Ford Ranger - 2003 Fuse Box Diagram

Ford Ranger - 2003 Fuse Box Diagram

TILT STEERING WHEEL (IF EQUIPPED)
To adjust the steering wheel:
1. Pull and hold the steering wheel
release control toward you.
2. Move the steering wheel up or
down until you find the desired
location.
3. Release the steering wheel
release control. This will lock the
steering wheel in position.
Never adjust the steering wheel when the vehicle is moving.
AUXILIARY POWER POINT
Power outlets are designed for
accessory plugs only. Do not
hang any type of accessory or
accessory bracket from the plug.
Improper use of the power
outlet can cause damage not
covered by your warranty.
The auxiliary power point is located
on the instrument panel. Do not
plug optional electrical accessories
into the cigarette lighter. Use the
power point.
Do not use the power point for operating the cigarette lighter element.
The Maximum power each power point can supply depends on the fuse
rating. For example: a 20A fuse should supply a maximum of 240 Watts,
a 15A fuse should supply a maximum of 180 Watts and a 10A fuse should
supply a maximum of 120 Watts. Exceeding these limits will result in a
blown fuse. Refer to
Passenger Compartment Fuse Panel
in the
Roadside Emergencies
chapter for fuse ratings in your vehicle.
Always keep the power point caps closed when not being used.
Driver Controls
51
Steps you can take to properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the Air Bag
Supplemental Restraint System or its fuses. See your Ford or
Lincoln Mercury dealer.
The front passenger air bag is not designed to offer protection to
an occupant in the center front seating position.
Modifying or adding equipment to the front end of the vehicle
(including frame, bumper, front end body structure and tow
hooks) may affect the performance of the air bag system, increasing
the risk of injury. Do not modify the front end of the vehicle.
Additional equipment may affect the performance of the air bag
sensors increasing the risk of injury. Please refer to the Body
Builders Layout Book for instructions about the appropriate installation
of additional equipment.
Seating and Safety Restraints
86
Vehicles with a higher center of gravity such as utility and
four-wheel drive vehicles handle differently than vehicles with a
lower center of gravity. Utility and four-wheel drive vehicles are
not
designed for cornering at speeds as high as passenger cars any more
than low-slung sports cars are designed to perform satisfactorily under
off-road conditions. Avoid sharp turns, excessive speed and abrupt
maneuvers in these vehicles. Failure to drive cautiously could result in
an increased risk of loss of vehicle control, vehicle rollover, personal
injury and death.
Loaded vehicles, with a higher center of gravity, may handle
differently than unloaded vehicles. Extra precautions, such as
slower speeds and increased stopping distance, should be taken when
driving a heavily loaded vehicle.
AUTOMATIC TRANSMISSION OPERATION (IF EQUIPPED)
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the ON position unless the brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed:
1. Apply the parking brake, turn ignition key to LOCK, then remove the
key.
2. Insert the key and turn it to OFF.
Apply the brake pedal and shift
to N (Neutral)
.
In the ignition OFF position, the automatic transmission shift
lever can be moved from the P (Park) position without the brake
pedal depressed. To avoid unwanted vehicle movement, always set the
parking brake.
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle
s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Driving
115
This switch is located in the front
passenger
s footwell, by the kick
panel access cover.
To reset the switch:
1. Turn the ignition OFF.
2. Check the fuel system for leaks.
3. If no leaks are apparent, reset the
switch by pushing in on the reset
button.
4. Turn the ignition ON.
5. Wait a few seconds and return
the key to OFF.
6. Make another check of leaks.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
15
Roadside Emergencies
148
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is located on the
left-hand side of the instrument
panel facing the driver
s side door.
Pull the panel cover outward to
access the fuses.
Roadside Emergencies
149
To remove a fuse use the fuse puller tool provided.
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
1
5A
Power mirror switch
2
10A
Daytime Running Lights (DRL), Back-up
lamps, Transmission, Passenger air bag
deactivation switch, Blower motor relay
3
7.5A
Left stop/turn trailer tow connector
4
Not used
5
15A
4x4 control module
6
2A
Brake pressure switch
7
7.5A
Right stop/turn trailer tow connector
8
Not used
9
7.5A
Brake pedal position switch
10
7.5A
Speed control servo/amplifier assembly,
Generic Electronic Module (GEM), Shift
lock actuator, Turn signals, 4x4
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
29
30
35
36
31
32
33
34
27
28
Roadside Emergencies
150
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
11
7.5A
Instrument cluster, 4x4, Main light switch,
Truck Central Security Module (TCSM),
GEM
12
Not used
13
20A
Brake pedal position switch
14
10A
ABS control module
15
Not used
16
30A
Windshield wiper motor, Wiper HI/LO
relay, Wiper run/park relay
17
20A
Cigar lighter, Data Link Connector (DLC)
18
Not used
19
25A
Powertrain Control Module (PCM) power
diode, Ignition, PATS
20
7.5A
GEM, Radio
21
15A
Hazard flasher
22
20A
Auxiliary power socket
23
Not used
24
7.5A
Clutch Pedal Position (CPP) switch,
Starter interrupt relay
25
Not used
26
10A
Battery saver relay, Auxiliary relay box,
Restraint Central Module (RCM), Generic
Electronic Module (GEM), Instrument
cluster
27
Not used
28
7.5A
GEM, Radio
29
20A
Radio
30
Not used
31
Not used
32
Not used
33
15A
Headlamps, DRL module, Instrument
cluster
Roadside Emergencies
151
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
34
Not used
35
15A or Not
Used
15A: Horn relay (if not equipped with a
truck CSM)
36
Not used
Power distribution box
The power distribution box is
located in the engine compartment.
The power distribution box contains
high-current fuses that protect your
vehicle
s main electrical systems
from overloads.
Always disconnect the battery before servicing high current
fuses.
To reduce risk of electrical shock, always replace the cover to
the Power Distribution Box before reconnecting the battery or
refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and specifications
chapter.
Roadside Emergencies
152
2.3L engine (if equipped)
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
1
50A**
I/P fuse panel
2
Not used
3
Not used
4
Not used
5
Not used
6
50A**
Anti-lock Brake System (ABS) pump
motor
7
30A*
Powertrain Control Module (PCM)
8
20A*
Power door locks, Remote entry
9
Not used
10
Not used
11
50A**
Starter relay, Ignition switch
12
20A*
Power windows
13
Not used
1
2
3
4
5
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
6
7
8
9
10
55
49
48
54
53
52
51
56
56 B
56 A
50
50 B
50 A
47
45
45 B
45 A
46
46 B
46 A
11
12
13
14
15
16
17
18
19
20
Roadside Emergencies
153
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
14
Not used
15
Not used
16
40A**
Blower motor
17
20A**
Auxiliary cooling fan
18
Not used
19
Not used
20
Not used
21
10A*
PCM memory
22
Not used
23
20A*
Fuel pump motor
24
30A*
Headlamps
25
10A*
A/C clutch solenoid
26
Not used
27
Not used
28
30A*
ABS module
29
Not used
30
15A*
Trailer tow
31
20A*
Foglamps, Daytime Running Lamps (DRL)
32
Not used
33
15A*
Park Lamp
34
Not used
35
Not used
36
Not used
37
Not used
38
10A*
Left headlamp low beam
39
Not used
40
Not used
41
20A*
Heated oxygen sensors
42
10A*
Right headlamp low beam
43
(Resistor)
44
Not used
Roadside Emergencies
154
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
45A
Wiper HI/LO
45B
Wiper park/run
46A
Fuel pump
46B
Trailer tow
47
Starter
48
Auxiliary cooling fan
49
Not used
50
Not used
51
Not used
52
Not used
53
PCM Diode
54
PCM
55
Blower
56A
A/C clutch solenoid
56B
Front washer pump
* Mini Fuses ** Maxi Fuses
Roadside Emergencies
155
3.0L and 4.0L engines (if equipped)
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
1
50A**
I/P fuse panel
2
50A**
Amplifier
3
Not used
4
Not used
5
Not used
6
50A**
Anti-lock Brake System (ABS) pump
motor
7
30A*
Powertrain Control Module (PCM)
8
20A*
Power door locks, Remote entry
9
Not used
10
Not used
11
50A**
Starter relay, Ignition switch
12
20A*
Power windows
13
20A*
4x4 Motor
Roadside Emergencies
156
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
14
Not used
15
Not used
16
40A**
Blower motor
17
Not used
18
Not used
19
Not used
20
Not used
21
10A*
PCM memory
22
Not used
23
20A*
Fuel pump motor
24
30A*
Headlamps
25
10A*
A/C clutch solenoid
26
Not used
27
Not used
28
30A*
ABS Module
29
Not used
30
15A*
Trailer tow
31
20A*
Foglamps, Daytime Running Lamps (DRL)
32
Not used
33
15A*
Park lamp
34
Not used
35
Not used
36
Not used
37
Not used
38
10A*
Left headlamp low beam
39
Not used
40
Not used
41
20A*
Heated oxygen sensors
42
10A*
Right headlamp low beam
43
Not used
44
Not used
Roadside Emergencies
157
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
45A
Wiper HI/LO
45B
Wiper park/run
46A
Fuel pump
46B
Trailer tow
47A
A/C clutch solenoid
47B
Front washer pump
48A
Fog lamps
48B
Fog lamp relay
51
Not used
52
Not used
53
PCM Diode
54
PCM
55
Blower
56
Starter
* Mini Fuses ** Maxi Fuses
CHANGING THE TIRES
If you get a flat tire while driving, do not apply the brake heavily.
Instead, gradually decrease your speed. Hold the steering wheel firmly
and slowly move to a safe place on the side of the road.
The use of tire sealants is not recommended and may
compromise the integrity of your tires.
Temporary spare tire information
Your vehicle is equipped with a conventional spare tire that may be
different in size (smaller diameter and narrower width) than other tires
on your vehicle. If this is the case, your spare tire is considered
temporary
and the spare wheel will be labeled as such. Replace this
tire with a tire of the same size, speed rating and load carrying capacity
as the other road tires as soon as possible.
It is not recommended that the vehicle be operated in 4WD modes with
a
temporary
(i.e. dissimilar size) spare. If 4WD operation is necessary,
do not operate above speeds of 16 km/h (10 mph) or for distances above
80 km (50 miles).
Roadside Emergencies
158