Ford Mountaineer - 2003 Fuse Box Diagram

Ford Mountaineer - 2003 Fuse Box Diagram

Recline the seat slightly one or two degrees from the upright position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the air bag
supplemental restraint systems or its fuses. See your Ford or
Lincoln Mercury dealer.
Modifications to the front end of the vehicle, including frame,
bumper, front end body structure and non-Ford tow hooks may
effect the performance of the air bag sensors increasing the risk of
injury. Do not modify the front end of the vehicle with anything other
than authorized Ford accessories for your vehicle.
Additional equipment may affect the performance of the air bag
sensors increasing the risk of injury. Please refer to the Body
Builders Layout Book for instructions about the appropriate installation
of additional equipment.
Children and air bags
Children must always be properly
restrained. Accident statistics
suggest that children are safer when
properly restrained in the rear
seating positions than in the front
seating position. Failure to follow
these instructions may increase the
risk of injury in a collision.
Air bags can kill or injure a
child in a child seat.
NEVER
place a rear-facing child
seat in front of an active air bag. If
you must use a forward-facing
child seat in the front seat, move
the seat all the way back.
Seating and Safety Restraints
116
Safety Canopy
´
system (if equipped)
Do not place objects or
mount equipment on or
near the headliner at the siderail
that may come into contact with a
deploying Safety Canopy
±
. Failure
to follow these instructions may
increase the risk of personal injury
in the event of a collision.
Do not lean your head on the door. The Safety Canopy
±
could
injure you as it deploys from the headliner.
Do not attempt to service, repair, or modify the Safety Canopy
±
system, its fuses, the A, B, or C pillar trim, or the headliner on a
vehicle containing a Safety Canopy
±
. See your Ford or Lincoln
Mercury dealer.
All occupants of the vehicle including the driver should always
wear their safety belts even when an air bag SRS and Safety
Canopy
±
system is provided.
To reduce risk of injury, do not obstruct or place objects in the
deployment path of the inflatable Safety Canopy
±
.
Seating and Safety Restraints
119
3. Rotate the access panel
(counterclockwise) with a flat head
screw driver until it is lined up to
the access hole in the open position.
4. Insert a tool (or screw driver) into the access hole to override the
brake-shift interlock. Apply the brake and shift into Neutral.
5. Return the cover plate (rotate
clockwise) to the closed position.
Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle
s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
Driving
145
The fuel pump shut-off switch is
located in the passenger
s foot well,
by the kick panel.
Use the following procedure to reset
the fuel pump shut-off switch.
1. Turn the ignition to the OFF
position.
2. Check the fuel system for leaks.
3. If no fuel leak is apparent, reset
the fuel pump shut-off switch by
pushing in on the reset button.
4. Turn the ignition to the ON
position. Pause for a few seconds
and return the key to the OFF
position.
5. Make a further check for leaks in
the fuel system.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
15
Roadside Emergencies
170
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is located below the
instrument panel on the driver
s
side.
To remove a fuse use the fuse puller
tool provided on the fuse panel box.
Roadside Emergencies
171
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
1
30A
Memory seat module, Driver power seat
2
20A
Heated seats, Moonroof
3
20A
Radio, Amplifier, DVD
4
5A
Front wiper module
5
15A
Flasher relay (Turn, hazards)
6
10A
Right horn
7
15A
Heated mirrors
8
Not used (spare)
9
Not used (spare)
10
10A
Heated backlight relay coil, Heated seat
module, A/C clutch contact
11
Not used (spare)
1
6
16
21
26
27
28
29
30
22
23
24
25
17
18
19
20
7
8
9
10
11
12
13
14
15
2
3
4
5
Roadside Emergencies
172
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
12
5A
4x4 module
13
5A
Overdrive cancel switch, Flex fuel sender
14
5A
PATS module
15
5A
Rear wiper module, Cluster, TPMS
16
5A
Power mirror, Manual climate control, TPMS
17
15A
Delayed acc. coil, Battery saver, Glove
compartment lamp, 2nd row courtesy lamps
18
10A
Left horn
19
10A
RCM
20
5A
Driver seat switch, Memory switch, Driver
seat module, BSM, Sunload sensor
21
5A
Instrument cluster, Compass, Flasher coil
22
10A
ABS, IVD Controller
23
15A
Brake pedal position switch, Driver brake
applied relay, Redundant cruise deactivate
switch
24
15A
Cigar lighter, OBD II
25
5A
Mode-Temperature actuator for auxiliary
climate control, Trailer tow battery charge coil
26
7.5A
Park aid, Brake shift interlock, Approach lamp
relay coil, IVD switch
27
7.5A
Electrochromatic mirror, Digital transmission
range sensor - backup lamps
28
5A
Radio (Start)/DVD (Start)
29
10A
Digital transmission range sensor, PWR feed
to fuse #28 (Start feed)
30
5A
Daytime Running Lamps (DRL), Remote
solenoid, DEATC climate controller, Manual
climate control, Manual climate control temp
blend actuator
Roadside Emergencies
173
Passenger compartment fuse panel (top side)
These relays are located on the reverse side of the passenger
compartment fuse panel. See your dealer or a certified technician for
service of this relay box.
Fuse/Relay Location
Description
Relay 1
Flasher relay
Relay 2
Rear defrost
Relay 3
Delayed accessory relay
Relay 4
Open
Relay 5
Battery saver
Relay 6
Open
Relay 7
Open
Roadside Emergencies
174
Power distribution box
The power distribution box is
located in the engine compartment.
The power distribution box contains
high-current fuses that protect your
vehicle
s main electrical systems
from overloads.
Always disconnect the battery before servicing high current
fuses.
To reduce risk of electrical shock, always replace the cover to
the Power Distribution Box before reconnecting the battery or
refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and specifications
chapter.
Roadside Emergencies
175
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
1
60A**
PJB
2
30A**
BSM
3
Not used
4
30A**
Rear defrost
5
40A**
Anti-lock Brake System (ABS) pump
6
60A**
Delayed accessory
7
20A**
Power point #2
8
Not used
9
20A**
Power point #1
10
30A**
ABS module (valves)
11
40A**
PTEC
12
50A**
Ignition relay, Starter relay
13
40A**
Trailer tow battery, Trailer tow turn signals
14
10A*
Daytime Running Lamps (DRL) (Canada)
15
15A*
Memory (PCM/DEATC/Cluster)
16
15A*
Headlamp switch, Foglamp switch
17
20A*
4x4 (v-batt 2)
18
20A*
4x4 (v-batt 1)
19
20A**
High beam relay
20
30A**
Electric brake
21
30A**
Front wiper motor
22
20A**
Low beam
23
30A**
Ignition switch
24
Not used
25
Not used
26
15A*
Fuel pump
27
20A*
Trailer tow lamps
28
20A*
Horn relay
29
60A**
PJB
30
20A**
Rear wiper motor
Roadside Emergencies
176
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
31
Not used
32
Not used
33
30A**
Auxiliary blower motor
34
30A**
Passenger power seat, Adjustable pedals
35
Not used
36
40A**
Blower motor
37
15A*
A/C clutch relay, Transmission
38
15A*
Coil on plug
39
15A*
Injectors, Fuel pump relay
40
15A*
PTEC power
41
15A*
HEGO, VMV, CMS, PTEC
42
10A*
Right low beam
43
10A*
Left low beam
44
15A*
Front foglamps
45
2A*
Brake pressure switch (ABS)
46
20A*
High beams
47
Horn relay
48
Fuel pump relay
49
High beam relay
50
Fog lamp relay
51
DRL relay (Canada)/AdvanceTrac
±
relay
(U.S.)
52
A/C clutch relay
53
Trailer tow right turn relay
54
Trailer tow left turn relay
55
Blower motor relay
56
Starter relay
57
PTEC relay
58
Ignition relay
59
Driver brake applied relay (vehicles equipped
with AdvanceTrac
±
only)
Roadside Emergencies
177
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
60
PCM diode
61
A/C clutch diode
62
30A CB
Power windows circuit breaker
* Mini Fuses ** Maxi Cartridge Fuses
Rear Relay Box
The relay box is located on the rear passenger side quarter trim panel.
See your dealer or a certified technician for service of this relay box.
The relays are coded as follows:
Fuse/Relay Location
Description
Relay 14
Not used
Relay 15
Trailer tow back- up lamps
Relay 16
Not used
Relay 17
Not used
Relay 18
Not used
Relay 19
Trailer tow park lamps
Relay 20
Trailer tow battery charge
Relay 21
Not used
Relay 22
Approach lamps
Roadside Emergencies
178
Fuse/Relay Location
Description
Relay 23
Not used
Diode 3
Not used
Diode 4
Not used
Auxiliary relay box
(Canadian vehicles equipped with AdvanceTrac
´
)
The relay box is located on the front
right fender well underneath the
speed control module.
The relays are coded as follows:
Fuse/Relay Location
Description
Relay 64
AdvanceTrac
±
relay
Relay 65
Open
Relay 66
Open
CHANGING THE TIRES
If you get a flat tire while driving:
do not brake heavily.
gradually decrease the vehicle
s speed.
hold the steering wheel firmly.
slowly move to a safe place on the side of the road.
Roadside Emergencies
179
Illuminated visor mirror
To turn on the visor mirror lamps,
lift the mirror cover.
AUXILIARY POWER POINT
Power outlets are designed for
accessory plugs only. Do not
hang any type of accessory or
accessory bracket from the plug.
Improper use of the power
outlet can cause damage not
covered by your warranty.
Do not plug optional electrical
accessories into the cigarette lighter. Use the power point.
Do not use the power point for operating the cigarette lighter element.
The Maximum power each power point can supply depends on the fuse
rating. For example: a 20A fuse should supply a maximum of 240 Watts,
a 15A fuse should supply a maximum of 180 Watts. Exceeding these
limits will result in a blown fuse.
Always keep the power point caps closed when not being used.
Driver Controls
53
All occupants of the vehicle, including the driver, should always
properly wear their safety belts, even when an air bag (SRS) is
provided.
Always transport children 12 years old and under in the back
seat and always properly use appropriate child restraints.
The National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 25 cm (10 inches)
between an occupant’s chest and the driver air bag module.
Never place your arm over the air bag module as a deploying air
bag can result in serious arm fractures or other injuries.
To properly position yourself away from the air bag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly one or two degrees from the upright position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the air bag
supplemental restraint systems or its fuses. See your Ford or
Lincoln Mercury dealer.
Modifications to the front end of the vehicle, including frame,
bumper, front end body structure and non-Ford tow hooks may
effect the performance of the air bag sensors increasing the risk of
injury. Do not modify the front end of the vehicle with anything other
than authorized Ford accessories for your vehicle.
Additional equipment may affect the performance of the air bag
sensors increasing the risk of injury. Please refer to the Body
Builders Layout Book for instructions about the appropriate installation
of additional equipment.
Seating and Safety Restraints
122
Safety Canopy
Y
system (if equipped)
Do not place objects or
mount equipment on or
near the headliner at the siderail
that may come into contact with a
deploying Safety Canopy
y
. Failure
to follow these instructions may
increase the risk of personal injury
in the event of a collision.
Do not lean your head on the door. The Safety Canopy
y
could
injure you as it deploys from the headliner.
Do not attempt to service, repair, or modify the Safety Canopy
y
system, its fuses, the A, B, or C pillar trim, or the headliner on a
vehicle containing a Safety Canopy
y
. See your Ford or Lincoln
Mercury dealer.
All occupants of the vehicle including the driver should always
wear their safety belts even when an air bag SRS and Safety
Canopy
y
system is provided.
To reduce risk of injury, do not obstruct or place objects in the
deployment path of the inflatable Safety Canopy
y
.
Seating and Safety Restraints
126
5. Return the cover plate (rotate
clockwise) to the closed position.
Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
Always set the parking brake fully and make sure the gearshift is
latched in P (Park). Turn the ignition to the LOCK position and
remove the key whenever you leave your vehicle.
If the parking brake is fully released, but the brake warning lamp
remains illuminated, the brakes may not be working properly.
See your dealer or a qualified service technician.
Driving with a 5–speed automatic transmission
Your transmission is equipped with an adaptive learning strategy found in
the vehicle computer. This feature is designed to increase durability, and
provide consistent shift feel over the life of the vehicle. A new vehicle or
transmission may have firm and/or soft shifts. This operation is
considered normal and will not affect function or durability of the
transmission. Over time, the adaptive learning process will fully update
transmission operation. Additionally, whenever the battery is
disconnected or a new battery installed, the strategy must be relearned.
Driving
150
The fuel pump shut-off switch is
located in the passenger’s foot well,
by the kick panel.
Use the following procedure to reset the fuel pump shut-off switch.
1. Turn the ignition to the OFF position.
2. Check the fuel system for leaks.
3. If no fuel leak is apparent, reset the fuel pump shut-off switch by
pushing in on the reset button.
4. Turn the ignition to the ON position. Pause for a few seconds and
return the key to the OFF position.
5. Make a further check for leaks in the fuel system.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
15
Roadside Emergencies
174
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Roadside Emergencies
175
Passenger compartment fuse panel
The fuse panel is located below the
instrument panel on the driver’s
side.
To remove a fuse use the fuse puller tool provided on the fuse panel box.
1
6
16
21
26
27
28
29
30
22
23
24
25
17
18
19
20
7
8
9
10
11
12
13
14
15
2
3
4
5
Roadside Emergencies
176
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
1
30A
Memory seat module, Driver
power seat
2
20A
Moonroof
3
20A
Radio, Amplifier, DVD
4
5A
Front wiper module
5
15A
Flasher relay (Turn, hazards)
6
10A
Right horn
7
15A
Heated mirrors
8
Not used
9
Not used
10
10A
Heated backlight relay coil,
A/C clutch contact
11
20A
Heated seats
12
Not used
13
5A
Overdrive cancel switch, Flex fuel
sender
14
5A
PATS module
15
5A
Rear wiper module, Cluster, TPMS
16
5A
Power mirror, Manual climate
control, TPMS
17
15A
Delayed acc. coil, Battery saver,
Glove compartment lamp, 2nd
row courtesy lamps, Interior
lamps (front)
18
10A
Left horn
19
10A
RCM
20
5A
Driver seat switch, Driver seat
module, BSM, Sunload sensor
21
5A
Instrument cluster, Compass,
Flasher coil
Roadside Emergencies
177
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
22
10A
ABS
23
15A
Brake pedal position switch
24
15A
Cigar lighter, OBD II
25
5A
Mode-Temperature actuator for
auxiliary climate control, Trailer
tow battery charge coil
26
7.5A
Park aid, Brake shift interlock
27
7.5A
Electrochromatic mirror, Digital
transmission range sensor -
backup lamps
28
5A
Radio (Start)/DVD (Start)
29
10A
Digital transmission range sensor,
PWR feed to fuse #28 (Start feed)
30
5A
Daytime Running Lamps (DRL),
Remote solenoid, DEATC climate
controller, Manual climate control,
Manual climate control temp
blend actuator
Roadside Emergencies
178
Passenger compartment fuse panel (top side)
These relays are located on the reverse side of the passenger
compartment fuse panel. See your dealer or a certified technician for
service of this relay box.
Fuse/Relay Location
Description
Relay 1
Flasher relay
Relay 2
Rear defrost
Relay 3
Delayed accessory relay
Relay 4
Open
Relay 5
Battery saver
Relay 6
Open
Relay 7
Open
Roadside Emergencies
179
Power distribution box
The power distribution box is
located in the engine compartment.
The power distribution box contains
high-current fuses that protect your
vehicle’s main electrical systems
from overloads.
Always disconnect the battery before servicing high current
fuses.
To reduce risk of electrical shock, always replace the cover to
the Power Distribution Box before reconnecting the battery or
refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and specifications
chapter.
Roadside Emergencies
180
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
1
60A**
PJB
2
30A**
BSM
3
Not used
4
30A**
Rear defrost
5
40A**
Anti-lock Brake System (ABS)
pump
6
60A**
Delayed accessory
7
20A**
Power point #2
8
Not used
9
20A**
Power point #1
10
30A**
ABS module (valves)
11
40A**
PTEC
12
50A**
Ignition relay, Starter relay
13
40A**
Trailer tow battery, Trailer tow
turn signals
14
10A*
Daytime Running Lamps (DRL)
(Canada)
15
15A*
Memory (PCM/DEATC/Cluster),
Interior lights
16
15A*
Headlamp switch, Foglamp switch
17
Not used
18
Not used
19
20A**
High beam relay
20
30A**
Electric brake
21
30A**
Front wiper motor
22
20A**
Low beam
23
30A**
Ignition switch
24
Not used
25
Not used
26
15A*
Fuel pump
27
20A*
Trailer tow lamps
Roadside Emergencies
181
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
28
20A*
Horn relay
29
60A**
PJB
30
20A**
Rear wiper motor
31
Not used
32
Not used
33
30A**
Auxiliary blower motor
34
30A**
Passenger power seat, Adjustable
pedals
35
Not used
36
40A**
Blower motor
37
15A*
A/C clutch relay, Transmission
38
15A*
Coil on plug
39
15A*
Injectors, Fuel pump relay
40
15A*
PTEC power
41
15A*
HEGO, VMV, CMS, PTEC
42
10A*
Right low beam
43
10A*
Left low beam
44
15A*
Front foglamps
45
2A*
Brake pressure switch (ABS)
46
20A*
High beams
47
Horn relay
48
Fuel pump relay
49
High beam relay
50
Fog lamp relay
51
DRL relay (Canada)
52
A/C clutch relay
53
Trailer tow right turn relay
54
Trailer tow left turn relay
55
Blower motor relay
56
Starter relay
57
PTEC relay
Roadside Emergencies
182
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
58
Ignition relay
59
Not used
60
PCM diode
61
A/C clutch diode
62
30A CB
Power windows circuit breaker
* Mini Fuses ** Maxi Cartridge Fuses
Rear relay box
The relay box is located on the rear passenger side quarter trim panel.
See your dealer or a certified technician for service of this relay box.
The relays are coded as follows:
Fuse/Relay Location
Description
Relay 14
Not used
Relay 15
Trailer tow back-up lamps
Relay 16
Not used
Relay 17
Not used
Roadside Emergencies
183
Fuse/Relay Location
Description
Relay 18
Not used
Relay 19
Trailer tow park lamps
Relay 20
Trailer tow battery charge
Relay 21
Not used
Relay 22
Not used
Relay 23
Not used
Diode 3
Not used
Diode 4
Not used
Auxiliary relay box
The relay box is located on the front
right fender well underneath the
speed control module.
The relays are coded as follows:
Fuse/Relay Location
Description
Relay 64
Open
Relay 65
Open
Relay 66
Open
Roadside Emergencies
184
Illuminated visor mirror
To turn on the visor mirror lamps,
lift the mirror cover.
AUXILIARY POWER POINT
Power outlets are designed for
accessory plugs only. Do not
hang any type of accessory or
accessory bracket from the plug.
Improper use of the power
outlet can cause damage not
covered by your warranty.
Do not plug optional electrical
accessories into the cigarette lighter. Use the power point.
Do not use the power point for operating the cigarette lighter element.
The Maximum power each power point can supply depends on the fuse
rating. For example: a 20A fuse should supply a maximum of 240 Watts,
a 15A fuse should supply a maximum of 180 Watts. Exceeding these
limits will result in a blown fuse.
Always keep the power point caps closed when not being used.
Driver Controls
53
Never place your arm over the air bag module as a deploying air
bag can result in serious arm fractures or other injuries.
To properly position yourself away from the air bag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly one or two degrees from the upright position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the air bag
supplemental restraint systems or its fuses. See your Ford or
Lincoln Mercury dealer.
Modifications to the front end of the vehicle, including frame,
bumper, front end body structure and non-Ford tow hooks may
effect the performance of the air bag sensors increasing the risk of
injury. Do not modify the front end of the vehicle with anything other
than authorized Ford accessories for your vehicle.
Additional equipment may affect the performance of the air bag
sensors increasing the risk of injury. Please refer to the Body
Builders Layout Book for instructions about the appropriate installation
of additional equipment.
Seating and Safety Restraints
121
Do not lean your head on the door. The Safety Canopy
±
could
injure you as it deploys from the headliner.
Do not attempt to service, repair, or modify the Safety Canopy
±
system, its fuses, the A, B, or C pillar trim, or the headliner on a
vehicle containing a Safety Canopy
±
. See your Ford or Lincoln
Mercury dealer.
All occupants of the vehicle including the driver should always
wear their safety belts even when an air bag SRS and Safety
Canopy
±
system is provided.
To reduce risk of injury, do not obstruct or place objects in the
deployment path of the inflatable Safety Canopy
±
.
Seating and Safety Restraints
125
5. Return the cover plate (rotate
clockwise) to the closed position.
Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle
s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
Always set the parking brake fully and make sure the gearshift is
latched in P (Park). Turn the ignition to the LOCK position and
remove the key whenever you leave your vehicle.
If the parking brake is fully released, but the brake warning lamp
remains illuminated, the brakes may not be working properly.
See your dealer or a qualified service technician.
Driving with a 5–speed automatic transmission
Your transmission is equipped with an adaptive learning strategy found in
the vehicle computer. This feature is designed to increase durability, and
provide consistent shift feel over the life of the vehicle. A new vehicle or
transmission may have firm and/or soft shifts. This operation is
considered normal and will not affect function or durability of the
transmission. Over time, the adaptive learning process will fully update
transmission operation. Additionally, whenever the battery is
disconnected or a new battery installed, the strategy must be relearned.
Driving
150
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
15
Roadside Emergencies
166
Passenger compartment fuse panel
The fuse panel is located below the
instrument panel on the driver
s
side.
To remove a fuse use the fuse puller tool provided on the fuse panel box.
1
6
16
21
26
27
28
29
30
22
23
24
25
17
18
19
20
7
8
9
10
11
12
13
14
15
2
3
4
5
Roadside Emergencies
167
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
1
30A
Memory seat module, Driver
power seat
2
20A
Moonroof
3
20A
Radio, Amplifier, DVD
4
5A
Front wiper module
5
15A
Flasher relay (Turn, hazards)
6
10A
Right horn
7
15A
Heated mirrors
8
Not used
9
Not used
10
10A
Heated backlight relay coil, A/C
clutch contact
11
20A
Heated seats
12
Not used
13
5A
Overdrive cancel switch, Flex fuel
sender
14
5A
PATS module
15
5A
Rear wiper module, Cluster, TPMS
16
5A
Power mirror, Manual climate
control, TPMS
17
15A
Delayed acc. coil, Battery saver,
Glove compartment lamp, 2nd
row courtesy lamps, Interior
lamps (front)
18
10A
Left horn
19
10A
RCM
20
5A
Driver seat switch, Driver seat
module, BSM, Sunload sensor
21
5A
Instrument cluster, Compass,
Flasher coil
22
10A
ABS
Roadside Emergencies
168
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
23
15A
Brake pedal position switch
24
15A
Cigar lighter, OBD II
25
5A
Mode-Temperature actuator for
auxiliary climate control, Trailer
tow battery charge coil
26
7.5A
Park aid, Brake shift interlock
27
7.5A
Electrochromatic mirror, Digital
transmission range sensor -
backup lamps
28
5A
Radio (Start)/DVD (Start)
29
10A
Digital transmission range sensor,
PWR feed to fuse #28 (Start feed)
30
5A
Daytime Running Lamps (DRL),
Remote solenoid, DEATC climate
controller, Manual climate control,
Manual climate control temp
blend actuator
Roadside Emergencies
169
Passenger compartment fuse panel (top side)
These relays are located on the reverse side of the passenger
compartment fuse panel. See your dealer or a certified technician for
service of this relay box.
Fuse/Relay Location
Description
Relay 1
Flasher relay
Relay 2
Rear defrost
Relay 3
Delayed accessory relay
Relay 4
Open
Relay 5
Battery saver
Relay 6
Open
Relay 7
Open
Roadside Emergencies
170
Power distribution box
The power distribution box is
located in the engine compartment.
The power distribution box contains
high-current fuses that protect your
vehicle
s main electrical systems
from overloads.
Always disconnect the battery before servicing high current
fuses.
To reduce risk of electrical shock, always replace the cover to
the Power Distribution Box before reconnecting the battery or
refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and specifications
chapter.
Roadside Emergencies
171
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
1
60A**
PJB
2
30A**
BSM
3
Not used
4
30A**
Rear defrost
5
40A**
Anti-lock Brake System (ABS)
pump
6
60A**
Delayed accessory
7
20A**
Power point #2
8
Not used
9
20A**
Power point #1
10
30A**
ABS module (valves)
11
40A**
PTEC
12
50A**
Ignition relay, Starter relay
13
40A**
Trailer tow battery, Trailer tow
turn signals
14
10A*
Daytime Running Lamps (DRL)
(Canada)
15
15A*
Memory (PCM/DEATC/Cluster),
Interior lights
16
15A*
Headlamp switch, Foglamp switch
17
Not used
18
Not used
19
20A**
High beam relay
20
30A**
Electric brake
21
30A**
Front wiper motor
22
20A**
Low beam
23
30A**
Ignition switch
24
Not used
25
Not used
26
15A*
Fuel pump
Roadside Emergencies
172
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
27
20A*
Trailer tow lamps
28
20A*
Horn relay
29
60A**
PJB
30
20A**
Rear wiper motor
31
Not used
32
Not used
33
30A**
Auxiliary blower motor
34
30A**
Passenger power seat, Adjustable
pedals
35
Not used
36
40A**
Blower motor
37
15A*
A/C clutch relay, Transmission
38
15A*
Coil on plug
39
15A*
Injectors, Fuel pump relay
40
15A*
PTEC power
41
15A*
HEGO, VMV, CMS, PTEC
42
10A*
Right low beam
43
10A*
Left low beam
44
15A*
Front foglamps
45
2A*
Brake pressure switch (ABS)
46
20A*
High beams
47
Horn relay
48
Fuel pump relay
49
High beam relay
50
Fog lamp relay
51
DRL relay (Canada)
52
A/C clutch relay
53
Trailer tow right turn relay
54
Trailer tow left turn relay
55
Blower motor relay
56
Starter relay
Roadside Emergencies
173
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
57
PTEC relay
58
Ignition relay
59
Not used
60
PCM diode
61
A/C clutch diode
62
30A CB
Power windows circuit breaker
* Mini Fuses ** Maxi Cartridge Fuses
Rear relay box
The relay box is located on the rear passenger side quarter trim panel.
See your dealer or a certified technician for service of this relay box.
The relays are coded as follows:
Fuse/Relay Location
Description
Relay 14
Not used
Relay 15
Trailer tow back-up lamps
Relay 16
Not used
Relay 17
Not used
Relay 18
Not used
Relay 19
Trailer tow park lamps
Roadside Emergencies
174
Fuse/Relay Location
Description
Relay 20
Trailer tow battery charge
Relay 21
Not used
Relay 22
Not used
Relay 23
Not used
Diode 3
Not used
Diode 4
Not used
Auxiliary relay box
The relay box is located on the front
right fender well underneath the
speed control module.
The relays are coded as follows:
Fuse/Relay Location
Description
Relay 64
Open
Relay 65
Open
Relay 66
Open
Roadside Emergencies
175