Ford Ranger - 2000 Fuse Box Diagram

Ford Ranger - 2000 Fuse Box Diagram

National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 25 cm (10 inches)
between an occupant’s chest and the driver air bag module.
Never place your arm over the air bag module as a deploying air
bag can result in serious arm fractures or other injuries.
Never place a rear facing infant seat in the front seat unless the
passenger air bag is turned off.
Steps you can take to properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the Air Bag
Supplemental Restraint System or its fuses. See your Ford or
Lincoln-Mercury dealer.
Children and air bags
For additional important safety information, read all information on
safety restraints in this guide.
Children must always be properly restrained. Failure to follow these
instructions may increase the risk of injury in a collision.
An infant in a rear-facing seat faces a high risk of serious or fatal
injuries from a deploying passenger air bag. Rear facing infant
seats should NEVER be placed in the front seats, unless the passenger
air bag is turned off. See
Passenger air bag ON/OFF switch.
Seating and safety restraints
85
Use extra caution while becoming familiar with your vehicle. Know the
capabilities and limitations of both you as a driver and your vehicle.
AUTOMATIC TRANSMISSION OPERATION (IF EQUIPPED)
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the ON position unless brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed:
1. Apply the parking brake, turn ignition key to LOCK, then remove the
key.
2. Insert the key and turn it to OFF. Apply the brake pedal and shift to N
(Neutral).
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
If your vehicle gets stuck in mud or snow it may be rocked out by
shifting from forward and reverse gears, stopping between shifts, in a
steady pattern. Press lightly on the accelerator in each gear.
Do not rock the vehicle if the engine is not at normal operating
temperature or damage to the transmission may occur.
Do not rock the vehicle for more than a few minutes or damage
to the transmission and tires may occur or the engine may
overheat.
Always set the parking brake fully and make sure the gearshift is
latched in P (Park). Turn off the ignition whenever you leave
your vehicle.
Driving
111
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause
severe wire damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
Rating
Mini
Fuses
Standard
Fuses
Maxi
Fuses
Cartridge
Maxi
Fuses
Fuse Link
Cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
15
Roadside emergencies
140
Passenger compartment fuse panel
The fuse panel is located on the left
hand side of the instrument panel
facing the driver’s side door. Pull the
panel cover outward to access the
fuses.
To remove a fuse use the fuse puller tool provided on the fuse panel
cover.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
29
30
35
36
31
32
33
34
27
28
Roadside emergencies
141
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment
Fuse Panel Description
1
7.5A
Power Mirror Switch
2
7.5A
Blower Motor Relay, PAD Module, Air Bag
Diagnostic Monitor
3
7.5A
Left Stop/Turn Trailer Tow Connector
4
10A
Left Headlamp
5
Not Used
6
15A
Overdrive, Back-up Lamps, DRL, 4x4
7
7.5A
Right Stop/Turn Trailer Tow Connector
8
10A
Right Headlamp, Fog Lamp Relay
9
7.5A
Brake Pedal Position Switch
10
7.5A
Speed Control Servo/Amplifier Assembly,
Generic Electronic Module (GEM), Shift
Lock Actuator, Blend Door Actuator,
A/C-Heater Assembly, Turn Signals
11
7.5A
Instrument Cluster, Daytime Running
Lights (DRL), RABS Resistor
12
Not Used
13
20A
Brake Pedal Position Switch
14
20A or 10A
20A: If equipped with Rear Anti-Lock Brake
System (RABS) Module.
10A: If equipped with 4 Wheel Anti-Lock
Brake System (4WABS) Module, 4WABS
Main Relay
15
7.5A
Air Bag Indicator Lamp, Alternator
Indicator Lamp
16
30A
Windshield Wiper Motor, Wiper Hi-Lo Relay,
Wiper Run/Park Relay
17
25A
Cigar Lighter, Data Link Connector (DLC)
18
15A
Driver’s Unlock Relay, All-Unlock Relay,
All-Lock Relay
19
25A
PCM Power Diode, Ignition, PATS
20
7.5A
RAP Module, Generic Electronic Module
(GEM), Radio
Roadside emergencies
142
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment
Fuse Panel Description
21
15A
Flasher (Hazard)
22
20A
Auxiliary Power Socket
23
Not Used
24
7.5A
Clutch Pedal Position (CPP) switch, Starter
Interrupt Relay, Anti-Theft
25
Not Used
26
10A
Battery Saver Relay, Electronic Shift Relay,
Interior Lamp Relay, Power Window Relay,
Electronic Shift Control Module, Dome/Map
Lamp, GEM, Instrument Cluster
27
Not Used
28
7.5A
Generic Electronic Module (GEM), Radio
29
15A
Radio
30
10A
RABS Test Connector
31
Not Used
32
Not Used
33
15A
Headlamps, Daytime Running Lamps (DRL)
Module, Instrument Cluster
34
Not Used
35
Not Used
36
Not Used
Roadside emergencies
143
Power distribution box
The power distribution box is
located in the engine compartment.
The power distribution box contains
high-current fuses that protect your
vehicle’s main electrical systems
from overloads.
Always disconnect the battery before servicing high current
fuses.
Always replace the cover to the Power Distribution Box before
reconnecting the battery or refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and care
chapter.
Roadside emergencies
144
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
1
50A**
I/P Fuse Panel
2
40A**
Blower Motor Relay
3
50A**
4 Wheel Anti-Lock Brake System (4WABS)
Module
4
20A**
Power Windows
5
50A**
Ignition Switch, Starter Relay
1
10A*
A/C Relay
2
Not Used
3
20A*
Electronic Shift Relay and Electronic Shift
Control Module
4
20A*
Fog Lamp and Daytime Running Lamps
5
15A
Trailer Tow Park Lamps
6
10A*
Powertrain Control Module
7
30A*
4 Wheel Anti-lock Brake System (4WABS)
Module
8
30A*
PCM Relay
5
4
3
2
1
12
11
10
9
8
7
6
5
4
3
2
1
14
15
13
9
6
10
8
7
5
4
1
2
3
2
1
1
125
MEGAFUSE
11
13
12
14
Roadside emergencies
145
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
9
20A*
Fuel Pump Relay and RAP Module
10
15A*
Horn Relay
11
15A*
Parklamps Relay and Main Light Switch
12
30A*
Main Light Switch and Multifunction Switch
13
15A*
Heated Oxygen Sensor, EGR Vacuum
Regulator, EVR Solenoid, Camshaft Position
Sensor (CMP), Canister Vent Solenoid
14
30A*
Alternator Voltage Regulator
15
Not Used
1
Wiper Park Relay
2
A/C Relay
3
Wiper Hi/Lo Relay
4
PCM Power Relay
5
Fuel Pump Relay
6
Starter Relay
7
Horn Relay
8
Fog Lamp Control Relay
9
Blower Motor Relay
10
Foglamp Isolation Relay
11
Not Used
12
Not Used
13
Park Lamp/Trailer Tow Relay
14
Washer Pump Relay
1
RABS Resistor
1
RABS Diode
2
Electronic Engine Controls Diode
* Mini Fuses ** Maxi Fuses
Roadside emergencies
146