Ford Ranger - 2005 Fuse Box Diagram

Ford Ranger - 2005 Fuse Box Diagram

5. To prolong the life of the wiper blades, it is highly recommended to
scrape off the ice on the windshield before turning on the wipers. The
layer of ice has many sharp edges and can damage the micro edge of the
wiper rubber element.
TILT STEERING WHEEL (IF EQUIPPED)
To adjust the steering wheel:
1. Pull and hold the steering wheel
release control toward you.
2. Move the steering wheel up or
down until you find the desired
location.
3. Release the steering wheel
release control. This will lock the
steering wheel in position.
Never adjust the steering wheel when the vehicle is moving.
AUXILIARY POWER POINT (12VDC)
Power outlets are designed for
accessory plugs only. Do not
hang any type of accessory or
accessory bracket from the
plugs. Improper use of the
power outlets can cause damage
not covered by your warranty.
The auxiliary power points are
located on the instrument panel. Do
not plug optional electrical
accessories into the cigarette lighter.
Use the power points.
Do not use the power points for operating the cigarette lighter element.
The maximum power each power point can supply depends on the fuse
rating. For example: a 20A fuse should supply a maximum of 240 Watts,
a 15A fuse should supply a maximum of 180 Watts and a 10A fuse should
supply a maximum of 120 Watts. Exceeding these limits will result in a
blown fuse.
Refer to
Passenger Compartment Fuse Panel
in the
Roadside
Emergencies
chapter for fuse ratings in your vehicle.
REVIEW COPY
2005 Ranger
(ran)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Driver Controls
48
National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 25 cm (10 inches)
between an occupant
s chest and the driver air bag module.
Never place your arm over the air bag module as a deploying air
bag can result in serious arm fractures or other injuries.
Steps you can take to properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the Air Bag
Supplemental Restraint System or its fuses. See your Ford or
Lincoln Mercury dealer.
The front passenger air bag is not designed to offer protection to
an occupant in the center front seating position.
Modifying or adding equipment to the front end of the vehicle
(including frame, bumper, front end body structure and tow
hooks) may affect the performance of the air bag system, increasing
the risk of injury. Do not modify the front end of the vehicle.
Additional equipment may affect the performance of the air bag
sensors increasing the risk of injury. Please refer to the
Body
Builders Layout Book
for instructions about the appropriate
installation of additional equipment.
REVIEW COPY
2005 Ranger
(ran)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Seating and Safety Restraints
73
When the key is in the ignition and in the OFF position, the
automatic transmission shift lever can be moved from the P
(Park) position without the brake pedal depressed. To avoid unwanted
vehicle movement, always set the parking brake.
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle
s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
Emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
Always set the parking brake fully and make sure the gearshift is
latched in P (Park). Turn the ignition to the LOCK position and
remove the key whenever you leave your vehicle.
If the parking brake is fully released, but the brake warning lamp
remains illuminated, the brakes may not be working properly.
See your dealer or a qualified service technician.
Driving with a 5
speed automatic transmission (if equipped)
This vehicle is equipped with an adaptive Transmission Shift Strategy.
Adaptive Shift Strategy offers the optimal transmission operation and
shift quality. When the vehicle
s battery has been disconnected for any
type of service or repair, the transmission will need to relearn the normal
shift strategy parameters, much like having to reset your radio stations
when your vehicle battery has been disconnected. The Adaptive
Transmission Strategy allows the transmission to relearn these operating
parameters. This learning process could take several transmission
upshifts and downshifts; during this learning process, slightly firmer
shifts may occur. After this learning process, normal shift feel and shift
scheduling will resume.
REVIEW COPY
2005 Ranger
(ran)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Driving
148
This switch is located under the
right-hand side of the glove box,
just above the carpet.
To reset the switch:
1. Turn the ignition OFF.
2. Check the fuel system for leaks.
3. If no leaks are apparent, reset the
switch by pushing in on the reset
button.
4. Turn the ignition ON.
5. Wait a few seconds and return
the key to OFF.
6. Make another check for leaks.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
15
REVIEW COPY
2005 Ranger
(ran)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
164
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is located under the
right-hand side of the instrument
panel behind the kick panel. A fuse
puller tool is located near the top
left corner of the fuse box; this tool
will assist you in pulling the fuses
out for inspection, if necessary.
REVIEW COPY
2005 Ranger
(ran)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
165
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
1
5A
Instrument panel dimmer switch
2
10A
Trailer tow park lamps
3
10A
Right low beam headlamp
4
10A
Left low beam headlamp
5
30A
Windshield wipers/washer
6
10A
Radio (RUN/ACCY)
7
5A
Headlamp illumination indicator
8
10A
Restraints Control Module (RCM), PADI
(Passenger Air bag Deactivation Indicator)
9
5A
Cluster air bag indicator
10
10A
Cluster (RUN/START), 4x4 module
(RUN/START), Tire Pressure Monitoring
System (TPMS) (RUN/START)
REVIEW COPY
2005 Ranger
(ran)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
166
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
11
10A
Smart Junction Box (SJB) (Logic power)
12
15A
Center console subwoofer amplifier
13
15A
Horn, Interior lamps
14
15A
High beam headlamp, High beam indicator
(cluster)
15
One-touch down relay
16
30A
cartridge
fuse
Power windows
17
15A
Turn signals/Hazards
18
Not used
19
20A
Center High-Mounted Stop Lamp
(CHMSL)/Stop lamps
20
10A
Anti-lock Brake System (ABS) module,
Brake-shift interlock, Speed control
module, Back-up lamps, Overdrive cancel
switch, Electronic flasher (turn/hazard)
21
5A
Starter relay
22
5A
Radio (START), 4x4 Neutral sense
(manual only)
23
30A
Headlamps (low and high beam)
24
20A
Radio
25
Accessory relay
26
2A
Brake pressure switch
27
10A
Climate control blower relay/blend doors,
4x4 module
28
15A
4x4 module B+
29
20A
Cigar lighter or power point, Diagnostic
connector (OBD II)
30
5A
Power mirrors
31
20A
Front park lamps, Rear park lamps,
License plate lamps
REVIEW COPY
2005 Ranger
(ran)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
167
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
32
5A
Brake switch (logic)
33
5A
Instrument cluster, TPMS module
34
20A
Power point
35
15A
Power locks
Power distribution box
The power distribution box is
located in the engine compartment.
The power distribution box contains
high-current fuses that protect your
vehicle
s main electrical systems
from overloads.
Always disconnect the battery before servicing high current
fuses.
To reduce risk of electrical shock, always replace the cover to
the Power Distribution Box before reconnecting the battery or
refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
REVIEW COPY
2005 Ranger
(ran)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
168
2.3L engine (if equipped)
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
1
40A**
Interior fuse panel (SJB)
2
Not used
3
40A**
Interior fuse panel (SJB)
4
Not used
5
50A**
Interior fuse panel (SJB)
6
Not used
7
40A**
Starter
8
Not used
9
40A**
Ignition switch
10
Not used
11
30A**
Powertrain Control Module (PCM), Engine
sensors
12
Not used
13
30A**
Blower motor (climate control)
REVIEW COPY
2005 Ranger
(ran)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
169
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
14
Not used
15
Not used
16
Not used
17
40A**
ABS (motor)
18
Not used
19
20A**
Engine fan
20
Not used
21
10A*
PCM
22
Not used
23
20A*
Fuel pump
24
Not used
25
10A*
A/C clutch solenoid
26
Not used
27
Not used
28
Not used
29
Not used
30
Not used
31
Not used
32
Not used
33
30A*
Anti-lock Brake System (ABS) (solenoids)
34
Not used
35
Not used
36
Not used
37
Not used
38
7.5A*
Trailer tow (right turn)
39
Not used
40
Not used
41
15A*
Heated Exhaust Gas Oxygen (HEGO)
sensors, EVAP canister vent valve,
Exhaust Gas Recirculation (EGR) stepper
motor, Transmission
REVIEW COPY
2005 Ranger
(ran)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
170
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
42
7.5A*
Trailer tow (left turn)
43
Not used
44
Not used
45A
Wiper HI/LO relay
45B
Wiper Park/Run relay
46A
Fuel pump relay
46B
Washer pump relay
47
Engine fan relay
48
Starter relay
49
Not used
50
Not used
51
Not used
52
Not used
53
Not used
54
PCM relay
55
Blower relay
56A
A/C clutch solenoid relay
56B
Not used
* Mini Fuses ** Maxi Fuses
REVIEW COPY
2005 Ranger
(ran)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
171
3.0L and 4.0L engines (if equipped)
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
1
40A**
Interior fuse panel (SJB)
2
40A**
Amplifier (Tremor audio system only)
3
40A**
Interior fuse panel (SJB)
4
Not used
5
50A**
Interior fuse panel (SJB)
6
Not used
7
40A**
Starter
8
Not used
9
40A**
Ignition switch
10
Not used
11
30A**
Powertrain Control Module (PCM), Engine
sensors
12
Not used
13
30A**
Blower motor (climate control)
14
Not used
REVIEW COPY
2005 Ranger
(ran)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
172
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
15
Not used
16
Not used
17
40A**
ABS (motor)
18
Not used
19
Not used
20
Not used
21
10A*
PCM
22
Not used
23
20A*
Fuel pump
24
Not used
25
10A*
A/C clutch solenoid
26
Not used
27
20A*
4x4 module
28
Not used
29
Not used
30
Not used
31
15A*
Foglamps
32
Not used
33
30A*
Anti-lock Brake System (ABS) (solenoids)
34
Not used
35
Not used
36
Not used
37
Not used
38
7.5A*
Trailer tow (right turn)
39
Not used
40
Not used
41
15A*
Heated Exhaust Gas Oxygen (HEGO)
sensors, EVAP canister vent valve,
Exhaust Gas Recirculation (EGR) stepper
motor, Transmission
42
7.5A*
Trailer tow (left turn)
REVIEW COPY
2005 Ranger
(ran)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
173
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
43
Not used
44
Not used
45A
Wiper HI/LO relay
45B
Wiper Park/Run relay
46A
A/C clutch solenoid
46B
Washer pump relay
47
PCM relay
48A
Fuel pump relay
48B
Fog lamp relay
51
Not used
52
Not used
53
Not used
54
Not used
55
Blower relay
56
Starter relay
* Mini Fuses ** Maxi Fuses
JUMP STARTING YOUR VEHICLE
The gases around the battery can explode if exposed to flames,
sparks, or lit cigarettes. An explosion could result in injury or
vehicle damage.
Batteries contain sulfuric acid which can burn skin, eyes and
clothing, if contacted.
Do not attempt to push-start your vehicle. Automatic
transmissions do not have push-start capability; doing so may
damage the catalytic converter.
Preparing your vehicle
When the battery is disconnected or a new battery is installed, the
transmission must relearn its shift strategy. As a result, the transmission
may have firm and/or soft shifts. This operation is considered normal and
will not affect function or durability of the transmission. Over time, the
adaptive learning process will fully update transmission operation.
REVIEW COPY
2005 Ranger
(ran)
, Owners Guide (post-2002-fmt)
(own2002)
,
Market:
USA_English
(fus)
Roadside Emergencies
174