Ford Focus Electric - 2012 Fuse Box Diagram

Ford Focus Electric - 2012 Fuse Box Diagram

AUXILIARY POWER POINTS
WARNING:
Do not plug optional electrical accessories into the
cigarette lighter socket (if equipped). Improper use of the lighter
can cause damage not covered by your warranty, and can result in fire
or serious injury.
Note:
Do not insert objects other than an accessory plug into the power
point. This will damage the outlet and blow the fuse.
Note:
Do not hang any type of accessory or accessory bracket from the
plug.
Note:
Do not use the power point over the vehicle capacity of 12 volts
DC 180 watts or a fuse may blow.
Note:
Do not use the power point for operating a cigarette lighter
element.
Note:
Improper use of the power point can cause damage not covered
by your warranty.
Note:
Always keep the power point caps closed when not in use.
Run the engine for full capacity use of the power point. To prevent the
battery from being discharged:
Do not use the power point longer than necessary when the engine is
not running.
Do not leave devices plugged in overnight or when the vehicle is
parked for extended periods.
Locations
Power points may be found:
on the center console
on the rear of the center console.
Driver Controls
141
2012 Focus Electric Vehicle
(fob)
Owners Guide gf, 1st Printing
USA
(fus)
WARNING:
When possible, all children 12 years old and under
should be properly restrained in a rear seating position.
WARNING:
The National Highway Traffic Safety Administration
(NHTSA) recommends a minimum distance of at least 10 inches
(25 cm) between an occupant’s chest and the driver airbag module.
WARNING:
Never place your arm over the airbag module as a
deploying airbag can result in serious arm fractures or other
injuries.
To properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly one or two degrees from the upright position.
WARNING:
Do not put anything on or over the airbag module.
Placing objects on or over the airbag inflation area may cause
those objects to be propelled by the airbag into your face and torso
causing serious injury.
WARNING:
Do not attempt to service, repair, or modify the
airbag supplemental restraint systems or its fuses. Contact your
authorized dealer as soon as possible.
Seating and Safety Restraints
195
2012 Focus Electric Vehicle
(fob)
Owners Guide gf, 1st Printing
USA
(fus)
If any of these things happen, even intermittently, have the supplemental
restraint system serviced at an authorized dealer immediately. Unless
serviced, the system may not function properly in the event of a collision.
Knee Airbag (if equipped)
The knee airbag is located under the instrument panel. The system
works along with the driver’s front airbag to help reduce injury to the
legs. When the driver’s airbag activates in a collision, the knee airbag
deploys from under the instrument panel. As with front and side airbags,
it is important to be properly seated and restrained to reduce the risk of
death or serious injury.
Seat-mounted side airbag system
WARNING:
Do not place objects or mount equipment on or near
the airbag cover on the side of the seatbacks of the front seats or
in front seat areas that may come into contact with a deploying airbag.
Failure to follow these instructions may increase the risk of personal
injury in the event of a collision.
WARNING:
Do not use accessory seat covers. The use of
accessory seat covers may prevent the deployment of the side
airbags and increase the risk of injury in an accident.
WARNING:
Do not lean your head on the door. The side airbag
could injure you as it deploys from the side of the seatback.
WARNING:
Do not attempt to service, repair, or modify the
airbag SRS, its fuses or the seat cover on a seat containing an
airbag. Contact your authorized dealer as soon as possible.
WARNING:
All occupants of the vehicle should always wear
their safety belts even when an airbag SRS is provided.
202
Seating and Safety Restraints
2012 Focus Electric Vehicle
(fob)
Owners Guide gf, 1st Printing
USA
(fus)
WARNING:
Do not attempt to service, repair, or modify the side air
curtain system, its fuses, the A, B, or C pillar trim, or the headliner
on a vehicle containing a side air curtain. See your authorized dealer.
WARNING:
All occupants of the vehicle, including the driver,
should always wear their safety belts even when an inflatable
curtain is provided.
WARNING:
To reduce the risk of injury, do not obstruct or place
objects in the deployment zone of the inflatable curtain.
How does the side air curtain system work?
The design and development of the
side air curtain system included
recommended testing procedures
that were developed by a group of
automotive safety experts known as
the Side Airbag Technical Working
Group. These recommended testing
procedures help reduce the risk of
injuries related to the deployment
of side airbags (including side air
curtain systems).
The side air curtain system consists
of the following:
An inflatable curtain with a gas
generator concealed behind the
headliner and above the doors.
The headliner will flex to open above the side doors to allow air
curtain deployment.
The same warning light, electronic control and diagnostic unit as used
for the front airbags.
Two pressure sensors located in the front doors.
Two crash sensors located on the rocker panel behind the lower C pillar.
Side air curtains and side airbags, in combination with safety belts, can
help reduce the risk of severe injuries in the event of a significant side
impact collision.
Seating and Safety Restraints
205
2012 Focus Electric Vehicle
(fob)
Owners Guide gf, 1st Printing
USA
(fus)
If the steering wanders or pulls, check for:
an improperly inflated tire.
uneven tire wear.
loose or worn suspension components.
loose or worn steering components.
improper steering alignment.
A high crown in the road or high crosswinds may also make the steering
seem to wander/pull.
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the on position unless the brake pedal is pressed, your charge cord
may be plugged into the vehicle, or there may be a fault with the
associated electrical system. If this is the case, you must follow the
instructions in your instrument cluster display before your vehicle will
start.
If you cannot move the gearshift lever out of P (Park) with ignition on
and the brake pedal pressed, it is also possible that a fuse has blown or
the vehicle’s brake lamps are not operating properly. Refer to
Fuses and
relays
in the
Roadside Emergencies
chapter.
If your charge cord is not connected and there is not a fault with the
associated electrical system, the fuse is not blown and the brake lamps
are working properly, the following procedure will allow you to move the
gearshift lever from P (Park):
1. Apply the parking brake, turn the
ignition key to the off position and
remove the key.
2. Using a screwdriver (or similar tool),
carefully pry off and remove the
passenger side access cover. Remove the
fastener, then remove the console side
panel to expose the inside of the shifter
assembly.
262
Driving
2012 Focus Electric Vehicle
(fob)
Owners Guide gf, 1st Printing
USA
(fus)
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
Standard Fuse Amperage Rating and Color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
Yellow
70A
Tan
Brown
80A
Natural
Black
Black
15
278
Roadside Emergencies
2012 Focus Electric Vehicle
(fob)
Owners Guide gf, 1st Printing
USA
(fus)
Luggage Compartment Fuse Panel
The fuse panel is located in the luggage compartment behind the left
side wheel well. Remove the fuse panel cover to gain access to the fuses.
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Protected Components
F1
5A
Telematics control unit
F2
10A
Keyless vehicle module
F3
5A
Keyless vehicle door handles
F4
25A
Door control unit – front left
F5
25A
Door control unit – front right
F6
25A
Door control unit – rear left
F7
25A
Door control unit – rear right
F8
Not used
F9
25A
Driver seat motor
F10
25A
Rear window defroster
R4
R5
R6
R2
R1
R3
F46
F28
F16
F15
F14
F13
F12
F11
F10
F9
F8
F7
F6
F5
F4
F3
F2
F1
F27
F26
F25
F24
F45
F44
F43
F42
F41
F40
F39
F38
F37
F36
F35
F23
F22
F21
F20
F19
F18
F17
F34
F33
F32
F31
F30
F29
Roadside Emergencies
279
2012 Focus Electric Vehicle
(fob)
Owners Guide gf, 1st Printing
USA
(fus)
Fuse/Relay
Location
Fuse Amp
Rating
Protected Components
F11
5A
Battery electronics control module
F12
Not used
F13
Not used
F14
Not used
F15
Not used
F16
Not used
F17
Not used
F18
Not used
F19
Not used
F20
Not used
F21
Not used
F22
Not used
F23
Not used
F24
Not used
F25
Not used
F26
Not used
F27
Not used
F28
Not used
F29
5A
Park assist camera
F30
5A
Parking aid module
F31
Not used
F32
Not used
F33
Not used
F34
15A
Driver seat heater
F35
15A
Passenger seat heater
F36
Not used
F37
Not used
F38
Not used
F39
Not used
F40
Not used
F41
Not used
280
Roadside Emergencies
2012 Focus Electric Vehicle
(fob)
Owners Guide gf, 1st Printing
USA
(fus)
Fuse/Relay
Location
Fuse Amp
Rating
Protected Components
F42
Not used
F43
Not used
F44
Not used
F45
Not used
F46
Not used
R1
Rear 15 relay
R2
Rear window defrost relay
R3
Rear wiper relay
R4
Not used
R5
Not used
R6
Not used
Passenger Compartment Fuse Panel
The fuse panel is located on the right side below the glove box.
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
88
89
82
83
84
85
86
87
Roadside Emergencies
281
2012 Focus Electric Vehicle
(fob)
Owners Guide gf, 1st Printing
USA
(fus)
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Protected Components
56
20A
Not used (spare)
57
Not used
58
Not used
59
5A
Passive anti-theft transceiver
60
10A
Interior light, Driver door switch
pack, Glove box illumination,
Overhead console switch bank
61
20A
Cigar lighter, Power point
62
5A
Rain sensor module
63
Not used
64
Not used
65
10A
Liftgate release
66
20A
Not used (spare)
67
7.5A
SYNC
²
, Multifunction display,
Global positioning system module,
Compass
68
Not used
69
5A
Instrument cluster
70
20A
Central lock and unlock supply
71
10A
Climate control
72
7.5A
Steering wheel module
73
5A
Datalink connector
74
15A
Low beam headlamp supply
75
15A
Not used (spare)
76
10A
Reversing lamp supply,
Electrochromatic rear view mirror
77
20A
Windshield and rear washer
supply
78
5A
Ignition switch, Start button
282
Roadside Emergencies
2012 Focus Electric Vehicle
(fob)
Owners Guide gf, 1st Printing
USA
(fus)
Fuse/Relay
Location
Fuse Amp
Rating
Protected Components
79
15A
Radio, Hazard light switch, Door
lock switch, Electronic finish
panel
80
20A
Not used (spare)
81
5A
Radio frequency receiver
82
20A
Windshield and rear washer relay
83
20A
Central locking
84
20A
Unlock supply, Double lock
85
7.5A
Front seat heater switch
86
10A
Airbag module, Occupant
classification sensor, Passenger
airbag deactivation indicator
87
Not used
88
Not used
89
Not used
Power Distribution Box
The power distribution box is located in the underhood compartment.
The power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
WARNING:
Always remove the high voltage battery safety
connectors to make sure the high voltage batteries are
disconnected, and always disconnect the 12 volt (underhood) battery
before servicing high current fuses.
WARNING:
To reduce risk of electrical shock, always replace the
cover to the power distribution box before reconnecting the
battery or refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
Roadside Emergencies
283
2012 Focus Electric Vehicle
(fob)
Owners Guide gf, 1st Printing
USA
(fus)
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
F1
Not used
F2
Not used
F3
Not used
F4
Not used
F5
Not used
F6
Not used
F7
40A**
Anti-lock brakes pump
F8
30A**
Anti-lock brakes valve
F9
Not used
F10
40A**
Heater blower motor,
Temperature sensor
F11
40A**
Vacuum pump
F12
40A**
Motor control relay fuse
F30
F31
F24
F21
F20
F25
F22
F23
F17
R10
R9
R6
F15
F19
F8
F7
F37
F38
F39
F40
F41
F43
F42
F44
F45
F46
F48
F47
F13
F11
F9
F16
F14
F12
F10
R11
R8
R7
R16
R15
R3
R5
R4
R2
R1
F18
F26
F27
F32
F33
F34
F35
F28
F29
R12
R13
R14
F36
284
Roadside Emergencies
2012 Focus Electric Vehicle
(fob)
Owners Guide gf, 1st Printing
USA
(fus)
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
F13
40A**
On-board charger
F14
40A**
Heater element 1
F15
Not used
F16
40A**
Heater element 2
F17
Not used
F18
20A**
Front wiper motor
F19
5A*
Anti-lock brake control module
F20
15A*
Horn
F21
5A*
Stop light switch
F22
15A*
Battery monitoring sensor
F23
5A*
Relay coils
F24
5A*
Light switch module
F25
Not used
F26
10A*
Powertrain Control Module (PCM)
F27
15A*
Charger port light ring
F28
5A*
Vacuum pump monitor
F29
Not used
F30
5A*
Transmission control module
F31
10A*
Smart datalink connector;
Diagnostic connector
F32
10A*
Compressor bypass valves,
Coolant valves, Electronic fan
control module relay
F33
10A*
PCM (PSR feedback), A/C
compressor solenoid
F34
15A*
PCM (contactor sense), Battery
electronics control module (PSR)
F35
Not used
F36
20A*
Coolant water pumps
F37
5A*
Vehicle audible speaker for
pedestrians
Roadside Emergencies
285
2012 Focus Electric Vehicle
(fob)
Owners Guide gf, 1st Printing
USA
(fus)
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
F38
15A*
PCM (electronic control module
KL15)
F39
5A*
Not used (spare)
F40
5A*
Electronic power assist steering
F41
20A*
Body Control Module (BCM)
F42
15A*
Rear wiper
F43
15A*
Not used (spare)
F44
Not used
F45
Not used
F46
Not used
F47
5A*
In-Car temperature sensor
F48
5A*
Mechanical relay
R1
Not used
R2
Micro relay
Horn relay
R3
Not used
R4
Micro relay
Contactor relay
R5
Not used
R6
Not used
R7
Power relay
Heater element 3
R8
Power relay
Heater element 1 & 2
R9
Not used
R10
Mini relay
ABS vacuum pump (solid state
relay)
R11
Not used
R12
Power relay
Electronic Fan Control Module
(EFCM) relay
R13
Mini relay
Heater blower relay
R14
Mini relay
Motor control relay
R15
Power relay
Mechanical relay
R16
Power relay
Ignition 15
*Mini Fuses **Cartridge Fuses
286
Roadside Emergencies
2012 Focus Electric Vehicle
(fob)
Owners Guide gf, 1st Printing
USA
(fus)