Ford Sable - 1999 Fuse Box Diagram

Ford Sable - 1999 Fuse Box Diagram

Do not put anything on or over the air bag
module. Placing objects on or over the air
bag inflation area may cause those objects to be
propelled by the air bag into your face and torso
causing serious injury.
Do not attempt to service, repair, or modify
the Air Bag Supplemental Restraint System
or its fuses. See your Ford or Lincoln-Mercury
dealer.
Children and air bags
For additional
important safety
information, read all
information on safety
restraints in this guide.
Children must always
be properly restrained.
Accident statistics
suggest that children
are safer when
properly restrained in
the rear seating
positions than in the front seating position. Failure
to follow these instructions may increase the risk of
injury in a collision.
Air bags can kill or injure a child in a child
seat.
NEVER
place a rear-facing child seat
in front of an active air bag. If you must use a
forward-facing child seat in the front seat, move
the seat all the way back.
Seating and safety restraints
85
AUTOMATIC TRANSAXLE OPERATION
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock
feature that prevents the gearshift from being moved
from P (Park) unless the brake pedal is depressed.
If you cannot move the gearshift out of P (Park)
with the brake pedal depressed:
1. Apply the parking brake, turn ignition key to
LOCK, then remove the key.
2. Insert the key and turn it to OFF. Apply the brake
pedal and shift to N (Neutral).
3. Start the vehicle.
If it is necessary to use the above procedure to
move the gearshift, it is possible that a fuse has
blown or the vehicle’s brakelamps are not operating
properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle until you verify
that the brakelamps are working.
If your vehicle gets stuck in mud or snow it may be
rocked out by shifting from forward and reverse
gears, stopping between shifts, in a steady pattern.
Press lightly on the accelerator in each gear.
Do not rock the vehicle for more than a few
minutes. The transmission and tires may be
damaged or the engine may overheat.
Always set the parking brake fully and make
sure the gearshift is latched in P (Park).
Turn off the ignition whenever you leave your
vehicle.
Driving
105
If your vehicle is a
sedan, the Resetting
the fuel shut-off switch
is located on the right
side of the trunk
behind the trunk liner.
If your vehicle is a
wagon, the Resetting
the fuel shut-off switch
is located behind the
service panel on the
right side of the cargo
area.
FUSES AND RELAYS
Fuses
If electrical
components in the
vehicle are not
working, a fuse may
have blown. Blown
fuses are identified by a broken wire within the fuse.
Check the appropriate fuses before replacing any
electrical components.
Always replace a fuse with one that has the
specified amperage rating. Using a fuse with
a higher amperage rating can cause severe wire
damage and could start a fire.
15
Roadside emergencies
119
Standard fuse amperage rating and color
COLOR
Fuse
Rat-
ing
Mini
Fuses
Stan-
dard
Fuses
Maxi
Fuses
Car-
tridge
Maxi
Fuses
Fuse
Link
Car-
tridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is located below and to the left of
the steering wheel by the brake pedal. Remove the
panel cover to access the fuses.
To remove a fuse use the fuse puller tool provided
on the fuse panel cover.
Roadside emergencies
120
The fuses are coded as follows.
Fuse/
Relay
Location
Fuse
Amp
Rating
Description
1
Not Used
2
5A
Instrument Illumination
3
10A
Left Low Beam Headlamp
4
10A
Right Low Beam Headlamp
5
5A
Instrument Cluster, Shift Lock
Actuator, Rear Defrost
6
15A
TR Sensor, Reverse Lamps,
DRL, A/C Controls
7
10A
TR Sensor, Starter Relay
8
5A
Power Antenna, RCU, GEM
9
10A
ABS
10
20A
PCM Relay, Ignition Coil, PATS,
Radio
11
5A
Instrument Cluster
12
5A
Instrument Cluster, Autolamps,
Transmission Control Switch,
ICP, GEM
13
5A
Electronic Crash Unit (ECU),
Blower Motor, EATC
SEE OWNERS MANUAL
CONSULTER LA GUIDE
DRIVER
WINDOW
RELAY
ACCESSORY
DELAY
RELAY
REAR
DEFROST
RELAY
INTERIOR
LAMP
RELAY
DRIVER
UNLOCK
RELAY
BATTERY
SAVER
RELAY
15A
HAZARD
LAMPS
15A
HIGH
BEAM
5A
TAIL
LAMPS
10A
DEF SW
ILLUM
10A
DIAGNOS
15A
DECKLID
RELEASE
10A
BATTERY
SAVER
15A
STOP
LAMPS
20A
CIGAR
5A
MIRRORS
ANTENNA
5A
WIPER &
VAPS
5A
RADIO
30A
FRONT
WIPERS
5A
HEAD LP
ILLUM
15A
REAR
WIPER
5A
RADIO
MEMORY
5A
AIR BAG
5A
LIGHT
OUT MOD
10A
TURN
SIGNAL
20A
RHD
PWR LKS
10A
ABS
20A
EEC
IGN COIL
5A
AIR BAG
ALT LPS
5A
GAUGES
WRN LPS
5A
SHIFT
INTLOCK
15A
BK LPS
AC
10A
STARTER
RELAY
5A
RADIO
MUTE
5A
INSTR
ILLUM
10A
LT LOW
BEAM
10A
RT LOW
BEAM
5A
SWITCH
ILLUM
Roadside emergencies
121
Fuse/
Relay
Location
Fuse
Amp
Rating
Description
14
5A
Semi-Active Ride Control Module
15
10A
Multifunction Switch (Turn
Signal)
16
Not Used
17
30A
Front Wiper/Washer
18
5A
Headlamp Switch
19
15A
Rear Wiper/Washer
20
5A
ICP, RAP, Phone, GEM
21
20A
Cigar Lighter
22
5A
Power Mirrors, Power Antenna,
Luggage Compartment Lamp,
Autolamp
23
5A
GEM, RAP, PATS
24
5A
ICP, RCC, Speedometer
25
10A
Data Link Connector (DLC)
26
15A
Luggage Compartment
27
10A
Battery Saver Relay
28
15A
Speed Control, Brake Lamp
29
15A
Multifunction Switch, (Hazard)
30
15A
High Beams, Daytime Running
Lamps, Instrument Cluster
31
Not Used
32
10A
ICP, Heated Mirrors
33
5A
Power Windows, Lock
Illumination
34
Battery Saver Relay
35
Driver Door Unlock Relay
36
Rear Defroster Relay
37
Interior Lamp Relay
38
One Touch Window Down Relay
39
Accessory Delay Relay
Roadside emergencies
122
Power distribution box
The power distribution
box is located in the
engine compartment.
The power distribution
box contains high-
current fuses that
protect your vehicle’s
main electrical systems
from overloads.
Always disconnect the battery before
servicing high current fuses.
Always replace the cover to the Power
Distribution Box before reconnecting the
battery or refilling fluid reservoirs.
If the battery has been disconnected and
reconnected, refer to the
Battery
section of the
Maintenance and Care
chapter.
Roadside emergencies
123
The high-current fuses are coded as follows.
Fuse/
Relay
Location
Fuse
Amp
Rating
Description
1
40A**
Fuse Junction Panel
2
30A**
PCM Relay
3
40A**
Ignition Switch, Starter Relay
4
30A
C.B.
Accessory Delay Relay, Power
Seat
5
40A**
Ignition Switch
6
Not Used
7
40A**
Rear Window Defrost Relay
8
30A**
Thermactor Air ByPass
Solenoid, EAM Solid State Relay
9
40A**
High Speed Cooling Fan Relay,
Low Speed Cooling Fan Relay
10
20A**
Fuel Pump Relay
11
40A**
Blower Motor Relay
12
Not Used
13
40A**
Anti-Lock Brake Module
14
Not Used
15
15A*
Daytime Running Lamps (DRL)
Module
16
10A*
Electronic Control Unit (ECU)
17
20A*
Rear Control Unit, CD Changer
22
14
13
12
11
10
9
8
7
175A
MEGA-FUSE
6
5
4
3
2
1
21
24
23
28
27
26
25
30
29
31
33
34
32
20
19
18
17
16
15
Roadside emergencies
124
Fuse/
Relay
Location
Fuse
Amp
Rating
Description
18
30A*
Anti-Lock Brake Module
19
15A*
Horn Relay, Powertrain Control
Module (PCM)
20
15A*
Headlamp Switch, Autolamp
Park Relay
21
Not Used
22
30A*
Autolamps Relay, Multifunction
Switch, Headlamp Switch
23
Blower Motor Relay
24
Starter Relay
25
A/C Clutch Relay
26
30A*
Generator
27
10A*
A/C Clutch Relay
28
15A*
Heated Oxygen Sensors,
Canister Vent
29
Fuel Pump Relay
30
PCM Relay
31
Low Speed Cooling Fan Relay
32
PCM Diode
33
A/C Clutch Diode
34
Not Used
* Mini Fuses ** Maxi Fuses
Relays
Relays are located in the power distribution box and
should be replaced by qualified technicians.
Roadside emergencies
125