Ford Town Car - 2001 Fuse Box Diagram

Ford Town Car - 2001 Fuse Box Diagram

Always transport children 12 years old and under in the back
seat and always properly use appropriate child restraints.
National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 25 cm (10 inches)
between an occupant’s chest and the driver air bag module.
Never place your arm over the air bag module as a deploying air
bag can result in serious arm fractures or other injuries.
Steps you can take to properly position yourself away from the air bag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the Air Bag
Supplemental Restraint System or its fuses. See your Ford or
Lincoln Mercury dealer.
Modifications to the front end of the vehicle, including frame,
bumper, front end body structure and tow hooks may effect the
performance of the air bag sensors increasing the risk of injury. Do not
modify the front end of the vehicle.
Seating and safety restraints
110
Do not lean your head on the door. The side air bag could injure
you as it deploys from the side of the seatback.
Do not attempt to service, repair, or modify the air bag
Supplemental Restraint System, its fuses or the seat cover on a
seat containing an air bag. See your Ford or Lincoln Mercury dealer.
All occupants of the vehicle including the driver should always
wear their safety belts even when an air bag SRS is provided.
How does the side air bag system work?
The side air bag system consists of
the following:
An inflatable nylon bag (air bag)
with a gas generator concealed
behind the outboard bolster of
the driver and front passenger
seatbacks.
A special seat cover designed to
allow airbag deployment.
The same warning light,
electronic control and diagnostic
unit as used for the front air
bags.
Two crash sensors located under
the outboard side of the front
seats, attached to the floor.
Side air bags, in combination with seat belts, can help reduce the risk of
severe injuries in the event of a significant side impact collision.
The side air bags are fitted on the outboard side of the seatbacks of the
front seats. In certain lateral collisions, the air bag on the side affected
by the collision will be inflated, even if the respective seat is not
occupied. The air bag was designed to inflate between the door panel
and occupant to further enhance the protection provided occupants in
side impact collisions.
Seating and safety restraints
114
If you exceed the load limit, the rear air suspension may not operate.
The air suspension shut-off switch is
located on the left side of the trunk.
If this switch is in the OFF position,
the rear air suspension will not
operate.
On vehicles equipped with
Air Suspension, turn OFF
the Air Suspension switch prior to
jacking, hoisting or towing your
vehicle.
Normal vehicle operation does not
require any action by the driver.
AUTOMATIC TRANSMISSION OPERATION (IF EQUIPPED)
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the ON position unless brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed:
1. Apply the parking brake, turn ignition key to LOCK, then remove the
key.
2. Insert the key and turn it to OFF. Apply the brake pedal and shift to N
(Neutral).
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
AIR SUSPENSION
SWITCH
INTERRUPTEUR DE
LA SUSPENSION
PNEUMATIQUE
WARNING
AVERTISSEMENT
OFF-ARRET
To prevent sudden
vehicle movement,
turn off air suspen-
sion switch prior to
jacking, hoisting or
towing vehicle.
Pour prévenir tout mouvement soudain du véhi-
cule, placer à l'arrêt l'interrupteur de la suspension
pneumatique avant de lever le véhicule (cric ou
pont élévateur) ou de le remorquer.
OFF
Driving
133
The fuel pump shut-off switch is
located on a bracket inside of the
luggage compartment.
Use the following procedure to reset the fuel pump shut-off switch.
1. Turn the ignition to the OFF position.
2. Check the fuel system for leaks.
3. If no fuel leak is apparent, reset the fuel pump shut-off switch by
pushing in on the reset button.
4. Turn the ignition to the ON position. Pause for a few seconds and
return the key to the OFF position.
5. Make a further check for leaks in the fuel system.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
15
Roadside emergencies
145
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause
severe wire damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
Rating
Mini
Fuses
Standard
Fuses
Maxi
Fuses
Cartridge
Maxi
Fuses
Fuse Link
Cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the panel cover to access the fuses.
To remove a fuse use the fuse puller tool provided on the fuse panel
cover.
Roadside emergencies
146
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
1
10A
Lighting Control Module (LCM),
Left-Hand Low Beam Headlamp
2
30A
EATC Blower Motor
3
10A
Lighting Control Module (LCM),
Right-Hand Low Beam Headlamp
4
7.5A
Instrument Cluster
5
7.5A
Lighting Control Module (LCM),
Instrument Panel Light
6
15A
EATC, Heated Seats
7
15A
Lighting Control Module (LCM),
Day/Night Sensor/Amplifier,
Park/Tail Lamps
8
10A
Shift Lock, Speed Control, Air
Suspension, Steering Wheel
Rotation Sensor
27
25
26
24
23
21
22
19
20
18
16
17
15
14
12
13
10
33
31
29
32
30
28
11
9
7
8
6
5
3
4
1
2
RELAY
1
Roadside emergencies
147
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
9
20A
Lighting Control Module (LCM),
Multi-Function Switch, Hi Beam
Headlamps
10
10A
Restraint Control Module (RCM),
Air Bags
11
25A
Brake Pedal Position Switch
(BPP), Brake Pressure Switch,
Fuses 20 and 22
12
15A
Instrument Cluster, Anti-Theft,
Ignition Switch, Ignition Coils
13
10A
Anti-Lock Brake Module, Traction
Control Switch
14
7.5A
Transmission Control Switch,
Lighting Control Module (LCM)
15
20A
Multi-Function Switch, Turn
Signals
16
30A
Wiper Control Module (WCM),
Windshield Wiper Motor
17
10A
Digital Transmission Range (DTR)
Sensor, Back-Up Lamps, EC
Mirrors
18
7.5A
Lighting Control Module (LCM),
Front Radio Control Unit, Cellular
Telephone Transceiver, Electronic
Day/Night Mirror, Compass
Module/Rear Audio/Climate
Control Module
19
10A
EATC, Clock, Instrument Cluster,
PCM
20
7.5A
Lighting Control Module (LCM),
ABS, Shift Lock
21
20A
Multi-Function Switch, Hazard
Lamps
Roadside emergencies
148
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
22
20A
Multi-Function Switch, High
Mounted Stop Lamps, Stop Lamps
23
20A
Datalink Connector, I/P Cigar
Lighter
24
5A
Front Radio Control Unit
25
15A
Lighting Control Module (LCM),
Courtesy/Demand Lamps
26
5A
Digital Transmission Range (DTR)
Sensor, Starter Relay Coil
27
20A
Fuel Filler Door Release Switch
28
10A
Heated Mirrors
29
20A
LF Door Module, Door Locks,
Decklid Release
30
7.5A
LF Seat Module, Trunk Lid
Release Switch, Door Lock
Switches, LF Seat Control Switch,
LF Door Module, Power Mirror
Switch
31
7.5A
Main Light Switch, Lighting
Control Module (LCM)
32
20A
Reardoor Cigar Lighters (Long
Wheel Base Only)
33
15A
Front Radio Control Unit, Digital
Compact Disk Changer, Cellular
Telephone Transceiver
Relay 1
Accessory Delay Relay
(Signature/Cartier) or Power
Window Relay (Executive)
Roadside emergencies
149
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
Always replace the cover to the Power Distribution Box before
reconnecting the battery or refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and care
chapter.
13
14
15
16
17
18
21
22
19
20
23
24
25
26
27
PCM
DIODE
1
2
3
4
5
6
7
8
9
10
11
12
RELAY
1
RELAY
2
RELAY
3
RELAY
4
RELAY
5
Roadside emergencies
150
The high-current fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
1
50A**
Ignition Switch
2
40A**
Ignition Switch
3
50A**
Cooling Fan-High Speed
4
30A**
PCM Power Relay
5
40A**
I/P Fuse Panel, Fuses 11, 19, 21,
23, 25, 27, and 32(Long Wheel
Base Only)
6
Not Used
7
40A**
I/P Fuse Panel, Fuses 1, 3, 5, 7, 9,
31
8
30A**
Driver Power Seat, I/P Fuse
Panel, Fuse 30, Adjustable Pedal,
Passenger Power Seat
9
40A**
Anti-Lock Brakes
10
40A**
Rear Defrost, I/P Fuse Panel, Fuse
28
11
40A**
Accessory Delay Relay
(Signature/Cartier), Power
Window Relay (Executive), I/P
Fuse Panel, Fuse 29,
12
30A**
Air Suspension
13
30A*
Rear Heated Seats (Long Wheel
Base Only)
14
20A*
Rear Power Point (Long Wheel
Base Only)
15
20A*
Rear Power Point (Longe Wheel
Base)
16
30A*
Heated Seats
17
10A*
Air Suspension
18
15A*
Horn
Roadside emergencies
151
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
19
30A*
Subwoofer, I/P Fuse Panel, Fuse
33
20
15A*
Fuel Injectors, PCM
21
15A*
Heated Oxygen Sensors,
Transmission Solenoids, EVAP
Canaster Vent Solenoid, EGR
Vacuum Regulator, EVAP Vapor
Management Valve
22
20A
Fuel Pump
23
15A
Charging System
24
20A*
Auxiliary Power Outlet
25
30A**
Passenger Seat (Long Wheel Base
Only)
26
30A CB**
Cooling Fan-Low Speed
27
20A**
Anti-Lock Brakes
Relay 1
Fuel Pump Relay
Relay 2
A/C Clutch Relay
Relay 3
PCM Power Relay
Relay 4
Air Suspension Relay
Relay 5
Rear Defrost Relay
* Mini Fuses ** Maxi Fuses
CHANGING THE TIRES
If you get a flat tire while driving, do not apply the brake heavily.
Instead, gradually decrease your speed. Hold the steering wheel firmly
and slowly move to a safe place on the side of the road.
Temporary spare tire information
Your vehicle may have a temporary or full-size spare tire. The temporary
spare tire for your vehicle is labeled as such. It is smaller than a regular
tire and is designed for emergency use only. Replace this tire with a
full-size tire as soon as possible.
Roadside emergencies
152
Always transport children 12 years old and under in the back
seat and always properly use appropriate child restraints.
National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 25 cm (10 inches)
between an occupant’s chest and the driver air bag module.
Never place your arm over the air bag module as a deploying air
bag can result in serious arm fractures or other injuries.
Steps you can take to properly position yourself away from the air bag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the Air Bag
Supplemental Restraint System or its fuses. See your Ford or
Lincoln Mercury dealer.
Modifications to the front end of the vehicle, including frame,
bumper, front end body structure and tow hooks may effect the
performance of the air bag sensors increasing the risk of injury. Do not
modify the front end of the vehicle.
Seating and safety restraints
107
Do not lean your head on the door. The side air bag could injure
you as it deploys from the side of the seatback.
Do not attempt to service, repair, or modify the air bag
Supplemental Restraint System, its fuses or the seat cover on a
seat containing an air bag. See your Ford or Lincoln Mercury dealer.
All occupants of the vehicle including the driver should always
wear their safety belts even when an air bag SRS is provided.
How does the side air bag system work?
The side air bag system consists of
the following:
An inflatable nylon bag (air bag)
with a gas generator concealed
behind the outboard bolster of
the driver and front passenger
seatbacks.
A special seat cover designed to
allow airbag deployment.
The same warning light,
electronic control and diagnostic
unit as used for the front air
bags.
Two crash sensors located under
the outboard side of the front
seats, attached to the floor.
Side air bags, in combination with seat belts, can help reduce the risk of
severe injuries in the event of a significant side impact collision.
The side air bags are fitted on the outboard side of the seatbacks of the
front seats. In certain lateral collisions, the air bag on the side affected
by the collision will be inflated, even if the respective seat is not
occupied. The air bag was designed to inflate between the door panel
and occupant to further enhance the protection provided occupants in
side impact collisions.
Seating and safety restraints
111
The air suspension shut-off switch is
located on the left side of the trunk.
If this switch is in the OFF position,
the rear air suspension will not
operate.
On vehicles equipped with
Air Suspension, turn OFF
the Air Suspension switch prior to
jacking, hoisting or towing your
vehicle.
Normal vehicle operation does not
require any action by the driver.
AUTOMATIC TRANSMISSION OPERATION (IF EQUIPPED)
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the ON position unless brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed:
1.
Apply the parking brake, turn ignition key to LOCK, then remove the key.
2. Insert the key and turn it to OFF. Apply the brake pedal and shift to N
(Neutral).
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
If your vehicle gets stuck in mud or snow it may be rocked out by
shifting from forward and reverse gears, stopping between shifts, in a
steady pattern. Press lightly on the accelerator in each gear.
AIR SUSPENSION
SWITCH
INTERRUPTEUR DE
LA SUSPENSION
PNEUMATIQUE
WARNING
AVERTISSEMENT
OFF-ARRET
To prevent sudden
vehicle movement,
turn off air suspen-
sion switch prior to
jacking, hoisting or
towing vehicle.
Pour prévenir tout mouvement soudain du véhi-
cule, placer à l'arrêt l'interrupteur de la suspension
pneumatique avant de lever le véhicule (cric ou
pont élévateur) ou de le remorquer.
OFF
Driving
130
The fuel pump shut-off switch is
located on a bracket inside of the
luggage compartment.
Use the following procedure to reset the fuel pump shut-off switch.
1. Turn the ignition to the OFF position.
2. Check the fuel system for leaks.
3. If no fuel leak is apparent, reset the fuel pump shut-off switch by
pushing in on the reset button.
4. Turn the ignition to the ON position. Pause for a few seconds and
return the key to the OFF position.
5. Make a further check for leaks in the fuel system.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
15
Roadside emergencies
142
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause
severe wire damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
Rating
Mini
Fuses
Standard
Fuses
Maxi
Fuses
Cartridge
Maxi
Fuses
Fuse Link
Cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the panel cover to access the fuses.
To remove a fuse use the fuse puller tool provided on the fuse panel
cover.
Roadside emergencies
143
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment
Fuse Panel Description
1
10A
Lighting Control Module (LCM),
Left-Hand Low Beam Headlamp
2
30A
EATC Blower Motor
3
10A
Lighting Control Module (LCM),
Right-Hand Low Beam Headlamp
4
7.5A
Instrument Cluster
5
7.5A
Lighting Control Module (LCM),
Instrument Panel Light
6
15A
EATC, Heated Seats
7
15A
Lighting Control Module (LCM),
Day/Night Sensor/Amplifier, Park/Tail
Lamps
8
10A
Shift Lock, Speed Control, Air
Suspension, Steering Wheel Rotation
Sensor
9
20A
Lighting Control Module (LCM),
Multi-Function Switch, Hi Beam
Headlamps
27
25
26
24
23
21
22
19
20
18
16
17
15
14
12
13
10
33
31
29
32
30
28
11
9
7
8
6
5
3
4
1
2
RELAY
1
Roadside emergencies
144
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment
Fuse Panel Description
10
10A
Restraint Control Module (RCM), Air
Bags
11
Not Used
12
15A
Instrument Cluster, Anti-Theft, Ignition
Switch, Ignition Coils
13
10A
Anti-Lock Brake Module, Traction
Control Switch
14
7.5A
Transmission Control Switch, Lighting
Control Module (LCM)
15
20A
Multi-Function Switch, Turn Signals
16
30A
Wiper Control Module (WCM),
Windshield Wiper Motor
17
10A
Digital Transmission Range (DTR)
Sensor, Back-Up Lamps, EC Mirrors
18
7.5A
Lighting Control Module (LCM), Front
Radio Control Unit, Cellular Telephone
Transceiver, Electronic Day/Night Mirror,
Compass Module/Rear Audio/Climate
Control Module
19
10A
EATC, Clock, Instrument Cluster, PCM
20
7.5A
Lighting Control Module (LCM), ABS,
Shift Lock
21
20A
Multi-Function Switch, Hazard Lamps
22
20A
Multi-Function Switch, High Mounted
Stop Lamps, Stop Lamps
23
20A
Datalink Connector, I/P Cigar Lighter,
Reardoor Cigar Lighters (Long Wheel
Base Only)
24
5A
Front Radio Control Unit
25
15A
Lighting Control Module (LCM),
Courtesy/Demand Lamps
26
5A
Digital Transmission Range (DTR)
Sensor, Starter Relay Coil
27
20A
Fuel Filler Door Release Switch
Roadside emergencies
145
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment
Fuse Panel Description
28
10A
Heated Mirrors
29
20A
LF Door Module, Door Locks, Decklid
Release
30
7.5A
LF Seat Module, Trunk Lid Release
Switch, Door Lock Switches, LF Seat
Control Switch, LF Door Module, Power
Mirror Switch
31
7.5A
Main Light Switch, Lighting Control
Module (LCM)
32
25A
Brake Pedal Position Switch (BPP),
Brake Pressure Switch, Fuses 20 and 22
33
15A
Front Radio Control Unit, Digital
Compact Disk Changer, Cellular
Telephone Transceiver
Relay 1
Accessory Delay Relay
(Signature/Cartier) or Power Window
Relay (Executive)
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
Always replace the cover to the Power Distribution Box before
reconnecting the battery or refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and care
chapter.
Roadside emergencies
146
The high-current fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
1
50A**
Ignition Switch
2
40A**
Ignition Switch
3
50A**
Cooling Fan-High Speed
4
30A**
PCM Power Relay
5
40A**
I/P Fuse Panel, Fuses 11, 19, 21, 23, 25,
27, and 32(Long Wheel Base Only)
6
Not Used
7
40A**
I/P Fuse Panel, Fuses 1, 3, 5, 7, 9, 31
8
30A**
Driver Power Seat, I/P Fuse Panel, Fuse
30, Adjustable Pedal, Passenger Power
Seat
9
40A**
Anti-Lock Brakes
10
40A**
Rear Defrost, I/P Fuse Panel, Fuse 28
Roadside emergencies
147
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
11
40A**
Accessory Delay Relay
(Signature/Cartier), Power Window Relay
(Executive), I/P Fuse Panel, Fuse 29,
12
30A**
Air Suspension
13
30A*
Rear Heated Seats (Long Wheel Base
Only)
14
20A*
Rear Power Point (Long Wheel Base
Only)
15
20A*
Rear Power Point (Longe Wheel Base)
16
30A*
Heated Seats
17
10A*
Air Suspension
18
15A*
Horn
19
30A*
Subwoofer, I/P Fuse Panel, Fuse 33
20
15A*
Fuel Injectors, PCM
21
15A*
Heated Oxygen Sensors, Transmission
Solenoids, EVAP Canaster Vent Solenoid,
EGR Vacuum Regulator, EVAP Vapor
Management Valve
22
20A
Fuel Pump
23
15A
Charging System
24
20A*
Auxiliary Power Outlet
25
30A**
Passenger Seat (Long Wheel Base Only)
26
30A CB**
Cooling Fan-Low Speed
27
20A**
Anti-Lock Brakes
28
PCM Diode
29
Not used
Relay 1
Fuel Pump Relay
Relay 2
A/C Clutch Relay
Relay 3
PCM Power Relay
Relay 4
Air Suspension Relay
Relay 5
Rear Defrost Relay
* Mini Fuses ** Maxi Fuses
Roadside emergencies
148