Ford Sable - 2009 Fuse Box Diagram

Ford Sable - 2009 Fuse Box Diagram

CENTER CONSOLE
Your vehicle may be equipped with a variety of console features. These
include:
1. Cupholders
2. Utility compartment with coin
holder, a clamshell tray, audio input
jack, USB port and power point
3. Rear power point, vent and (if
equipped) a cupholder
4. Pen holder
WARNING:
Use only soft cups in the cupholder. Hard objects
can injure you in a collision.
AUXILIARY POWER POINT (12VDC)
Power outlets are designed for accessory plugs only. Do not insert
any other object in the power outlet as this will damage the
outlet and blow the fuse. Do not hang any type of accessory or
accessory bracket from the plug. Improper use of the power
outlet can cause damage not covered by your warranty.
The auxiliary power points are
located on the instrument panel and
in the center console utility
compartment.
Do not use the power point for
operating the cigarette lighter
element (if equipped).
To prevent the fuse from being
blown, do not use the power
point(s) over the vehicle capacity of
12 VDC/180W. If the power point or cigar lighter socket is not working, a
fuse may have blown. Refer to
Fuses and relays
in the
Roadside
Emergencies
chapter for information on checking and replacing fuses.
2009 Sable
(mgo)
Owners Guide, 1st Printing
USA
(fus)
Driver Controls
97
WARNING:
All occupants of the vehicle, including the driver,
should always properly wear their safety belts, even when an air
bag supplemental restraint system (SRS) is provided.
WARNING:
When possible, all children 12 years old and under
should be properly restrained in a rear seating position.
WARNING:
National Highway Traffic Safety Administration
(NHTSA) recommends a minimum distance of at least 10 inches
(25 cm) between an occupant’s chest and the driver airbag module.
WARNING:
Never place your arm over the airbag module as a
deploying airbag can result in serious arm fractures or other
injuries.
Steps you can take to properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
WARNING:
Do not put anything on or over the airbag module.
Placing objects on or over the airbag inflation area may cause
those objects to be propelled by the airbag into your face and torso
causing serious injury.
WARNING:
Do not attempt to service, repair, or modify the
airbag supplemental restraint system (SRS) or its fuses. See your
authorized dealer.
WARNING:
Modifying or adding equipment to the front end of
the vehicle (including frame, bumper, front end body structure
and tow hooks) may affect the performance of the airbag system,
increasing the risk of injury. Do not modify the front end of the
vehicle.
2009 Sable
(mgo)
Owners Guide, 1st Printing
USA
(fus)
Seating and Safety Restraints
170
A difficulty with the system is indicated by one or more of the following:
The readiness light (same light
for front and side airbag system)
will either flash or stay lit.
The readiness light will not
illuminate immediately after ignition is turned on.
A series of five beeps will be heard. The tone pattern will repeat
periodically until the problem and/or light are repaired.
If any of these things happen, even intermittently, have the supplemental
restraint system serviced at an authorized dealer immediately. Unless
serviced, the system may not function properly in the event of a
collision.
Seat-mounted side airbag system
WARNING:
Do not place objects or mount equipment on or
near the airbag cover on the side of the seatbacks of the front
seats or in front seat areas that may come into contact with a
deploying airbag. Failure to follow these instructions may increase the
risk of personal injury in the event of a collision.
WARNING:
Do not use accessory seat covers. The use of
accessory seat covers may prevent the deployment of the side
airbags and increase the risk of injury in an accident.
WARNING:
Do not lean your head on the door. The side airbag
could injure you as it deploys from the side of the seatback.
WARNING:
Do not attempt to service, repair, or modify the
airbag SRS, its fuses or the seat cover on a seat containing an
airbag. See your authorized dealer.
WARNING:
All occupants of the vehicle should always wear
their safety belts even when an airbag SRS is provided.
2009 Sable
(mgo)
Owners Guide, 1st Printing
USA
(fus)
Seating and Safety Restraints
178
WARNING:
Several air bag system components get hot after
inflation. Do not touch them after inflation.
WARNING:
If the side
airbag has deployed,
the
airbag will not function again.
The side airbag system
(including the seat) must be
inspected and serviced by an
authorized dealer.
If the airbag
is not replaced, the unrepaired
area will increase the risk of injury
in a collision.
Safety Canopy
²
system
WARNING:
Do not place
objects or mount equipment
on or near the headliner at the
siderail that may come into
contact with a deploying Safety
Canopy
±
. Failure to follow these
instructions may increase the risk
of personal injury in the event of a
collision.
WARNING:
Do not lean your head on the door. The Safety
Canopy
±
could injure you as it deploys from the headliner.
WARNING:
Do not attempt to service, repair, or modify the
Safety Canopy
±
system, its fuses, the A, B, or C pillar trim, or
the headliner on a vehicle containing a Safety Canopy
±
. See your
authorized dealer.
2009 Sable
(mgo)
Owners Guide, 1st Printing
USA
(fus)
Seating and Safety Restraints
180
If the steering wanders or pulls, check for:
an improperly inflated tire
uneven tire wear
loose or worn suspension components
loose or worn steering components
improper steering alignment
AUTOMATIC TRANSMISSION OPERATION
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the on position unless brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the on position and the brake pedal depressed:
1. Apply the parking brake, turn
ignition key to off, then remove the
key.
2. Using a screwdriver (or similar
tool), remove the protective cover
to the interlock release access hole
on the console.
3. Insert the screwdriver (or similar
tool) into the access hole and press
downward while pulling the
gearshift lever out of the P (Park)
position and into the N (Neutral)
position.
4. Remove the tool and reinstall the
protective cover.
5. Start the vehicle and release the
parking brake.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
Emergencies
chapter.
2009 Sable
(mgo)
Owners Guide, 1st Printing
USA
(fus)
Driving
243
FUEL PUMP SHUT-OFF SWITCH
This device stops the electric fuel pump from sending fuel to the engine
when your vehicle has had a substantial jolt.
After an accident, if the engine cranks but does not start, this switch
may have been activated.
The fuel pump shut-off switch is
located in the front passenger
footwell area in the right upper
corner.
To reset the switch:
1. Turn the ignition to the off
position.
2. Check the fuel system for leaks.
3. If no leaks are apparent, reset the
switch by pushing in on the reset
button.
4. Turn the ignition the on position.
5. Wait a few seconds and return
the key to the off position.
6. Make another check for leaks.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
15
2009 Sable
(mgo)
Owners Guide, 1st Printing
USA
(fus)
Roadside Emergencies
257
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
Yellow
70A
Tan
Brown
80A
Natural
Black
Black
2009 Sable
(mgo)
Owners Guide, 1st Printing
USA
(fus)
Roadside Emergencies
258
Passenger compartment fuse panel
The fuse panel is located under the instrument panel to the left of the
steering wheel.
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
1
30A
Smart window motor
2
15A
Brake on/off switch,
High-mounted brake lamp
3
15A
SDARS, Bluetooth, Family
entertainment system (FES)/Rear
seat control
4
30A
Not used (spare)
5
10A
SPDJB logic power
6
20A
Turn signals
7
10A
Low beam headlamps (left)
2009 Sable
(mgo)
Owners Guide, 1st Printing
USA
(fus)
Roadside Emergencies
259
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
8
10A
Low beam headlamps (right)
9
15A
Interior lights, Cargo lamps
10
15A
Backlighting, Puddle lamps
11
10A
All wheel drive
12
7.5A
Memory seat/mirror switches,
Memory module
13
5A
FEPS module
14
10A
Analog clock
15
10A
Climate control
16
15A
Not used (spare)
17
20A
All power lock motor feeds,
Decklid release
18
20A
Not used (spare)
19
25A
Moon roof
20
15A
OBDII connector
21
15A
Fog lamps
22
15A
Park lamps, License lamps
23
15A
High beam headlamps
24
20A
Horn relay
25
10A
Demand lamps/Interior lamps
26
10A
Instrument panel cluster
27
20A
Adjustable pedal switch
28
5A
Radio, Radio start signal
29
5A
Instrument panel cluster
30
5A
Overdrive cancel switch
31
10A
Not used (spare)
32
10A
Not used (spare)
33
10A
Restraint control module
34
5A
AWD module
35
10A
Steering rotation sensor, FEPS,
Rear park assist, Heated seat
modules
2009 Sable
(mgo)
Owners Guide, 1st Printing
USA
(fus)
Roadside Emergencies
260
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
36
5A
PATS module
37
10A
Climate control
38
20A
Subwoofer (Audiophile radio)
39
20A
Radio
40
20A
Spare
41
15A
Moon roof, Front lock switches,
Radio, EC Mirror with compass
(with and without microphone)
42
10A
Not used (spare)
43
10A
Not used (spare)
44
10A
Not used (spare)
45
5A
Relay coils: PDB, Auxiliary A/C,
Front and rear wipers, Front
blower motor
46
7.5A
Occupant Classification Sensor
(OCS), Passenger Airbag
Deactivation Indicator (PADI)
47
30A Circuit
Breaker
Power windows
48
Delayed accessory relay
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
WARNING:
Always disconnect the battery before servicing high
current fuses.
WARNING:
To reduce risk of electrical shock, always replace
the cover to the Power Distribution Box before reconnecting the
battery or refilling fluid reservoirs.
2009 Sable
(mgo)
Owners Guide, 1st Printing
USA
(fus)
Roadside Emergencies
261
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
1
80A*
SPDJB power
2
80A*
SPDJB power
3
30A*
Front wipers
4
Not used
5
Not used
6
Not used
7
50A*
Engine cooling fan
8
Not used
9
40A*
Anti-lock Brake System
(ABS)/AdvanceTrac pump
10
30A*
Starter
11
50A*
Powertrain Control Module (PCM)
relay
12
20A*
ABS/AdvanceTrac valve
13
20A**
Power point (instrument panel)
2009 Sable
(mgo)
Owners Guide, 1st Printing
USA
(fus)
Roadside Emergencies
262
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
14
20A**
Power point (2nd row)
15
Not used
16
20A**
Power point (console)
17
10A**
Alternator
18
Not used
19
Not used
20
40A*
Rear defroster
21
30A*
Power seat motors (passenger)
22
20A*
Heated seat module
23
10A**
PCM Keep alive power, Canister
vent
24
10A**
A/C clutch relay
25
Not used
26
20A**
Backup relay
27
15A**
Fuel relay (Fuel pump driver
module, Fuel pump)
28
Not used
29
Not used
30
Not used
31
Not used
32
30A*
Driver seat motors, Memory
module
33
20A*
Ignition switch (to SJB)
34
Not used
35
40A*
Front A/C blower motor
36
1A Diode
One-touch start
37
1A Diode
Fuel pump
38
10A**
IVD, Yaw rate sensor
39
10A**
Fuel diode, PCM
40
Not used
41
G8VA relay
A/C clutch
2009 Sable
(mgo)
Owners Guide, 1st Printing
USA
(fus)
Roadside Emergencies
263
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
42
G8VA relay
Fuel pump
43
G8VA relay
Backup
44
Not used
45
10A**
Speed control deactivate switch,
Mass air flow sensor, Inline
module VPWR2
46
10A**
A/C clutch relay, VPWR3
47
15A**
PCM VPWR1
48
15A**
PCM VPWR4
49
15A**
Heated mirrors
50
Full ISO relay
PCM relay
51
Not used
52
Not used
53
Full ISO relay
Rear defrost relay
54
Full ISO relay
Blower motor relay
55
Full ISO relay
Starter relay
56
Not used
57
Full ISO relay
Front wiper relay
58
Not used
* Cartridge Fuses ** Mini Fuses
CHANGING THE TIRES
If you get a flat tire while driving:
do not brake heavily.
gradually decrease the vehicle’s speed.
hold the steering wheel firmly.
slowly move to a safe place on the side of the road.
Note:
The tire pressure monitoring system (TPMS) indicator light will
illuminate when the spare is in use. To restore the full functionality of
the monitoring system, all road wheels equipped with tire pressure
monitoring sensors must be mounted on the vehicle.
Have a flat serviced by an authorized dealer in order to prevent damage
to the TPMS sensor, refer to
Changing tires with TPMS
in the
Tires,
Wheels and Loading
chapter. Replace the spare tire with a road tire as
soon as possible.
2009 Sable
(mgo)
Owners Guide, 1st Printing
USA
(fus)
Roadside Emergencies
264