk of electrical shock, always replace
the cover to the Power Distribution Box before reconnecting the
battery or refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
Note:
To remove the power distribution box cover, the battery negative
cable clip needs to be removed first. Pull up on the clip to detach it from
the battery tray.
25
24
22
23
26
27
28
29
21A
21B
21C
21D
30A
30B
30C
30D
31A
31B
31C
31D
31E
31F
32
33
34
35
36
15
16
17
18
19
20
10
11
12
9
3
4
1
2
5
6
7
8
13
14
Roadside Emergencies
179
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Protected circuits
1
Not used
2
40A**
Passenger compartment fuse
panel
3
20A**
Ignition switch
4
20A**
Fuel pump
5
10A*
Powertrain control module (PCM)
keep alive power, Canister
solenoid
6
15A*
PCM, Data link connector
7
10A*
Backup lamps
8
15A*
Headlamps
9
40A**
Passenger compartment fuse
panel II
10
30A**
Passenger compartment fuse
panel III
11
30A**
Start lock
12
30A**
Anti-lock brake system (ABS)
pump motor
13
30A*
Heater blower motor
14
10A*
PCM relay
15
20A**
ABS/Traction control valves
16
30A**
Cooling fan – low
17
50A**
Cooling fan – high
18
20A**
Daytime Running Lamps (DRL),
Low beam interrupt relay
19
20A**
Tire pressure monitor system
20
A/C clutch relay
21A
Ignition overload relay
21B
Not used
21C
High beam headlamp relay
21D
PCM relay
Roadside Emergencies
180
Fuse/Relay
Location
Fuse Amp
Rating
Protected circuits
22
10A*
PCM, Auxiliary connector
23
10A*
Right low beam headlamp
24
10A*
A/C clutch solenoid
25
10A*
Left low beam headlamp
26
10A*
Mass air flow sensor, Brake
switch, Backup lamps relay
27
Not used
28
15A*
PCM vehicle power 1
29
15A*
Auxiliary connector
30A
70A Relay
Cooling fan high relay
30B
30C
Cooling fan low relay
30D
Start lock relay
31A
Backup lamp relay
31B
Fuel pump relay
31C
DRL relay
31D
Low beam headlamps relay
31E
Not used
31F
Not used
32
Cooling fan diode
33
Fuel pump relay diode
34
Gear shifter diode
35
10A*
PCM ignition sensor
36
Not used
*Mini fuse **Cartridge fuse
CHANGING THE TIRES
If you get a flat tire while driving, do not apply the brake heavily.
Instead, gradually decrease your speed. Hold the steering wheel firmly
and slowly move to a safe place on the side of the road.
Note:
The tire pressure monitoring system (TPMS) indicator light will
illuminate when the spare tire is in use. To restore the full functionality
of the monitoring system, all road wheels equipped with tire pressure
monitoring sensors must be mounted on the vehicle.
Roadside Emergencies
181
FUSE BOX LOCATIONS
E75782
B
A
Engine compartment fuse box
A
Central fuse box
B
Engine compartment fuse box
E75785
2
1
WARNING
Have MAXI fuses (Fuses 1–9 in the
auxiliary fuse box) replaced by a
properly trained technician.
To remove the lid, release the clip and the
hinge on the sides and lift the lid off. When
replacing the lid, press down on both
sides of the hinge (positions
1
and
2
) to
ensure it is closed properly.
Central fuse box
Left-hand drive
E75783
E75784
Right-hand drive
E75786
100
Fuses
1.
Press the sides inwards and allow the
glove box to pivot downwards.
E75787
B
A
Fuse chart label
A
Fuses
B
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by a properly trained
technician.
Switch the ignition and all electrical
equipment off before touching or
attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Note:
You can identify a blown fuse by
a break in the filament.
Note:
All fuses, except high current
fuses, are a push fit.
Note:
A fuse puller is located in the
engine compartment fuse box.
FUSE LABELS
The fuse chart label located on the rear
side of the panel trim will help you identify
the fuses. Depending on the vehicle
variant the necessary fuses and relays
may vary.
The fuse chart label shows rectangles
representing a fuse or relay. The following
information is shown in the rectangles:
E75788
3
2
1
Number of the fuse
1
Symbol of the function
2
Ampere rating of the fuse
3
101
Fuses
FUSE SPECIFICATION CHART
Engine compartment fuse box
Circuits protected
Ampere
rating
Fuse
Central fuse box
40
1
Engine cooling fan - secondary fuse (110 PS)
30
2
Central fuse box
30
3
Heated windscreen
60
4
Engine cooling fan - primary fuse (75 PS/90 PS)
40
5
Engine cooling fan - primary fuse (110 PS)
50
5_A
Glow plugs
60
6
Central fuse box
40
7
Ignition switch
20
8
Engine control module
20
9
Battery voltage sense, data link connector
10
10
Fuel fired heater
20
11
Starter solenoid
20
12
ABS pump
30
13
PCV Valve, VCV Valve
10
14
Main beam left-hand side
10
15
Dipped beam left-hand side
10
16
Dipped beam right-hand side
10
17
PCM Power, Vehicle speed sensor
10
18
Daytime running lamps (side lights)
20
19
PCM
1
20
Not used
-
21
Daytime running lamps (dipped beams)
20
22
ABS valves
20
23
102
Fuses
Circuits protected
Ampere
rating
Fuse
Glow plug monitoring (diesel engines)
10
24
Main beam right-hand side
10
25
Air conditioning clutch solenoid
10
26
Sensors, Actuators, Relay coils
10
27
Foglamps
20
28
Dipped beam (via main beam relay)
20
29
Heater blower motor
30
64
Heated windscreen
7.5
65
Central fuse box
Circuits protected
Ampere
rating
Fuse
GEM flasher power
15
130
Power mirror
5
131
Light switch (30), GEM VBAT Ext. lighting
10
132
Not used
-
133
Not used
-
134
Light switch, daytime running lamps
10
135
Horn
15
136
TPMS, radio, instrument cluster
7.5
137
Not used
-
138
Not used
-
139
Not used
-
140
Back up lamps, heated front washer jets
10
141
Stop lamps
15
142
Cigar lighter, Auxiliary power point front
15
143
103
Fuses
Circuits protected
Ampere
rating
Fuse
Not used
-
144
Not used
-
145
Front wiper motor
20
146
Heated front seats
10
147
GEM VBAT, Recirc / ICL (30-)
7.5
148
Not used
-
149
Not used
-
150
Radio (memory and power), BTVC module
15
151
A/C, parking aid
7.5
152
Interior lamps and battery saver
7.5
153
Not used
-
154
Not used
-
155
Side lamps right-hand side
7.5
156
Number plate lamp
7.5
157
Light switch, Rain sensor
7.5
158
Not used
-
159
Not used
-
160
ABS, ESP, steering angle sensor
7.5
161
Airbag module, PADI indicator
7.5
162
GEM VBATT locking
20
163
Not used
-
164
Not used
-
165
Power windows front
25
166
Heated mirrors, heated rear window
7.5
167
Daytime running lamps, parking lamps, number plate
lamp
10
168
Second power point
15
169
104
Fuses
Circuits protected
Ampere
rating
Fuse
Not used
-
170
Not used
-
171
Not used
-
172
Heated rear window, heated windscreen
7.5
173
Rear power point, Transco hand wash
15
174
Side lamps left-hand side
7.5
175
Not used
-
176
Not used
-
177
Heated rear window
25
178
Cluster, PATS, accelerator pedal
7.5
179
Wiper front and rear
20
180
Not used
-
181
Not used
-
182
105
Fuses
ENGINECOMPARTMENTOVERVIEW-1.8LDURATORQ-TDCI
(LYNX) DIESEL/1.8L DURATORQ-TDDI (LYNX) DIESEL
E75516
A
B
C
D
E
F
G
H
I
Power steering fluid reservoir
1
: See
Power steering fluid check
(page
112).
A
Engine oil filler cap
1
: See
Engine oil check
(page 111).
B
Brake and clutch fluid reservoir
1
: See
Brake and clutch fluid check
(page
112).
C
Engine compartment fuse box: See
Fuses
(page 100).
D
Air cleaner.
E
Washer fluid reservoir
1
: See
Washer fluid check
(page 113).
F
Battery: See
Vehicle battery
(page 117).
G
110
Maintenance