Ford Ranger - 2004 Fuse Box Diagram

Ford Ranger - 2004 Fuse Box Diagram

TILT STEERING WHEEL (IF EQUIPPED)
To adjust the steering wheel:
1. Pull and hold the steering wheel
release control toward you.
2. Move the steering wheel up or
down until you find the desired
location.
3. Release the steering wheel
release control. This will lock the
steering wheel in position.
Never adjust the steering wheel when the vehicle is moving.
AUXILIARY POWER POINT
Power outlets are designed for
accessory plugs only. Do not
hang any type of accessory or
accessory bracket from the
plugs. Improper use of the
power outlets can cause damage
not covered by your warranty.
The auxiliary power points are
located on the instrument panel. Do
not plug optional electrical
accessories into the cigarette lighter.
Use the power points.
Do not use the power points for operating the cigarette lighter element.
The Maximum power each power point can supply depends on the fuse
rating. For example: a 20A fuse should supply a maximum of 240 Watts,
a 15A fuse should supply a maximum of 180 Watts and a 10A fuse should
supply a maximum of 120 Watts. Exceeding these limits will result in a
blown fuse. Refer to
Passenger Compartment Fuse Panel
in the
Roadside Emergencies
chapter for fuse ratings in your vehicle.
Always keep the power point caps closed when not being used.
2004 Ranger
(ran)
Owners Guide (post-2002-fmt)
USA English
(fus)
Driver Controls
46
National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 25 cm (10 inches)
between an occupant
s chest and the driver air bag module.
Never place your arm over the air bag module as a deploying air
bag can result in serious arm fractures or other injuries.
Steps you can take to properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the Air Bag
Supplemental Restraint System or its fuses. See your Ford or
Lincoln Mercury dealer.
The front passenger air bag is not designed to offer protection to
an occupant in the center front seating position.
Modifying or adding equipment to the front end of the vehicle
(including frame, bumper, front end body structure and tow
hooks) may affect the performance of the air bag system, increasing
the risk of injury. Do not modify the front end of the vehicle.
Additional equipment may affect the performance of the air bag
sensors increasing the risk of injury. Please refer to the Body
Builders Layout Book for instructions about the appropriate installation
of additional equipment.
2004 Ranger
(ran)
Owners Guide (post-2002-fmt)
USA English
(fus)
Seating and Safety Restraints
75
When the key is in the ignition and in the OFF position, the
automatic transmission shift lever can be moved from the P
(Park) position without the brake pedal depressed. To avoid unwanted
vehicle movement, always set the parking brake.
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle
s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
Always set the parking brake fully and make sure the gearshift is
latched in P (Park). Turn the ignition to the LOCK position and
remove the key whenever you leave your vehicle.
If the parking brake is fully released, but the brake warning lamp
remains illuminated, the brakes may not be working properly.
See your dealer or a qualified service technician.
Driving with a 5–speed automatic transmission (if equipped)
Your transmission is equipped with an adaptive learning strategy found in
the vehicle computer. This feature is designed to increase durability, and
provide consistent shift feel over the life of the vehicle. A new vehicle or
transmission may have firm and/or soft shifts. This operation is
considered normal and will not affect function or durability of the
transmission. Over time, the adaptive learning process will fully update
transmission operation. Additionally, whenever the battery is
disconnected or a new battery is installed, the strategy must relearn.
P (Park)
This position locks the transmission and prevents the rear wheels from
turning.
2004 Ranger
(ran)
Owners Guide (post-2002-fmt)
USA English
(fus)
Driving
104
This switch is located under the
right-hand side of the glove box,
just above the carpet.
To reset the switch:
1. Turn the ignition OFF.
2. Check the fuel system for leaks.
3. If no leaks are apparent, reset the
switch by pushing in on the reset
button.
4. Turn the ignition ON.
5. Wait a few seconds and return
the key to OFF.
6. Make another check of leaks.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
15
2004 Ranger
(ran)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
134
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is located under the
right-hand side of the instrument
panel behind the kick panel.
2004 Ranger
(ran)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
135
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
1
5A
Instrument panel dimmer switch
2
10A
Trailer tow park lamps
3
10A
Right low beam headlamp
4
10A
Left low beam headlamp
5
30A
Windshield wipers/washer
6
10A
Radio (RUN/ACCY)
7
5A
Headlamp illumination indicator
8
10A
Restraints Control Module (RCM),
PADI (Passenger Air bag
Deactivation Indicator)
9
5A
Cluster air bag indicator
10
10A
Cluster (RUN/START), 4x4
module (RUN/START)
2004 Ranger
(ran)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
136
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
11
10A
Smart Junction Box (SJB) (Logic
power)
12
15A
Center console subwoofer
amplifier
13
15A
Horn, Interior lamps
14
15A
High beam headlamp, High beam
indicator (cluster)
15
One-touch down relay
16
30A cartridge
fuse
Power windows
17
15A
Turn signals/Hazards
18
Not used
19
20A
Center High-Mounted Stop Lamp
(CHMSL)/Stop lamps
20
10A
Anti-lock Brake System (ABS)
module, Brake-shift interlock,
Speed control module, Back-up
lamps, Overdrive cancel switch,
Electronic flasher (turn/hazard)
21
5A
Starter relay
22
5A
Spare
23
30A
Headlamps (low and high beam)
24
20A
Radio
25
Accessory relay
26
2A
Brake pressure switch
27
10A
Climate control blower relay/blend
doors, 4x4 module
28
15A
4x4 module B+
29
20A
Cigar lighter or power point,
Diagnostic connector (OBD II)
30
5A
Power mirrors
2004 Ranger
(ran)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
137
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
31
20A
Front park lamps, Rear park
lamps, License plate lamps
32
5A
Brake switch (logic)
33
5A
Instrument cluster
34
20A
Power point
35
15A
Power locks
Power distribution box
The power distribution box is
located in the engine compartment.
The power distribution box contains
high-current fuses that protect your
vehicle
s main electrical systems
from overloads.
Always disconnect the battery before servicing high current
fuses.
To reduce risk of electrical shock, always replace the cover to
the Power Distribution Box before reconnecting the battery or
refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and specifications
chapter.
2004 Ranger
(ran)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
138
2.3L engine (if equipped)
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
1
50A**
Interior fuse panel (SJB)
2
Not used
3
50A**
Interior fuse panel (SJB)
4
Not used
5
50A**
Interior fuse panel (SJB)
6
Not used
7
40A**
Starter relay fuse
8
Not used
9
40A**
Ignition switch
10
Not used
11
30A**
Powertrain Control Module
(PCM), Engine sensors
12
Not used
13
30A**
Blower motor (climate control)
1
2
3
4
5
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
6
7
8
9
10
55
49
48
54
53
52
51
56
56 B
56 A
50
50 B
50 A
47
45
45 B
45 A
46
46 B
46 A
11
12
13
14
15
16
17
18
19
20
2004 Ranger
(ran)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
139
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
14
Not used
15
30A**
Anti-lock Brake System (ABS)
(solenoids)
16
Not used
17
40A**
ABS (motor)
18
Not used
19
20A**
Engine fan
20
Not used
21
10A*
PCM
22
Not used
23
20A*
Fuel pump
24
Not used
25
10A*
A/C clutch solenoid
26
Not used
27
Not used
28
Not used
29
Not used
30
Not used
31
Not used
32
Not used
33
Not used
34
Not used
35
Not used
36
Not used
37
Not used
38
7.5A*
Trailer tow (right turn)
39
Not used
40
Not used
41
15A*
HEGOs
42
7.5A*
Trailer tow (left turn)
43
Not used
2004 Ranger
(ran)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
140
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
44
Not used
45A
Wiper HI/LO relay
45B
Wiper Park/Run relay
46A
Fuel pump relay
46B
Washer pump relay
47
Engine fan relay
48
Starter relay
49
Not used
50
Not used
51
Not used
52
Not used
53
Not used
54
PCM relay
55
Blower relay
56A
A/C clutch solenoid relay
56B
Not used
* Mini Fuses ** Maxi Fuses
2004 Ranger
(ran)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
141
3.0L and 4.0L engines (if equipped)
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
1
50A**
Interior fuse panel (SJB)
2
40A**
Amplifier (Tremor audio system
only)
3
50A**
Interior fuse panel (SJB)
4
Not used
5
50A**
Interior fuse panel (SJB)
6
Not used
7
40A**
Starter relay fuse
8
Not used
9
40A**
Ignition switch
10
Not used
11
30A**
Powertrain Control Module (PCM)
relay fuse
12
Not used
13
30A**
Blower motor (climate control)
2004 Ranger
(ran)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
142
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
14
Not used
15
30A**
Anti-lock Brake System (ABS)
(solenoids)
16
Not used
17
40A**
ABS (motor)
18
Not used
19
Not used
20
Not used
21
10A*
PCM
22
Not used
23
20A*
Fuel pump
24
Not used
25
10A*
A/C clutch solenoid
26
Not used
27
20A*
4x4 module
28
Not used
29
Not used
30
Not used
31
15A*
Foglamps
32
Not used
33
Not used
34
Not used
35
Not used
36
Not used
37
Not used
38
7.5A*
Trailer tow (right turn)
39
Not used
40
Not used
41
15A*
HEGOs
42
7.5A*
Trailer tow (left turn)
43
Not used
2004 Ranger
(ran)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
143
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
44
Not used
45A
Wiper HI/LO relay
45B
Wiper Park/Run relay
46A
A/C clutch solenoid
46B
Washer pump relay
47
PCM relay
48A
Fuel pump relay
48B
Fog lamp relay
51
Not used
52
Not used
53
Not used
54
Not used
55
Blower relay
56
Starter relay
* Mini Fuses ** Maxi Fuses
CHANGING THE TIRES
If you get a flat tire while driving, do not apply the brake heavily.
Instead, gradually decrease your speed. Hold the steering wheel firmly
and slowly move to a safe place on the side of the road.
The use of tire sealants is not recommended and may damage
your tires.
Spare tire information
Your vehicle may be equipped with a conventional spare tire that may be
different in size (smaller diameter and narrower width) than other tires
on your vehicle. This tire will have a
Caution
label on the wheel (rim).
Some 4x2 models may have a
mini-spare
tire. This tire will have the
words
Temporary Use Only
molded into the tire sidewall. These spare
tires are considered
temporary
. Replace the temporary tire with a tire
of the same size, speed rating and load carrying capacity as the other
road tires as soon as possible
2004 Ranger
(ran)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
144