Ford Focus Electric - 2015 Fuse Box Diagram

Ford Focus Electric - 2015 Fuse Box Diagram

PRINCIPLE OF OPERATION
WARNINGS
Airbags do not inflate slowly or
gently, and the risk of injury from a
deploying airbag is the greatest close
to the trim covering the airbag module.
All occupants of your vehicle,
including the driver, should always
properly wear their safety belts, even
when an airbag supplemental restraint
system is provided. Failure to properly wear
your safety belt could seriously increase
the risk of injury or death.
Always transport children 12 years
old and under in the back seat and
always properly use appropriate
child restraints. Failure to follow this could
seriously increase the risk of injury or death.
Never place your arm over the airbag
module as a deploying airbag can
result in serious arm fractures or
other injuries.
Airbags can kill or injure a child in a
child seat. Never place a rear-facing
child seat in front of an active airbag.
If you must use a forward-facing child seat
in the front seat, move the seat upon which
the child seat is installed all the way back.
Do not attempt to service, repair, or
modify the airbag supplemental
restraint systems or its fuses as you
could be seriously injured or killed. Contact
your authorized dealer as soon as possible.
Several airbag system components
get hot after inflation. To reduce the
risk of injury, do not touch them after
inflation.
If the airbag has deployed, the airbag
will not function again and must be
replaced immediately. If the airbag
is not replaced, the unrepaired area will
increase the risk of injury in a crash.
The airbags are a supplemental restraint
system and are designed to work with the
safety belts to help protect the driver and
right front passenger from certain upper
body injuries. Airbags do not inflate slowly;
there is a risk of injury from a deploying
airbag.
Note:
You will hear a loud bang and see a
cloud of harmless powdery residue if an
airbag deploys. This is normal.
The airbags inflate and deflate rapidly
upon activation. After airbag deployment,
it is normal to notice a smoke-like, powdery
residue or smell the burnt propellant. This
may consist of cornstarch, talcum powder
(to lubricate the bag) or sodium
compounds (for example, baking soda)
that result from the combustion process
that inflates the airbag. Small amounts of
sodium hydroxide may be present which
may irritate the skin and eyes, but none of
the residue is toxic.
While the system is designed to help
reduce serious injuries, contact with a
deploying airbag may also cause abrasions
or swelling. Temporary hearing loss is also
a possibility as a result of the noise
associated with a deploying airbag.
Because airbags must inflate rapidly and
with considerable force, there is the risk of
death or serious injuries such as fractures,
facial and eye injuries or internal injuries,
particularly to occupants who are not
properly restrained or are otherwise out of
position at the time of airbag deployment.
Thus, it is extremely important that
occupants be properly restrained as far
away from the airbag module as possible
while maintaining vehicle control.
Routine maintenance of the airbags is not
required.
37
Focus (CDH), enUSA, First Printing
Supplementary Restraints System
WARNINGS
Do not use accessory seat covers.
The use of accessory seat covers
may prevent the deployment of the
side airbags and increase the risk of injury
in an accident.
Do not lean your head on the door.
The side airbag could injure you as it
deploys from the side of the
seatback.
Do not attempt to service, repair, or
modify the airbag, its fuses or the
seat cover on a seat containing an
airbag as you could be seriously injured or
killed. Contact your authorized dealer as
soon as possible.
If the side airbag has deployed, the
airbag will not function again. The
side airbag system (including the
seat) must be inspected and serviced by
an authorized dealer. If the airbag is not
replaced, the unrepaired area will increase
the risk of injury in a crash.
The side airbags are located on the
outboard side of the seatbacks of the front
seats. In certain sideways crashes, the
airbag on the side affected by the crash
will be inflated. The airbag was designed
to inflate between the door panel and
occupant to further enhance the protection
provided occupants in side impact crashes.
E152533
The system consists of the following:
A label or embossed side panel
indicating that side airbags are fitted
to your vehicle.
Side airbags located inside the driver
and front passenger seatbacks.
Front passenger sensing system.
·Crash sensors and monitoring
system with readiness indicator.
See
Crash Sensors and Airbag
Indicator
(page 44).
Note:
The passenger sensing system will
deactivate the passenger seat-mounted
side airbag if it detects an empty passenger
seat.
The design and development of the side
airbag system included recommended
testing procedures that were developed
by a group of automotive safety experts
known as the Side Airbag Technical
Working Group. These recommended
testing procedures help reduce the risk of
injuries related to the deployment of side
airbags.
DRIVER KNEE AIRBAG
A driver's knee airbag is located under the
instrument panel. During a crash, the
restraints control module may activate the
driver's knee airbag based on crash severity
and occupant conditions. Under certain
crash and occupant conditions, the driver
s
knee airbag may deploy but the driver
s
front airbag may not activate. As with front
and side airbags, it is important to be
properly seated and restrained to reduce
the risk of death or serious injury.
Make sure the knee airbag is
operating properly. See
Crash
Sensors and Airbag Indicator
(page 44).
42
Focus (CDH), enUSA, First Printing
Supplementary Restraints System
SIDE CURTAIN AIRBAGS
WARNINGS
Do not place objects or mount
equipment on or near the headliner
at the siderail that may come into
contact with a deploying side curtain
airbag. Failure to follow these instructions
may increase the risk of personal injury in
the event of a crash.
Do not lean your head on the door.
The side curtain airbag could injure
you as it deploys from the headliner.
Do not attempt to service, repair, or
modify the side curtain airbags, its
fuses, the A, B, or C pillar trim, or the
headliner on a vehicle containing side
curtain airbags. Contact your authorized
dealer as soon as possible.
All occupants of the vehicle including
the driver should always wear their
safety belts even when an airbag
supplemental restraint system and side
curtain airbag is provided. Failure to
properly wear your safety belt could
seriously increase the risk of injury or death.
To reduce risk of injury, do not
obstruct or place objects in the
deployment path of the side curtain
airbag.
If the side curtain airbags have
deployed, the side curtain airbags
will not function again. The side
curtain airbags (including the A, B and C
pillar trim and headliner) must be
inspected and serviced by an authorized
dealer. If the side curtain airbag is not
replaced, the unrepaired area will increase
the risk of injury in a crash.
In certain sideways crashes, the side
curtain airbag on the side affected by the
crash will be inflated. The side curtain
airbags are mounted to the roof side-rail
sheet metal, behind the headliner, above
each row of seats. The side curtain airbags
are designed to inflate between the side
window area and occupants to further
enhance protection provided in side impact
crashes.
The system consists of the following:
E75004
Side curtain airbags located above the
trim panels over the front and rear side
windows identified by a label or
wording on the headliner or roof-pillar
trim.
A flexible headliner which opens above
the side doors to allow side air curtain
deployment.
· Crash sensors and monitoring
system with readiness indicator.
See
Crash Sensors and Airbag
Indicator
(page 44).
Children 12 years old and under should
always be properly restrained in the back
seats. The side curtain airbags will not
interfere with children restrained using a
properly installed child or booster seat
because it is designed to inflate downward
from the headliner above the doors along
the side window opening.
43
Focus (CDH), enUSA, First Printing
Supplementary Restraints System
12 Volt DC Power Point
WARNING
Do not plug optional electrical
accessories into the cigar lighter
socket. Incorrect use of the lighter
can cause damage not covered by your
warranty, and can result in fire or serious
injury.
Note:
After starting your vehicle, you can
use the socket to power 12-volt appliances
with a maximum current rating of 20 amps.
After you switch your vehicle off, the power
supply works only for a maximum of 30
minutes.
Note:
Do not insert objects other than an
accessory plug into the power point. This
damages the outlet and can blow the fuse.
Note:
Do not hang any type of accessory or
accessory bracket from the plug.
Note:
Do not use the power point over the
vehicle capacity of 12 volt DC 180 watt or a
fuse may blow.
Note:
Do not use the power point for
operating a cigar lighter element.
Note:
Incorrect use of the power point can
cause damage not covered by your
warranty.
Note:
Always keep the power point caps
closed when not in use.
Run the vehicle for full capacity use of the
power point.
To prevent the battery from running out of
charge:
Do not use the power point longer than
necessary after switching the vehicle
off.
Do not leave devices plugged in
overnight or when your vehicle is in park
(P) for extended periods.
Location
You may find power points in the following
locations:
On the center console
In the center console.
110
Focus (CDH), enUSA, First Printing
Auxiliary Power Points
FUSE SPECIFICATION CHART
Pre-Fuse Box
Your vehicle has a pre-fuse box located in
the electric motor compartment on the
front of the 12 volt battery box. It is
connected to the 12 volt battery positive
terminal. This fuse box contains several
high current fuses. If replacement of these
high current fuses is required, contact an
authorized dealer.
Circuits protected
Fuse rating
Fuse
Electronic power assist steering.
80A
F1
12 volt battery charge.
150A
F2
Power distribution box.
100A
F3
Body control module (KL30A supply).
50A
F4
High voltage battery coolant element one and two.
70A
F5
Load compartment fuse box.
70A
F6
Not used.
-
F7
Electric fan control module.
50A
F8
Body control module (KL30B supply).
50A
F9
High voltage battery coolant element three.
40A
F10
Electric Motor Compartment Fuse
Box
WARNING
To reduce risk of electrical shock,
always replace the cover to the
power distribution box before
reconnecting the battery or refilling fluid
reservoirs. Always disconnect the 12 volt
battery before servicing high current fuses.
This fuse box contains several high current
fuses that protect your vehicle's main
electrical systems from overloads.
If the 12 volt battery is disconnected and
reconnected, some features need to be
reset.
158
Focus (CDH), enUSA, First Printing
Fuses
E129925
Lift the release lever at the rear of the cover
to remove it.
Circuits protected
Fuse rating
Fuse
Anti-lock brake system.
40A
**
F7
Stability control (KL30V).
Anti-lock brake system.
30A
**
F8
Stability control (KL30P).
Not used.
-
F9
Blower motor module.
40A
**
F10
Brake vacuum pump.
40A
**
F11
Electric motor control relay.
40A
**
F12
Battery charging control module.
40A
**
F13
Coolant heater one.
40A
**
F14
159
Focus (CDH), enUSA, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Body control module (KL30C supply).
30A
**
F15
Coolant heater two.
40A
**
F16
Not used.
-
F17
Windshield wiper.
20A
**
F18
Anti-lock brake system.
5A
*
F19
Stability control (KL15).
Horn.
15A
*
F20
Stop lamp switch.
5A
*
F21
Battery monitoring system.
15A
*
F22
Relay coils.
5A
*
F23
Lighting control switch module.
5A
*
F24
Not used.
-
F25
Powertrain control module.
10A
*
F26
Charge port light ring.
15A
*
F27
Vacuum pump monitor.
5A
*
F28
Not used.
-
F29
Transmission control module (12V supply).
5A
*
F30
Smart data link/on-board diagnostic connector.
10A
*
F31
Coolant valve.
10A
*
F32
Air conditioning solenoid.
Chiller solenoid.
Powertrain control module/A/C compressor PSR
feedback.
10A
*
F33
High voltage battery.
15A
*
F34
Not used.
-
F35
160
Focus (CDH), enUSA, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Coolant pump.
20A
*
F36
Vehicle audible signal for pedestrians.
5A
*
F37
Powertrain control module (KL15 supply).
15A
*
F38
Not used.
-
F39
Electronic power assist steering.
5A
*
F40
Body control module (KL15 supply).
20A
*
F41
Not used.
-
F42
Daytime running light.
15A
*
F43
Not used.
-
F44
Not used.
-
F45
Not used.
-
F46
Not used.
-
F47
Mechanical relay coil fuse.
5A
*
F48
*
Mini fuses
**
Cartridge fuses
Circuit switched
Relay Type
Relay
Not used.
-
R1
Horn.
Micro relay
R2
Not used.
-
R3
High voltage battery.
Micro relay
R4
Not used.
-
R5
Not used.
-
R6
Coolant heater element three.
Power relay
R7
Coolant heater element one and two.
Power relay
R8
161
Focus (CDH), enUSA, First Printing
Fuses
Circuit switched
Relay Type
Relay
Not used.
-
R9
Brake vacuum pump.
Mini relay
R10
Not used.
-
R11
Electronic fan control module.
Power relay
R12
Blower motor.
Mini relay
R13
Electric motor control.
Mini relay
R14
Brake vacuum pump mechanical relay.
Power relay
R15
Ignition.
Power relay
R16
162
Focus (CDH), enUSA, First Printing
Fuses
Passenger Compartment Fuse Box
E129926
Circuits protected
Fuse rating
Fuse
Not used.
-
F56
Not used.
-
F57
Not used.
-
F58
Not used.
-
F59
Interior lamp.
10A
F60
Driver door switch pack.
Glove compartment lamp.
163
Focus (CDH), enUSA, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Ambient lighting lamp.
Front cigar lighter socket.
20A
F61
Rear auxiliary power points.
Not used.
-
F62
Not used.
-
F63
Not used.
-
F64
Luggage compartment lid release.
10A
F65
Not used.
-
F66
Global positioning sensor.
7.5A
F67
SYNC.
Not used.
-
F68
Instrument panel cluster.
5A
F69
Not used.
-
F70
Air conditioning.
7.5A
F71
Steering wheel control module.
7.5A
F72
Smart data link module.
7.5A
F73
High beam headlamp.
15A
F74
Not used.
-
F75
Reversing lamp.
10A
F76
Washer pump.
20A
F77
Ignition switch.
5A
F78
Push button ignition switch.
Audio unit.
15A
F79
Hazard flasher switch.
Door lock buttons.
Not used.
-
F80
Radio frequency receiver.
5A
F81
Washer pump (ground).
20A
F82
Central locking (ground).
20A
F83
164
Focus (CDH), enUSA, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Driver door unlock (ground).
20A
F84
Double locking ground (ground).
Heated seats switch.
7.5A
F85
Restraint system.
10A
F86
Passenger airbag deactivation system.
Not used.
-
F87
Not used.
-
F88
Not used.
-
F89
Luggage Compartment Fuse Box
E129927
Circuits protected
Fuse rating
Fuse
Cellphone passport module.
5A
*
F1
Not used.
-
F2
Keyless vehicle door handles.
5A
*
F3
Front power window (left).
25A
*
F4
Central locking (front left).
Power folding mirror (left).
Heated exterior mirror (left).
Front power window (right).
25A
*
F5
Central locking (front right).
165
Focus (CDH), enUSA, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Power folding mirror (right).
Heated exterior mirror (right).
Rear left door module (KL30 supply).
25A
*
F6
Rear right door module (KL30 supply).
25A
*
F7
Ignition relay.
5A
*
F8
Driver power seat.
25A
*
F9
Heated rear window.
25A
*
F10
High voltage battery (12V B+).
5A
*
F11
Not used.
-
F12
Not used.
-
F13
Not used.
-
F14
Not used.
-
F15
Not used.
-
F16
Not used.
-
F17
Not used.
-
F18
Not used.
-
F19
Not used.
-
F20
Not used.
-
F21
Not used.
-
F22
Not used.
-
F23
Not used.
-
F24
Not used.
-
F25
Not used.
-
F26
Not used.
-
F27
Not used.
-
F28
High voltage battery (12V B+).
5A
*
F29
166
Focus (CDH), enUSA, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Parking aid module.
5A
*
F30
Not used.
-
F31
Not used.
-
F32
Rear wiper motor.
15A
F33
Heated seat (driver).
15A
*
F34
Heated seat (front passenger).
15A
*
F35
Not used.
-
F36
Not used.
-
F37
Not used.
-
F38
Not used.
-
F39
Not used.
-
F40
Not used.
-
F41
Not used.
-
F42
Not used.
-
F43
Not used.
-
F44
Not used.
-
F45
Not used.
-
F46
*
Mini fuses
**
Cartridge fuses
Circuit switched
Relay Type
Relay
Rear KL15E.
Power relay
R1
Heated rear window.
Mini relay
R2
Rear window wiper.
Micro relay
R3
167
Focus (CDH), enUSA, First Printing
Fuses
Circuit switched
Relay Type
Relay
Not used.
-
R4
Not used.
-
R5
Not used.
-
R6
CHANGING A FUSE
Fuses
WARNING
Always replace a fuse with one that
has the specified amperage rating.
Using a fuse with a higher amperage
rating can cause severe wire damage and
could start a fire.
E142430
If electrical components in the vehicle are
not working, a fuse may have blown. Blown
fuses are identified by a broken wire within
the fuse. Check the appropriate fuses
before replacing any electrical
components.
Standard Fuse Amperage Rating and Color
Color
J-type fuses
M-type fuses
Dual micro fuses
Micro fuses
Fuse rating
-
-
Tan
Tan
5A
-
-
Brown
Brown
7.5A
-
-
Red
Red
10A
-
Grey
Blue
Blue
15A
Blue
Light Blue
-
Yellow
20A
White
White
-
White
25A
Pink
Pink
-
Green
30A
Green
Green
-
-
40A
Red
-
-
-
50A
Yellow
-
-
-
60A
168
Focus (CDH), enUSA, First Printing
Fuses
Coolant reservoir. See
Coolant Check
(page 171).
A
Brake fluid reservoir. See
Brake Fluid Check
(page 173).
B
12 volt battery. See
Changing the 12V Battery
(page 173).
C
Electric motor compartment fuse box. See
Fuses
(page 158).
D
Windshield washer fluid reservoir. See
Washer Fluid Check
(page 173).
E
COOLANT CHECK
WARNINGS
Do not add coolant when the electric
motor is hot. Steam and scalding
liquids released from a hot cooling
system can cause severe burns. You could
receive burns if you spill coolant on hot
motor parts. Failure to follow this warning
could result in serious personal injury.
Do not put coolant in the windshield
washer fluid container. If sprayed on
the windshield, coolant could make
it difficult to see through the windshield.
Failure to follow this warning could result
in serious personal injury or death.
To reduce the risk of personal injury,
make sure the electric motor is cool
before unscrewing the coolant
pressure relief cap. The cooling system is
under pressure; steam and hot liquid can
come out forcefully when the cap is
loosened slightly. Failure to follow this
warning could result in serious personal
injury.
Do not add coolant further than the
MAX mark.
When the electric motor is cold, check the
level and concentration of the coolant in
the reservoir at the intervals listed in the
scheduled maintenance information.
Note:
Make sure that the coolant level is
between the MIN and MAX marks on the
coolant reservoir.
Note:
Coolant expands when it is hot. The
level may extend beyond the MAX mark.
Note:
If the level is at the MIN mark, below
the MIN mark or empty, add coolant
immediately.
Maintain coolant concentration within
48% to 50%, which equates to a freeze
point between -30°F (-34°C) and -34°F
(-37°C).
Note:
For best results, coolant
concentration should be tested with a
refractometer such as Robinair Coolant and
Battery Refractometer 75240. We do not
recommend the use of hydrometers or
coolant test strips for measuring coolant
concentrations.
Note:
It is very important to use prediluted
coolant meeting the Ford specification in
order to avoid plugging the small coolant
passageways. Use of concentrated coolant
and water may cause coolant passageway
plugging and void the warranty. See
Capacities and Specifications
(page 225).
Note:
Automotive fluids are not
interchangeable; do not use coolant,
antifreeze or windshield washer fluid outside
of its specified function and vehicle location.
Adding Coolant
Note:
Do not use stop leak pellets or
cooling system sealants or additives as they
can cause damage to the cooling and
heating systems. This damage would not
be covered under your vehicle warranty.
171
Focus (CDH), enUSA, First Printing
Maintenance
FUSE SPECIFICATION CHART
Pre-Fuse Box
Your vehicle has a pre-fuse box located in
the electric motor compartment on the
front of the 12 volt battery box. It is
connected to the 12 volt battery positive
terminal. This fuse box contains several
high current fuses. If replacement of these
high current fuses is required, see an
authorized dealer.
Circuits protected
Fuse rating
Fuse
Electronic power assist steering
80A
F1
12 volt battery charge
150A
F2
Power distribution box
100A
F3
Body control module (KL30A supply)
50A
F4
High voltage battery coolant element one and two
70A
F5
Load compartment fuse box
70A
F6
Not used
-
F7
Electric motor cooling fan
50A
F8
Body control module (supply)
50A
F9
High voltage battery coolant element three
40A
F10
Electric Motor Compartment Fuse
Box
WARNING
To reduce risk of electrical shock,
always replace the cover to the
power distribution box before
reconnecting the battery or refilling fluid
reservoirs. Always disconnect the 12 volt
battery before servicing high current fuses.
This fuse box contains several high current
fuses that protect your vehicle's main
electrical systems from overloads.
If the 12 volt battery has been disconnected
and reconnected, some features will need
to be reset.
33
Focus Electric (CB8) Vehicles Built From: 13-07-2012, Vehicles Built Up To: 31-12-2013, Battery Electric Vehicle (BEV)
Fuses
Lift the release lever at the rear of the cover
to remove it.
Circuits protected
Fuse rating
Fuse
Anti-lock brake system
40A
F7
Stability control
Stability control
30A
F8
Not used
-
F9
Blower motor
40A
F10
Vacuum pump
40A
F11
Electric motor control relay
40A
F12
Battery charging control module
40A
F13
Coolant heater one
40A
F14
Body control module
30A
F15
Coolant heater two
40A
F16
34
Focus Electric (CB8) Vehicles Built From: 13-07-2012, Vehicles Built Up To: 31-12-2013, Battery Electric Vehicle (BEV)
Fuses
Circuits protected
Fuse rating
Fuse
Not used
-
F17
Windshield wiper
20A
F18
Anti-lock brake system
5A
F19
Stability control
Horn
15A
F20
Stop lamp switch
5A
F21
Battery monitoring system
15A
F22
Relay coils
5A
F23
Lighting control switch module
5A
F24
Not used
-
F25
Powertrain control module
10A
F26
Charge port light ring
15A
F27
Vacuum pump monitor
5A
F28
Not used
-
F29
Torque control module
15A
F30
Data link connector
10A
F31
Coolant valve
10A
F32
Air conditioning solenoid
Chiller solenoid
Powertrain control module
10A
F33
High voltage battery
15A
F34
Not used
-
F35
Not used
-
F35
Coolant pump
20A
F36
Vehicle audible sound for pedestrians
5A
F37
Powertrain control module
15A
F38
Headlamp leveling (halogen lamps)
5A
F39
Electronic power assist steering
5A
F40
35
Focus Electric (CB8) Vehicles Built From: 13-07-2012, Vehicles Built Up To: 31-12-2013, Battery Electric Vehicle (BEV)
Fuses
Circuits protected
Fuse rating
Fuse
Body control module
20A
F41
Rear window wiper
15A
F42
Headlamp leveling (high intensity discharge lamps)
15A
F43
Adaptive front lighting
Not used
-
F44
Heated washer jets
10A
F45
Not used
-
F46
In-vehicle temperature sensor
5A
F47
Mechanical relay coil fuse
5A
F48
Circuit switched
Relay
Not used
R1
Horn
R2
Not used
R3
High voltage battery
R4
Not used
R5
Not used
R6
Coolant heater
R7
Coolant heater
R8
Not used
R9
Vacuum pump
R10
Not used
R11
Electronic fan control module
R12
Blower motor
R13
Electric motor control
R14
Vacuum pump
R15
Ignition
R16
36
Focus Electric (CB8) Vehicles Built From: 13-07-2012, Vehicles Built Up To: 31-12-2013, Battery Electric Vehicle (BEV)
Fuses
Passenger Compartment Fuse Box
Circuits protected
Fuse rating
Fuse
Not used
-
F56
Not used
-
F57
Not used
-
F58
passive anti-theft system (supply)
5A
F59
Interior lamp
10A
F60
Driver door switch pack
Glove compartment lamp
37
Focus Electric (CB8) Vehicles Built From: 13-07-2012, Vehicles Built Up To: 31-12-2013, Battery Electric Vehicle (BEV)
Fuses
Circuits protected
Fuse rating
Fuse
Ambient lighting lamp
Moonroof
Front cigar lighter socket
20A
F61
Rear auxiliary power points
Rain sensor
5A
F62
Humidity sensor
Auto-dimming mirror
Not used
-
F63
Not used
-
F64
Luggage compartment lid release
10A
F65
Driver door lock
20A
F66
Double locking
Front display interface module
7.5A
F67
Global positioning sensor
Bluetooth phone and voice control connectivity
SYNC
Electrical steering column lock
15A
F68
Instrument panel cluster
5A
F69
Central locking
20A
F70
Air conditioning
10A
F71
Steering wheel control module
7.5A
F72
Battery back-up sounder (alarm system)
5A
F73
Onboard diagnostics system
High beam headlamp
15A
F74
Front fog lamp
15A
F75
Reversing lamp
10A
F76
Washer pump
20A
F77
Ignition switch
5A
F78
Push button ignition switch
Audio unit
15A
F79
Hazard flasher switch
Door lock buttons
38
Focus Electric (CB8) Vehicles Built From: 13-07-2012, Vehicles Built Up To: 31-12-2013, Battery Electric Vehicle (BEV)
Fuses
Circuits protected
Fuse rating
Fuse
Moonroof
20A
F80
Interior motion sensor
5A
F81
Radio frequency receiver
Washer pump (ground)
20A
F82
Central locking (ground)
20A
F83
Driver door unlock (ground)
20A
F84
Double locking ground (ground)
Climate control heater
7.5A
F85
Passenger airbag deactivation switch
Heated seats switch
Auxiliary heater
Manual air conditioning heater module
Restraint system
10A
F86
Passenger airbag deactivation system
Not used
-
F87
Not used
-
F88
Not used
-
F89
Load Compartment Fuse Box
39
Focus Electric (CB8) Vehicles Built From: 13-07-2012, Vehicles Built Up To: 31-12-2013, Battery Electric Vehicle (BEV)
Fuses
Circuits protected
Fuse rating
Fuse
Telematics control unit
5A
F1
Keyless vehicle module
10A
F2
Keyless vehicle door handles
5A
F3
Front power window (left)
25A
F4
Central locking (front left)
Power folding mirror (left)
Heated exterior mirror (left)
Front power window (right)
25A
F5
Central locking (front right)
Power folding mirror (right)
Heated exterior mirror (right)
Rear power window (left)
25A
F6
Rear power window (right)
25A
F7
Anti-theft alarm system
10A
F8
Driver power seat
25A
F9
Heated rear window
25A
F10
Battery electronic control module
5A
F11
Not used
-
F12
Not used
-
F13
Not used
-
F14
Not used
-
F15
Not used
-
F16
Not used
-
F17
Not used
-
F18
Not used
-
F19
Not used
-
F20
Not used
-
F21
Not used
-
F22
Not used
-
F23
40
Focus Electric (CB8) Vehicles Built From: 13-07-2012, Vehicles Built Up To: 31-12-2013, Battery Electric Vehicle (BEV)
Fuses
Circuits protected
Fuse rating
Fuse
Not used
-
F24
Not used
-
F25
Not used
-
F26
Not used
-
F27
Not used
-
F28
Parking aid camera
5A
F29
Parking aid module
5A
F30
Not used
-
F31
Not used
-
F32
Not used
-
F33
Heated seat (driver)
15A
F34
Heated seat (front passenger)
15A
F35
Not used
-
F36
Not used
-
F37
Not used
-
F38
Not used
-
F39
Not used
-
F40
Not used
-
F41
Not used
-
F42
Not used
-
F43
Not used
-
F44
Not used
-
F45
Not used
-
F46
41
Focus Electric (CB8) Vehicles Built From: 13-07-2012, Vehicles Built Up To: 31-12-2013, Battery Electric Vehicle (BEV)
Fuses
Circuit switched
Relay
Rear 15
R1
Heated rear window
R2
Rear window wiper
R3
Not used
R4
Anti-theft alarm horn
R5
Not used
R6
42
Focus Electric (CB8) Vehicles Built From: 13-07-2012, Vehicles Built Up To: 31-12-2013, Battery Electric Vehicle (BEV)
Fuses
UNDER HOOD OVERVIEW
Coolant reservoir. See
Coolant Check
(page 44).
A
Brake fluid reservoir (right-hand drive).
B
Brake fluid reservoir (left-hand drive).
C
12 volt battery.
D
Electric motor compartment fuse box. See
Fuses
(page 33).
E
Windshield washer fluid reservoir.
F
COOLANT CHECK
WARNING
Do not allow the fluid to touch your
skin or eyes. If this happens, rinse the
affected areas immediately with
plenty of water and contact your physician.
Failure to follow this warning could result
in serious personal injury.
Checking the Coolant
When the electric motor is cold, check the
level of the coolant in the reservoir at the
intervals listed in the scheduled
maintenance information.
If the level is at the
MIN
mark, add coolant
immediately.
Note:
Make sure that the level is between
the
MIN
and the
MAX
marks.
Note:
Coolant expands when it is hot. The
level may extend beyond the
MAX
mark.
44
Focus Electric (CB8) Vehicles Built From: 13-07-2012, Vehicles Built Up To: 31-12-2013, Battery Electric Vehicle (BEV)
Maintenance
FUSE BOX LOCATIONS
Engine compartment fuse box
This fuse box is located in the engine
compartment See
Maintenance
(page
198).
Passenger compartment fuse box
1.
Pinch the retaining clips to release the
cover.
2.
Lower the fuse box cover and pull it
towards you.
Install in the reverse order.
Load compartment fuse box
4-door
5-door
187
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Fuses
Wagon
FUSE SPECIFICATION CHART
Engine compartment fuse box
188
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Fuses
Circuits protected
Ampere
rating
Fuse
Anti-lock Braking System pump, electronic stability
program pump
40
7
Electronic stability program valve
30
8
Heated rear window
30
9
Heater blower
40
10
Start-stop module
30
11
Engine management systems, exhaust gas recirculation
relay
30
12
Starter relay
30
13
Heated windshield (right-hand side)
40
14
Transmission control module, intercooler fan - 1.0L
EcoBoost
25
15
Heated windshield (left-hand side)
40
16
Fuel operated heater
20
17
Windshield wipers
20
18
Anti-lock Braking System, electronic stability program
module
5
19
Horn
15
20
Brake lamp switch
5
21
Battery monitoring system
15
22
Relay coils, lighting control switch module
5
23
Rear power outlet
20
24
Power exterior mirrors
10
25
Transmission control module
15
26
Air conditioning clutch
15
27
Adaptive cruise control
5
28
Headlamp washer
20
29
189
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Fuses
Circuits protected
Ampere
rating
Fuse
Powertrain control module
5
30
Not used
-
31
Exhaust gas recirculation valve, swirl control valves, heated
exhaust gas oxygen sensor (engine management), elec-
tronic fan control module relay (coil), run on water pump
module - 1.0L EcoBoost
10
32
Engine control valves, canister purge valve, turbo control
valve, water in fuel sensor, ignition coils - 1.0L EcoBoost
10
33
Injectors, vaporizer relay, canister purge valve
10
34
Active grille shutter (gasoline engine), Run on water pump
relay, Intercooler fan relay
5
35
Active grille shutter and filter heater (diesel engine)
15
35
Powertrain control module
10
36
Not used
-
37
Powertrain control module, transmission control module
15
38
Headlamp control module (halogen leveling)
5
39
Electric power assisted steering
5
40
Body control module
20
41
Rear window wiper
15
42
Headlamp control module (high intensity discharge
leveling), adaptive front lighting unit
15
43
Adaptive cruise control
5
44
Heated washer jets
10
45
Power windows (front)
25
46
Heated exterior mirrors
7.5
47
Vaporizer
15
48
190
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Fuses
Passenger compartment fuse box
Circuits protected
Ampere
rating
Fuse
Fuel pump supply
20
56
Not used
-
57
Not used
-
58
Passive anti-theft system supply
5
59
Interior lamps, driver's door switch pack, glove box,
ambient lighting, power moonroof
10
60
191
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Fuses
Circuits protected
Ampere
rating
Fuse
Cigar lighter, rear power outlet
20
61
Rain sensor module, humidity sensor, auto-dimming mirror
5
62
Adaptive cruise control
10
63
Not used
-
64
Luggage compartment lid release
10
65
Driver's door lock, double locking
20
66
Information and entertainment display, GPS, bluetooth
phone voice control connectivity
7.5
67
Electrical steering column lock
15
68
Instrument cluster
5
69
Central locking
20
70
Air conditioning
10
71
Steering wheel control module
7.5
72
Battery back-up sounder (alarm system), onboard
diagnostics system
7.5
73
Main beam
15
74
Front fog lamps
15
75
Reversing lamp
10
76
Washer pump
20
77
Ignition switch or start button
5
78
Audio unit, hazard and door lock buttons
15
79
Power moonroof
20
80
Interior motion sensor, radio frequency receiver
5
81
Washer pump ground
20
82
Central locking ground
20
83
Driver's door unlock and double locking ground
20
84
192
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Fuses
Circuits protected
Ampere
rating
Fuse
Climate control heater, passenger airbag deactivation
switch, heated seats switch, auxiliary heater, manual air
conditioning heater module
7.5
85
Restraint system, passenger airbag deactivation system
10
86
Not used
-
87
Not used
-
88
Not used
-
89
Load compartment fuse box
Circuits protected
Ampere
rating
Fuse
Not used
-
1
Keyless vehicle module
10
2
Keyless vehicle door handles
5
3
Door module (left-hand front) (power windows, central
locking, electric folding mirrors, heated exterior mirrors)
25
4
Door module (right-hand front) (power windows, central
locking, electric folding mirrors, heated exterior mirrors)
25
5
Door module (left-hand rear) (power windows)
25
6
193
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Fuses
Circuits protected
Ampere
rating
Fuse
Door module (right-hand rear) (power windows)
25
7
Alarm system
10
8
Power driver's seat
25
9
Not used
-
10
Power front passenger's seat - 2.0L EcoBoost - MI4
25
11
Air conditioning module (with start-stop module)
10
12
Instrument cluster (with start-stop module)
5
13
Information and entertainment display, GPS module (with
start-stop module)
7.5
14
Audio unit, audio unit control panel (with start-stop
module)
15
15
Not used
-
16
Not used
-
17
Not used
-
18
Not used
-
19
Not used
-
20
Not used
-
21
Not used
-
22
Not used
-
23
Not used
-
24
Not used
-
25
Trailer module
40
26
Not used
-
27
Not used
-
28
Blind spot monitor, lane keeping aid, active city stop, rear
view camera (without start-stop module)
5
29
Parking aid module
5
30
194
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Fuses
Circuits protected
Ampere
rating
Fuse
Not used
-
31
Not used
-
32
Not used
-
33
Heated driver's seat
15
34
Heated front passenger's seat
15
35
Not used
-
36
Power moonroof
5
37
Not used
-
38
Not used
-
39
Not used
-
40
Retractable tow ball
5
41
Not used
-
42
Not used
-
43
Not used
-
44
Not used
-
45
Blind spot monitor, lane keeping aid, rear view camera
(with start-stop module)
10
46
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by a properly trained
technician.
Switch the ignition and all electrical
equipment off before touching or
attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Note:
You can identify a blown fuse by a
break in the filament.
Note:
All fuses, except high current fuses,
are a push fit.
Note:
A fuse puller is located in the engine
compartment fuse box.
195
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Fuses
UNDER HOOD OVERVIEW - 1.0L ECOBOOST
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 210).
A
Engine oil filler cap
*
. See
Engine Oil Check
(page 209).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 210).
C
Battery. See
Vehicle battery
(page 217).
D
Engine compartment fuse box. See
Fuses
(page 187).
E
Air cleaner. No maintenance necessary.
F
Engine oil dipstick
*
. See
Engine Oil Check
(page 209).
G
Windshield washer fluid reservoir. See
Washer Fluid Check
(page 211).
H
Engine coolant reservoir. See
Engine Coolant Check
(page 210).
I
1
The filler caps and the engine oil dipstick are colored for easy identification.
200
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Maintenance
UNDER HOOD OVERVIEW - 1.6L DURATEC-16V (SIGMA)
Engine coolant reservoir
*
: See
Engine Coolant Check
(page 210).
A
Brake and clutch fluid reservoir (right-hand drive)
*
: See
Brake and Clutch
Fluid Check
(page 210).
B
Engine oil filler cap
*
: See
Engine Oil Check
(page 209).
C
Brake and clutch fluid reservoir (left-hand drive)
*
: See
Brake and Clutch Fluid
Check
(page 210).
D
Battery: See
Vehicle battery
(page 217).
E
Engine compartment fuse box: See
Fuses
(page 187).
F
Air cleaner: No maintenance necessary.
G
201
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Maintenance
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 210).
C
Battery. See
Vehicle battery
(page 217).
D
Engine compartment fuse box. See
Fuses
(page 187).
E
Air cleaner. No maintenance necessary.
F
Engine oil dipstick
*
. See
Engine Oil Check
(page 209).
G
Windshield washer fluid reservoir. See
Washer Fluid Check
(page 211).
H
Engine coolant reservoir. See
Engine Coolant Check
(page 210).
I
1
The filler caps and the engine oil dipstick are colored for easy identification.
UNDER HOOD OVERVIEW - 2.0L ECOBOOST
Brake and clutch fluid reservoir (right-hand drive). See
Brake and Clutch Fluid
Check
(page 210).
A
Engine oil filler cap
*
. See
Engine Oil Check
(page 209).
B
Brake and clutch fluid reservoir (left-hand drive). See
Brake and Clutch Fluid
Check
(page 210).
C
203
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Maintenance
Battery. See
Vehicle battery
(page 217).
D
Engine compartment fuse box. See
Fuse Specification Chart
(page 188).
E
Air cleaner. No maintenance necessary.
F
Engine oil dipstick
*
. See
Engine Oil Check
(page 209).
G
Windshield washer fluid reservoir. See
Washer Fluid Check
(page 211).
H
Engine coolant reservoir. See
Engine Coolant Check
(page 210).
I
1
The filler caps and the engine oil dipstick are colored for easy identification.
UNDER HOOD OVERVIEW - 2.0L DURATEC-HE (MI4)
204
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Maintenance
Engine coolant reservoir
*
: See
Engine Coolant Check
(page 210).
A
Brake and clutch fluid reservoir (right-hand drive)
*
: See
Brake and Clutch
Fluid Check
(page 210).
B
Engine oil filler cap
*
: See
Engine Oil Check
(page 209).
C
Brake and clutch fluid reservoir (left-hand drive)
*
: See
Brake and Clutch Fluid
Check
(page 210).
D
Battery: See
Vehicle battery
(page 217).
E
Engine compartment fuse box: See
Fuses
(page 187).
F
Air cleaner: No maintenance necessary.
G
Engine oil dipstick
*
: See
Engine Oil Check
(page 209).
H
Windshield washer fluid reservoir
*
: See
Washer Fluid Check
(page 211).
I
*
For easy identification, filler caps and the engine oil dipstick are marked in color.
205
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Maintenance
UNDER HOOD OVERVIEW - 1.6L DIESEL
Engine coolant reservoir
*
: See
Engine Coolant Check
(page 210).
A
Brake and clutch fluid reservoir (right-hand drive)
*
: See
Brake and Clutch
Fluid Check
(page 210).
B
Engine oil filler cap
*
: See
Engine Oil Check
(page 209).
C
Brake and clutch fluid reservoir (left-hand drive)
*
: See
Brake and Clutch Fluid
Check
(page 210).
D
Battery: See
Vehicle battery
(page 217).
E
Engine compartment fuse box: See
Fuses
(page 187).
F
Air cleaner: No maintenance necessary.
G
Engine oil dipstick
*
: See
Engine Oil Check
(page 209).
H
Windshield washer fluid reservoir
*
: See
Washer Fluid Check
(page 211).
I
*
For easy identification, filler caps and the engine oil dipstick are marked in color.
206
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Maintenance
UNDER HOOD OVERVIEW - 2.0L DIESEL
Engine coolant reservoir
*
: See
Engine Coolant Check
(page 210).
A
Brake and clutch fluid reservoir (right-hand drive)
*
: See
Brake and Clutch
Fluid Check
(page 210).
B
Engine oil dipstick
*
: See
Engine Oil Check
(page 209).
C
Brake and clutch fluid reservoir (left-hand drive)
*
: See
Brake and Clutch Fluid
Check
(page 210).
D
Battery: See
Vehicle battery
(page 217).
E
Engine compartment fuse box: See
Fuses
(page 187).
F
Air cleaner: No maintenance necessary.
G
207
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Maintenance
CAUTIONS
Do not connect to the negative (
)
terminal of the flat battery.
Make sure that the cables are clear of
any moving parts and fuel delivery
system parts.
To start the engine
1.
Run the engine of vehicle
B
at
moderately high speed.
2.
Start the engine of vehicle
A
.
3.
Run both vehicles for a minimum of
three minutes before disconnecting the
cables.
CAUTION
Do not switch on the headlamps when
disconnecting the cables. The peak
voltage could blow the bulbs.
Disconnect the cables in the reverse order.
CHANGING THE 12V BATTERY
CAUTION
For vehicles with Start-stop the
battery requirement is different. It
must be replaced by one of exactly
the same specification as the original.
Note:
Where applicable, the audio system
must be reprogrammed with the keycode.
The battery is located in the engine
compartment. See
Maintenance
(page
198).
BATTERY CONNECTION
POINTS
CAUTION
Do not connect to the negative (
)
terminal of the flat battery.
The ground connection point is located to
the right of the battery near the engine
compartment fuse box.
218
Focus (CB8) Vehicles Built From: 03-03-2014, Vehicles Built Up To: 31-12-2014, CG3568en enGBR, Edition date: 03/2014, None
Vehicle battery
12 Volt DC Power Point
WARNING
Do not plug electrical accessories
into the cigar lighter socket. Incorrect
use of the lighter can cause damage
not covered by your warranty, and can
result in fire or serious injury.
Note:
When you switch the ignition on, you
can use the socket to power 12 volt
appliances with a maximum current rating
of 20 amps. After you switch the ignition off,
the power supply works only for a maximum
of 30 minutes.
Note:
Do not insert objects other than an
accessory plug into the power point. This
damages the outlet and can blow the fuse.
Note:
Do not hang any type of accessory or
accessory bracket from the plug.
Note:
Do not use the power point over the
vehicle capacity of 12 volt DC 180 watt or a
fuse may blow.
Note:
Do not use the power point for
operating a cigar lighter element.
Note:
Incorrect use of the power point can
cause damage not covered by your
warranty.
Note:
Always keep the power point caps
closed when not in use.
Run the engine for full capacity use of the
power point.
To prevent the battery from running out of
charge:
Do not use the power point longer than
necessary when your engine is not
running.
Do not leave devices plugged in
overnight or when your vehicle is in park
(P) for extended periods.
Location
Power points may be found:
On the center console.
In the center console.
In the cargo area (Wagons only).
87
Focus Electric (CEW) Battery Electric Vehicle (BEV), Vehicles Built From: 08-09-2014, CG3631en enGBR, Edition date: 11/2014, First Printing
Auxiliary Power Points
FUSE BOX LOCATIONS
Engine Compartment Fuse Box
This fuse box is located in the engine
compartment See
Under Hood Overview
(page 136).
Passenger Compartment Fuse Box
1.
Pinch the retaining clips to release the
cover.
2.
Lower the fuse box cover and pull it
toward you.
Install in the reverse order.
Luggage Compartment Fuse Box
FUSE SPECIFICATION CHART
Pre-Fuse Box
Your vehicle has a pre-fuse box located in
the electric motor compartment on the
front of the 12 volt battery box. It is
connected to the 12 volt battery positive
terminal. This fuse box contains several
high current fuses. If replacement of these
high current fuses is required, contact an
authorized dealer.
Circuits protected
Fuse rating
Fuse
Electronic power assist steering.
80A
F1
12 volt battery charge.
150A
F2
Power distribution box.
100A
F3
Body control module (supply).
50A
F4
121
Focus Electric (CEW) Battery Electric Vehicle (BEV), Vehicles Built From: 08-09-2014, CG3631en enGBR, Edition date: 11/2014, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
High voltage battery coolant element one and two.
70A
F5
Load compartment fuse box.
70A
F6
Not used.
-
F7
Electric motor cooling fan.
50A
F8
Body control module (supply).
50A
F9
High voltage battery coolant element three.
40A
F10
Electric Motor Compartment Fuse
Box
WARNING
To reduce risk of electrical shock,
always replace the cover to the
power distribution box before
reconnecting the battery or refilling fluid
reservoirs. Always disconnect the 12 volt
battery before servicing high current fuses.
This fuse box contains several high current
fuses that protect your vehicle's main
electrical systems from overloads.
If the 12 volt battery is disconnected and
reconnected, some features need to be
reset.
122
Focus Electric (CEW) Battery Electric Vehicle (BEV), Vehicles Built From: 08-09-2014, CG3631en enGBR, Edition date: 11/2014, First Printing
Fuses
Lift the release lever at the rear of the cover
to remove it.
Circuits protected
Fuse rating
Fuse
Anti-lock brake system.
40A
**
F7
Electronic stability program.
Electronic stability program.
30A
**
F8
Not used.
-
F9
Blower motor.
40A
**
F10
Vacuum pump.
40A
**
F11
Electric motor control relay.
40A
**
F12
Battery charging control module.
40A
**
F13
Coolant heater one.
40A
**
F14
123
Focus Electric (CEW) Battery Electric Vehicle (BEV), Vehicles Built From: 08-09-2014, CG3631en enGBR, Edition date: 11/2014, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Body control module.
30A
**
F15
Coolant heater two.
40A
**
F16
Not used.
-
F17
Windshield wipers.
20A
**
F18
Anti-lock brake system.
5A
*
F19
Electronic stability program.
Horn.
15A
*
F20
Stop lamp switch.
5A
*
F21
Battery monitoring system.
15A
*
F22
Relay coils.
5A
*
F23
Lighting control.
5A
*
F24
Not used.
-
F25
Powertrain control module.
10A
*
F26
Charge port light ring.
15A
*
F27
Vacuum pump monitor.
5A
*
F28
Not used.
-
F29
Transmission control module.
5A
*
F30
Data link connector.
10A
*
F31
Coolant valve.
10A
*
F32
Air conditioning solenoid.
Chiller solenoid.
Powertrain control module.
10A
*
F33
High voltage battery.
15A
*
F34
Not used.
-
F35
Coolant pump.
20A
*
F36
124
Focus Electric (CEW) Battery Electric Vehicle (BEV), Vehicles Built From: 08-09-2014, CG3631en enGBR, Edition date: 11/2014, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Vehicle audible sound for pedestrians.
5A
*
F37
Powertrain control module.
15A
*
F38
Headlamp leveling.
5A
*
F39
Electronic power assist steering.
5A
*
F40
Body control module.
20A
*
F41
Not used.
-
F42
Headlamp leveling.
15A
*
F43
Adaptive front lighting.
Not used.
-
F44
Not used.
-
F45
Not used.
-
F46
Not used.
-
F47
Mechanical relay coil fuse.
5A
*
F48
*
Mini fuses
**
Cartridge fuses
Circuit switched
Relay Type
Relay
Not used.
-
R1
Horn.
Micro relay
R2
Not used.
-
R3
High voltage battery.
Micro relay
R4
Not used.
-
R5
Not used.
-
R6
Coolant heater.
Power relay
R7
Coolant heater.
Power relay
R8
Not used.
-
R9
125
Focus Electric (CEW) Battery Electric Vehicle (BEV), Vehicles Built From: 08-09-2014, CG3631en enGBR, Edition date: 11/2014, First Printing
Fuses
Circuit switched
Relay Type
Relay
Vacuum pump.
Mini relay
R10
Not used.
-
R11
Electronic fan control module.
Power relay
R12
Blower motor.
Mini relay
R13
Electric motor control.
Mini relay
R14
Vacuum pump.
Power relay
R15
Ignition.
Power relay
R16
126
Focus Electric (CEW) Battery Electric Vehicle (BEV), Vehicles Built From: 08-09-2014, CG3631en enGBR, Edition date: 11/2014, First Printing
Fuses
Passenger Compartment Fuse Box
Circuits protected
Fuse rating
Fuse
Not used.
-
F56
Not used.
-
F57
Not used.
-
F58
Passive anti-theft transceiver.
5A
F59
Interior lighting.
10A
F60
Driver door switch pack.
Glove box lamp.
127
Focus Electric (CEW) Battery Electric Vehicle (BEV), Vehicles Built From: 08-09-2014, CG3631en enGBR, Edition date: 11/2014, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Ambient lighting.
Cigar lighter.
20A
F61
Rear auxiliary power points.
Rain sensor.
5A
F62
Humidity sensor.
Auto-dimming interior mirror.
Not used.
-
F63
Not used.
-
F64
Liftgate release.
10A
F65
Driver door lock.
20A
F66
Double locking.
Front display interface module.
7.5A
F67
Global positioning system module.
Bluetooth phone and voice control connectivity.
SYNC module.
Electrical steering column lock.
15A
F68
Instrument cluster.
5A
F69
Central locking system.
20A
F70
Air conditioning.
10A
F71
Steering wheel module.
7.5A
F72
Battery back-up sounder (alarm system).
7.5A
F73
Onboard diagnostics system.
High beam.
15A
F74
Not used.
-
F75
Reversing lamps.
10A
F76
Windshield washer pump.
20A
F77
Ignition switch.
5A
F78
Push button ignition switch.
Audio unit.
15A
F79
Hazard flasher switch.
Door lock switch.
128
Focus Electric (CEW) Battery Electric Vehicle (BEV), Vehicles Built From: 08-09-2014, CG3631en enGBR, Edition date: 11/2014, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Not used.
-
F80
Interior motion sensor.
5A
F81
Radio frequency receiver.
Windshield washer pump.
20A
F82
Central locking system.
20A
F83
Driver door unlock.
20A
F84
Double locking ground.
Air conditioning.
7.5A
F85
Passenger airbag deactivation switch.
Heated seat switches.
Auxiliary heater.
Restraints control module.
10A
F86
Passenger airbag deactivation switch.
Not used.
-
F87
Not used.
-
F88
Not used.
-
F89
Luggage Compartment Fuse Box
129
Focus Electric (CEW) Battery Electric Vehicle (BEV), Vehicles Built From: 08-09-2014, CG3631en enGBR, Edition date: 11/2014, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Telematics control unit.
5A
*
F1
Not used.
-
F2
Keyless vehicle door handles.
5A
*
F3
Front left door control unit.
25A
*
F4
Front right door control unit.
25A
*
F5
Rear left door control unit.
25A
*
F6
Rear right door control unit.
25A
*
F7
Anti-theft alarm.
10A
*
F8
Driver seat.
25A
*
F9
Heated rear window.
25A
*
F10
Battery electronic control module.
5A
*
F11
Not used.
-
F12
Not used.
-
F13
Not used.
-
F14
Not used.
-
F15
Not used.
-
F16
Not used.
-
F17
Not used.
-
F18
Not used.
-
F19
Not used.
-
F20
Not used.
-
F21
Not used.
-
F22
Not used.
-
F23
Not used.
-
F24
130
Focus Electric (CEW) Battery Electric Vehicle (BEV), Vehicles Built From: 08-09-2014, CG3631en enGBR, Edition date: 11/2014, First Printing
Fuses
Circuits protected
Fuse rating
Fuse
Not used.
-
F25
Not used.
-
F26
Not used.
-
F27
Not used.
-
F28
Rear view camera.
5A
*
F29
Parking aid module.
5A
*
F30
Not used.
-
F31
Not used.
-
F32
Rear window wiper relay.
15A
F33
Driver heated seat.
15A
*
F34
Passenger heated seat.
15A
*
F35
Not used.
-
F36
Not used.
-
F37
Not used.
-
F38
Not used.
-
F39
Not used.
-
F40
Not used.
-
F41
Not used.
-
F42
Not used.
-
F43
Not used.
-
F44
Not used.
-
F45
Not used.
-
F46
*
Mini fuses
**
Cartridge fuses
131
Focus Electric (CEW) Battery Electric Vehicle (BEV), Vehicles Built From: 08-09-2014, CG3631en enGBR, Edition date: 11/2014, First Printing
Fuses
Circuit switched
Relay Type
Relay
Rear 15.
Power relay
R1
Heated rear window.
Mini relay
R2
Rear window wiper.
Micro relay
R3
Not used.
-
R4
Anti-theft alarm horn.
Micro relay
R5
Not used.
-
R6
CHANGING A FUSE
Fuses
WARNING
Always replace a fuse with one that
has the specified amperage rating.
Using a fuse with a higher amperage
rating can cause severe wire damage and
could start a fire.
If electrical components in the vehicle are
not working, a fuse may have blown. Blown
fuses are identified by a broken wire within
the fuse. Check the appropriate fuses
before replacing any electrical
components.
Standard Fuse Amperage Rating and Color
Color
J-type fuses
M-type fuses
Dual micro fuses
Micro fuses
Fuse rating
-
-
Tan
Tan
5A
-
-
Brown
Brown
7.5A
-
-
Red
Red
10A
-
Grey
Blue
Blue
15A
Blue
Light Blue
-
Yellow
20A
White
White
-
White
25A
Pink
Pink
-
Green
30A
132
Focus Electric (CEW) Battery Electric Vehicle (BEV), Vehicles Built From: 08-09-2014, CG3631en enGBR, Edition date: 11/2014, First Printing
Fuses
Color
J-type fuses
M-type fuses
Dual micro fuses
Micro fuses
Fuse rating
Green
Green
-
-
40A
Red
-
-
-
50A
Yellow
-
-
-
60A
133
Focus Electric (CEW) Battery Electric Vehicle (BEV), Vehicles Built From: 08-09-2014, CG3631en enGBR, Edition date: 11/2014, First Printing
Fuses
UNDER HOOD OVERVIEW
Coolant reservoir. See
Coolant Check
(page 136).
A
Brake fluid reservoir (right-hand drive).
B
Brake fluid reservoir (left-hand drive).
C
12 volt battery.
D
Electric motor compartment fuse box. See
Fuses
(page 121).
E
Windshield washer fluid reservoir.
F
COOLANT CHECK
WARNING
Do not allow the fluid to touch your
skin or eyes. If this happens, rinse the
affected areas immediately with
plenty of water and contact your physician.
Failure to follow this warning could result
in serious personal injury.
Checking the Coolant
When the electric motor is cold, check the
level of the coolant in the reservoir at the
intervals listed in the scheduled
maintenance information.
If the level is at the
MIN
mark, add coolant
immediately.
Note:
Make sure that the level is between
the
MIN
and the
MAX
marks.
Note:
Coolant expands when it is hot. The
level may extend beyond the
MAX
mark.
136
Focus Electric (CEW) Battery Electric Vehicle (BEV), Vehicles Built From: 08-09-2014, CG3631en enGBR, Edition date: 11/2014, First Printing
Maintenance