Ford Montego - 2007 Fuse Box Diagram

Ford Montego - 2007 Fuse Box Diagram

CENTER CONSOLE
Your vehicle may be equipped with a
variety of console features. These
include:
Utility compartment with power
point
Gear Shift
Cup holders
Rear vent (if equipped)
Use only soft cups in the cupholder. Hard objects can injure you
in a collision.
AUXILIARY POWER POINT (12VDC)
Power outlets are designed for accessory plugs only. Do not insert
any other object in the power outlet as this will damage the
outlet and blow the fuse. Do not hang any type of accessory or
accessory bracket from the plug. Improper use of the power
outlet can cause damage not covered by your warranty.
The auxiliary power points are
located on the instrument panel and
in the center console utility
compartment.
Do not use the power point for
operating the cigarette lighter
element (if equipped).
To prevent the fuse from being
blown, do not use the power
point(s) over the vehicle capacity of
12 VDC/180W.
To prevent the battery from being discharged, do not use the power
point longer than necessary when the engine is not running.
Always keep the power point caps closed when not being used.
Cigar/Cigarette lighter (if equipped)
Do not plug optional electrical accessories into the cigarette lighter
socket.
2007 Montego
(mgo)
Owners Guide (post-2002-fmt)
USA
(fus)
Driver Controls
64
All occupants of the vehicle, including the driver, should always
properly wear their safety belts, even when an air bag
supplemental restraint system (SRS) is provided.
Always transport children 12 years old and under in the back
seat and always properly use appropriate child restraints.
National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 10 inches (25 cm)
between an occupant’s chest and the driver airbag module.
Never place your arm over the airbag module as a deploying
airbag can result in serious arm fractures or other injuries.
Steps you can take to properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
Do not put anything on or over the airbag module. Placing
objects on or over the airbag inflation area may cause those
objects to be propelled by the airbag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the airbag
supplemental restraint system (SRS) or its fuses. See your
authorized dealer.
Modifying or adding equipment to the front end of the vehicle
(including frame, bumper, front end body structure and tow
hooks) may affect the performance of the airbag system, increasing the
risk of injury. Do not modify the front end of the vehicle.
2007 Montego
(mgo)
Owners Guide (post-2002-fmt)
USA
(fus)
Seating and Safety Restraints
128
A difficulty with the system is indicated by one or more of the following:
The readiness light (same light
for front and side airbag system)
will either flash or stay lit.
The readiness light will not
illuminate immediately after ignition is turned on.
A series of five beeps will be heard. The tone pattern will repeat
periodically until the problem and/or light are repaired.
If any of these things happen, even intermittently, have the supplemental
restraint system serviced at an authorized dealer immediately. Unless
serviced, the system may not function properly in the event of a
collision.
Seat-mounted side airbag system (if equipped)
Do not place objects or mount equipment on or near the airbag
cover on the side of the seatbacks of the front seats or in front
seat areas that may come into contact with a deploying airbag. Failure
to follow these instructions may increase the risk of personal injury in
the event of a collision.
Do not use accessory seat covers. The use of accessory seat
covers may prevent the deployment of the side airbags and
increase the risk of injury in an accident.
Do not lean your head on the door. The side airbag could injure
you as it deploys from the side of the seatback.
Do not attempt to service, repair, or modify the airbag SRS, its
fuses or the seat cover on a seat containing an airbag. See your
authorized dealer.
All occupants of the vehicle should always wear their safety belts
even when an airbag SRS is provided.
2007 Montego
(mgo)
Owners Guide (post-2002-fmt)
USA
(fus)
Seating and Safety Restraints
136
Several air bag system components get hot after inflation. Do not
touch them after inflation.
If the side airbag has
deployed,
the airbag will
not function again. The side
airbag system (including the
seat) must be inspected and
serviced by an authorized
dealer.
If the airbag is not
replaced, the unrepaired area will
increase the risk of injury in a
collision.
Safety Canopy
µ
system (if equipped)
Do not place objects or
mount equipment on or
near the headliner at the siderail
that may come into contact with a
deploying Safety Canopy
²
. Failure
to follow these instructions may
increase the risk of personal injury
in the event of a collision.
Do not lean your head on the door. The Safety Canopy
²
could
injure you as it deploys from the headliner.
Do not attempt to service, repair, or modify the Safety Canopy
²
system, its fuses, the A, B, or C pillar trim, or the headliner on a
vehicle containing a Safety Canopy
²
. See your authorized dealer.
2007 Montego
(mgo)
Owners Guide (post-2002-fmt)
USA
(fus)
Seating and Safety Restraints
138
3. Locate the white plastic cover at
the front driver side of the gearshift
lever. Locate the screw which
attaches this cover and remove
using a screwdriver. Remove the
cover by tilting forward while
pulling up and out of the gearshift
assembly.
4. Locate the silver button in the driver side front area of the gearshift
assembly. Press and hold the silver button while moving the gearshift
lever out of P (Park) into N (Neutral).
5. Start the vehicle and release the parking brake.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
Emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
Always set the parking brake fully and make sure the gearshift is
latched in P (Park). Turn the ignition to the LOCK position and
remove the key whenever you leave your vehicle.
If the parking brake is fully released, but the brake warning lamp
remains illuminated, the brakes may not be working properly.
See your authorized dealer.
Understanding the gearshift positions of the Continuously Variable
Transaxle (CVT) (if equipped)
The CVT is a fully automatic transaxle that electronically monitors
vehicle system inputs and outputs and driver demands to select the
desired drive ratio. Unlike traditional automatic transmissions/transaxles,
the CVT continually adjusts the optimum overall drive ratio between
engine and drive wheels for all operating conditions.
As traditional automatic transmissions/transaxles shift up or down in
gears, this shifting in gear ratios is noticeable by increasing and
2007 Montego
(mgo)
Owners Guide (post-2002-fmt)
USA
(fus)
Driving
185
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
Yellow
80A
Natural
Black
Black
15
2007 Montego
(mgo)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
200
Passenger compartment fuse panel/Smart Junction Box (SJB)
The fuse panel is located under the instrument panel to the left of the
steering wheel.
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
F1
20A
High beams
F2
15A
Interior lamps (Courtesy and
demand lamps), Delayed
accessory (Power windows and
moonroof)
F3
25A
Access/Security (Power door lock
actuators, Decklid lock actuator,
Decklid solenoid)
F4
15A
Adjustable pedal switch
F5
20A
Horns
F6
20A
Audio (Subwoofer)
F7
7.5A
Power/Keep Alive Memory
(KAM): Cluster and Powertrain
Control Module (PCM), Climate
control, Analog clock
2007 Montego
(mgo)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
201
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
F8
15A
Park lamps, Side markers, Trailer
tow protect
F9
20A
Cigar lighter, Data Link Connector
(DLC)
F10
7.5A
Mirrors and memory module,
SDARS
F11
20A
Audio, Family Entertainment
System (FES)
F12
10A
Back-up lamps, Electrochromatic
mirror, Reverse Sensing System
(RSS), Trailer tow protect
F13
7.5A
Audio
F14
7.5A
Starter relay coil, PCM
F15
10A
Delayed accessory (Driver window
motor logic, Moonroof, Audio,
Driver door lock switch
illumination)
F16
10A
Rear defroster indicator, Heated
mirrors
F17
30A
Rear defroster
F18
10A
PCM relay coil, Shifter Brake-Shift
Interlock (BSI), Passive
Anti-Theft System (PATS)
module, Fuel relay coil, Brake
lamps, Center High-Mounted Stop
Lamp (CHMSL)
F19
10A
Anti-lock Brake System
(ABS)/Traction control module,
All Wheel Drive (AWD) module,
RSS, Heated seat modules
F20
7.5A
Cluster, Climate control
F21
7.5A
Restraint Control Module (RCM)
2007 Montego
(mgo)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
202
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
F22
7.5A
Electrochromatic mirror, Compass
module
F23
7.5A
Wiper relay coil, Blower relay coil,
Cluster logic
F24
7.5A
Occupant Classification Sensor
(OCS), Passenger Air bag
Deactivation (PAD)
C1
30A Circuit
breaker
Delayed accessory (Front
passenger window, Rear passenger
windows [via window switch],
Window switch illumination,
Backlighting
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
To reduce risk of electrical shock, always replace the cover to
the Power Distribution Box before reconnecting the battery or
refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
2007 Montego
(mgo)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
203
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
1
80A*
SJB, SJB fuses 1, 2, 3, 4, 5, 8 and
12
2
Not used
3
30A*
Front wiper, Front washer
4
Not used
5
20A*
Moonroof
6
Not used
7
60A*
Engine cooling fan
8
Not used
9
40A*
Anti-lock Brake System (ABS)
(Motor)
10
30A*
Starter
11
30A*
Powertrain Control Module (PCM)
relay
12
20A*
ABS (Valves)
13
Not used
14
Not used
2007 Montego
(mgo)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
204
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
15
15A**
Traction Control Module (TCM)
16
20A**
Power point (Console)
17
10A**
Alternator
18
40A*
Logic feed to SJB, SJB solid state
devices
19
20A*
Right-hand HID low beam
headlamp
20
40A*
Rear defroster
21
30A*
Power seat motors (passenger)
22
30A*
Heated seat module
23
15A**
Fog lamps
24
10A**
A/C clutch relay, A/C compressor
clutch
25
Not used
26
Not used
27
15A**
Fuel relay (Fuel pump driver
module, Fuel pump)
28
80A*
SJB power, SJB (Circuit breaker,
Fuses 6, 7, 9, 10, 11 and 15)
29
30A*
Driver window motor
30
20A*
Left-hand HID low beam
headlamp
31
Not used
32
30A*
Driver seat motors, Memory
module
33
30A*
Ignition switch (to SJB)
34
Not used
35
40A*
Front A/C blower motor
36
Not used
37
Not used
38
Not used
39
1A Diode
PCM
2007 Montego
(mgo)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
205
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
40
1A Diode
A/C clutch
41
1
±
2
ISO relay
Fog lamps
42
Not used
43
1
±
2
ISO relay
A/C clutch
44
1
±
2
ISO relay
Fuel pump driver module, Fuel
pump
45
Not used
46
5A**
Heated Positive Crankcase
Ventilation (PCV) valve
47
Not used
48
10A**
TCM, EVMV, Canister vent, ESM,
Exhaust Gas Oxygen heaters, A/C
clutch
49
15A**
PCM, Injectors, Ignition coils,
Mass Air Flow (MAF) sensor
50
Full ISO relay
PCM relay, PDB fuses 40 and 41
51
Full ISO relay
Starter motor solenoid
52
Full ISO relay
Front A/C blower motor
53
Not used
54
Not used
55
Not used
56
Not used
57
Full ISO relay
Front wiper
58
Not used
* Cartridge Fuses ** Mini Fuses
CHANGING THE TIRES
If you get a flat tire while driving:
do not brake heavily.
gradually decrease the vehicle’s speed.
hold the steering wheel firmly.
slowly move to a safe place on the side of the road.
2007 Montego
(mgo)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
206