Ford Focus - 2010 Fuse Box Diagram

Ford Focus - 2010 Fuse Box Diagram

2. To calibrate, press and hold the 7
and 9 radio preset buttons together
for approximately 10 seconds until
CAL appears. Release the buttons.
3. Slowly drive the vehicle in a
circle (less than 3 mph [5 km/h])
until the CAL display changes to the
direction value (N, S, E, W, etc.). It
may take up to five circles to
complete calibration.
4. The compass is now calibrated.
CENTER CONSOLE
Your vehicle has a variety of console features. These include:
Cupholders
Utility compartment
WARNING:
Use only soft cups in the cupholder. Hard objects
can injure you in a collision.
AUXILIARY POWER POINT (12VDC)
Power outlet is designed for accessory plugs only. Do not insert
any other object in the power outlet as this will damage the
outlet and blow the fuse. Do not hang any type of accessory or
accessory bracket from the plug. Improper use of the power
outlet can cause damage not covered by your warranty.
The auxiliary power points are located near the bottom of the center
stack.
Do not use the power point for operating the cigarette lighter element (if
equipped).
To prevent the fuse from being blown, do not use the power point(s)
over the vehicle capacity of 12 VDC/180W. If the power point or cigar
lighter socket is not working, a fuse may have blown. Refer to
Fuses and
relays
in the
Roadside Emergencies
chapter for information on
checking and replacing fuses.
Driver Controls
58
2010 Focus
(foc)
Owners Guide, 1st Printing
USA
(fus)
WARNING:
When possible, all children 12 years old and under
should be properly restrained in a rear seating position.
WARNING:
The National Highway Traffic Safety Administration
(NHTSA) recommends a minimum distance of at least 10 inches
(25 cm) between an occupant’s chest and the driver airbag module.
WARNING:
Never place your arm over the airbag module as a
deploying airbag can result in serious arm fractures or other
injuries.
To properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly one or two degrees from the upright position.
WARNING:
Do not put anything on or over the airbag module.
Placing objects on or over the airbag inflation area may cause
those objects to be propelled by the airbag into your face and torso
causing serious injury.
WARNING:
Do not attempt to service, repair, or modify the
airbag supplemental restraint systems or its fuses. Contact your
authorized dealer as soon as possible.
Seating and Safety Restraints
111
2010 Focus
(foc)
Owners Guide, 1st Printing
USA
(fus)
A difficulty with the system is indicated by one or more of the following:
The readiness light (same light
for front and side airbag system)
will either flash or stay lit.
The readiness light will not
illuminate immediately after ignition is turned on.
A series of five beeps will be heard. The tone pattern will repeat
periodically until the problem and/or light are repaired.
If any of these things happen, even intermittently, have the supplemental
restraint system serviced at an authorized dealer immediately. Unless
serviced, the system may not function properly in the event of a
collision.
Seat-mounted side airbag system
WARNING:
Do not place objects or mount equipment on or
near the airbag cover on the side of the seatbacks of the front
seats or in front seat areas that may come into contact with a
deploying airbag. Failure to follow these instructions may increase the
risk of personal injury in the event of a collision.
WARNING:
Do not use accessory seat covers. The use of
accessory seat covers may prevent the deployment of the side
airbags and increase the risk of injury in an accident.
WARNING:
Do not lean your head on the door. The side airbag
could injure you as it deploys from the side of the seatback.
WARNING:
Do not attempt to service, repair, or modify the
airbag SRS, its fuses or the seat cover on a seat containing an
airbag. Contact your authorized dealer as soon as possible.
WARNING:
All occupants of the vehicle should always wear
their safety belts even when an airbag SRS is provided.
Seating and Safety Restraints
119
2010 Focus
(foc)
Owners Guide, 1st Printing
USA
(fus)
WARNING:
Do not attempt to service, repair, or modify the side
air curtain system, its fuses, the A, B, or C pillar trim, or the
headliner on a vehicle containing a side air curtain. See your
authorized dealer.
WARNING:
All occupants of the vehicle, including the driver,
should always wear their safety belts even when an inflatable
curtain is provided.
WARNING:
To reduce the risk of injury, do not obstruct or
place objects in the deployment zone of the inflatable curtain.
How does the side air curtain system work?
The design and development of the
side air curtain system included
recommended testing procedures
that were developed by a group of
automotive safety experts known as
the Side Airbag Technical Working
Group. These recommended testing
procedures help reduce the risk of
injuries related to the deployment of
side airbags (including side air
curtain systems).
The side air curtain system consists
of the following:
An inflatable nylon curtain with a
gas generator concealed behind
the headliner and above the
doors.
The headliner will flex to open
above the side doors to allow air curtain deployment.
The same warning light, electronic control and diagnostic unit as used
for the front airbags.
Seating and Safety Restraints
122
2010 Focus
(foc)
Owners Guide, 1st Printing
USA
(fus)
Do not fill the power steering fluid reservoir above the MAX mark on
the reservoir.
If the power steering system breaks down (or if the engine is turned
off), you can steer the vehicle manually, but it takes more effort.
If the steering wanders or pulls, check for:
an improperly inflated tire
uneven tire wear
loose or worn suspension components
loose or worn steering components
improper steering alignment
A high crown in the road or high crosswinds may also make the steering
seem to wander/pull.
BRAKE-SHIFT INTERLOCK
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the on position unless the brake pedal is pressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the on position and the brake pedal pressed, it is possible that a fuse has
blown or the vehicle’s brakelamps are not operating properly. Refer to
Fuses and relays
in the
Roadside Emergencies
chapter.
If the fuse is not blown and the brakelamps are working properly, the
following procedure will allow you to move the gearshift lever from P
(Park):
Driving
183
2010 Focus
(foc)
Owners Guide, 1st Printing
USA
(fus)
Note:
With extended use, the flasher may run down your battery.
FUEL PUMP SHUT-OFF SWITCH
This device stops the electric fuel pump from sending fuel to the engine
when your vehicle has had a substantial jolt.
After an accident, if the engine cranks but does not start, this switch
may have been activated.
This switch is located in the front
passenger’s footwell, behind the kick
panel access cover.
To reset the switch:
1. Turn the ignition off.
2. Check the fuel system for leaks.
3. If no leaks are apparent, reset the
switch by pressing in on the reset
button.
4. Turn the ignition to the on position.
5. Wait a few seconds and return the key to off.
6. Make another check for leaks.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
15
Roadside Emergencies
192
2010 Focus
(foc)
Owners Guide, 1st Printing
USA
(fus)
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
Yellow
70A
Tan
Brown
80A
Natural
Black
Black
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the fuse panel cover to gain access to the fuses.
To remove a fuse use the fuse puller tool provided on the fuse panel
cover.
Roadside Emergencies
193
2010 Focus
(foc)
Owners Guide, 1st Printing
USA
(fus)
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Protected circuits
1
30A
Not used (spare)
2
15A
Brake switch (high-mount brake
lamp)
3
15A
Not used (spare)
4
30A
Not used (spare)
5
10A
Shift interlock
6
20A
Right front turn lamp/Left front
turn lamp, Rear stop/turn lamps
7
10A
Left low beam headlamp
8
10A
Right low beam headlamp
9
15A
Interior lamps
10
15A
Instrument panel backlighting
Roadside Emergencies
194
2010 Focus
(foc)
Owners Guide, 1st Printing
USA
(fus)
Fuse/Relay
Location
Fuse Amp
Rating
Protected circuits
11
10A
Not used (spare)
12
7.5A
Power mirrors
13
5A
SYNC
±
14
10A
Not used (spare)
15
10A
Recirculated air, Air conditioning
16
15A
Not used (spare)
17
20A
Power locks, Trunk release
18
20A
Heated seats
19
25A
Not used (spare)
20
15A
Data link connector
21
15A
Fog lamps, Fog lamp indicator
22
15A
Parking lamps
23
15A
High beam lamps
24
20A
Horn
25
10A
Demand lamps, Trunk lamps
26
10A
Instrument cluster
27
20A
Ignition switch
28
5A
Radio (Start)
29
5A
Instrument cluster (Run/Start)
30
5A
Not used (spare)
31
10A
Not used (spare)
32
10A
Restraints control module
33
10A
Not used (spare)
34
5A
Not used (spare)
35
10A
Anti-lock brake system (ABS)
36
5A
Passive anti-theft system (PATS)
module
37
10A
Climate control (Run/Start)
38
20A
Subwoofer
39
20A
Radio, Center information display,
Electronic finish panel
Roadside Emergencies
195
2010 Focus
(foc)
Owners Guide, 1st Printing
USA
(fus)
Fuse/Relay
Location
Fuse Amp
Rating
Protected circuits
40
20A
Not used (spare)
41
15A
Door lock/sunroof switch
illumination, Auto dimming rear
view mirror, Ambient lighting
42
10A
Not used (spare)
43
10A
Not used (spare)
44
10A
Not used (spare)
45
5A
Front wipers (logic)
46
7.5A
Front passenger sensing system
47
30A (circuit
breaker)
Sunroof, Power windows
48
Delayed accessory relay
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
WARNING:
Always disconnect the battery before servicing high
current fuses.
WARNING:
To reduce risk of electrical shock, always replace
the cover to the power distribution box before reconnecting the
battery or refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
Roadside Emergencies
196
2010 Focus
(foc)
Owners Guide, 1st Printing
USA
(fus)
To remove a fuse, use the fuse puller tool provided on the inside of the
passenger compartment fuse panel cover.
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Protected circuits
1
15A
Heated mirror
2
30A
Rear defrost
3
20A
Power point
4
20A
Fuel pump
5
10A
Powertrain control module (PCM)
keep alive power, Canister Vent
6
15A
Alt sense
7
10A
Reverse lamps
8
Not used
9
40A
Anti-lock brake system (ABS)
motor
10
30A
Wipers
11
30A
Starter
12
40A
Blower
13
10A
A/C clutch
14
10A
PCM relay coil
15
20A
Power point
16
20A
Cooling fan—low
17
30A
Cooling fan—high
Roadside Emergencies
197
2010 Focus
(foc)
Owners Guide, 1st Printing
USA
(fus)
Fuse/Relay
Location
Fuse Amp
Rating
Protected circuits
18
20A
ABS solenoid
19
Not used
20
A/C clutch relay
21A
Rear defrost relay
21B
Not used
21C
Blower relay
21D
PCM relay
22
10A
Fuel injector
23
Not used
24
Not used
25
Not used
26
15A
PCM – emission related
powertrain components
27
Not used
28
15A
PCM
29
15A
Ignition
30A
Cooling fan low speed relay
30B
Starter relay
30C
Not used
30D
Cooling fan high speed relay
31A
Reverse lamp relay
31B
Fuel pump relay
31C
Wiper power relay
31D
Not used
31E
Not used
31F
Not used
32
A/C clutch diode
33
EEC diode
34
One touch integrated start (OTIS)
diode
35
10A
Run/Start
Roadside Emergencies
198
2010 Focus
(foc)
Owners Guide, 1st Printing
USA
(fus)
2. To calibrate, press and hold the 7
and 9 radio preset buttons together
for approximately 10 seconds until
CAL appears. Release the buttons.
3. Slowly drive the vehicle in a
circle (less than 3 mph [5 km/h])
until the CAL display changes to the
direction value (N, S, E, W, etc.). It
may take up to five circles to
complete calibration.
4. The compass is now calibrated.
CENTER CONSOLE
Your vehicle has a variety of console features. These include:
Cupholders
Utility compartment
WARNING:
Use only soft cups in the cupholder. Hard objects
can injure you in a collision.
AUXILIARY POWER POINT (12VDC)
Power outlet is designed for accessory plugs only. Do not insert
any other object in the power outlet as this will damage the
outlet and blow the fuse. Do not hang any type of accessory or
accessory bracket from the plug. Improper use of the power
outlet can cause damage not covered by your warranty.
The auxiliary power points are located near the bottom of the center
stack.
Do not use the power point for operating the cigarette lighter element (if
equipped).
To prevent the fuse from being blown, do not use the power point(s)
over the vehicle capacity of 12 VDC/180W. If the power point or cigar
lighter socket is not working, a fuse may have blown. Refer to
Fuses and
relays
in the
Roadside Emergencies
chapter for information on
checking and replacing fuses.
Driver Controls
58
WARNING:
When possible, all children 12 years old and under
should be properly restrained in a rear seating position.
WARNING:
The National Highway Traffic Safety Administration
(NHTSA) recommends a minimum distance of at least 10 inches
(25 cm) between an occupant’s chest and the driver airbag module.
WARNING:
Never place your arm over the airbag module as a
deploying airbag can result in serious arm fractures or other
injuries.
To properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly one or two degrees from the upright position.
WARNING:
Do not put anything on or over the airbag module.
Placing objects on or over the airbag inflation area may cause
those objects to be propelled by the airbag into your face and torso
causing serious injury.
WARNING:
Do not attempt to service, repair, or modify the
airbag supplemental restraint systems or its fuses. Contact your
authorized dealer as soon as possible.
Seating and Safety Restraints
111
A difficulty with the system is indicated by one or more of the following:
The readiness light (same light
for front and side airbag system)
will either flash or stay lit.
The readiness light will not
illuminate immediately after ignition is turned on.
A series of five beeps will be heard. The tone pattern will repeat
periodically until the problem and/or light are repaired.
If any of these things happen, even intermittently, have the supplemental
restraint system serviced at an authorized dealer immediately. Unless
serviced, the system may not function properly in the event of a
collision.
Seat-mounted side airbag system
WARNING:
Do not place objects or mount equipment on or
near the airbag cover on the side of the seatbacks of the front
seats or in front seat areas that may come into contact with a
deploying airbag. Failure to follow these instructions may increase the
risk of personal injury in the event of a collision.
WARNING:
Do not use accessory seat covers. The use of
accessory seat covers may prevent the deployment of the side
airbags and increase the risk of injury in an accident.
WARNING:
Do not lean your head on the door. The side airbag
could injure you as it deploys from the side of the seatback.
WARNING:
Do not attempt to service, repair, or modify the
airbag SRS, its fuses or the seat cover on a seat containing an
airbag. Contact your authorized dealer as soon as possible.
WARNING:
All occupants of the vehicle should always wear
their safety belts even when an airbag SRS is provided.
Seating and Safety Restraints
119
WARNING:
Do not attempt to service, repair, or modify the side
air curtain system, its fuses, the A, B, or C pillar trim, or the
headliner on a vehicle containing a side air curtain. See your
authorized dealer.
WARNING:
All occupants of the vehicle, including the driver,
should always wear their safety belts even when an inflatable
curtain is provided.
WARNING:
To reduce the risk of injury, do not obstruct or
place objects in the deployment zone of the inflatable curtain.
How does the side air curtain system work?
The design and development of the
side air curtain system included
recommended testing procedures
that were developed by a group of
automotive safety experts known as
the Side Airbag Technical Working
Group. These recommended testing
procedures help reduce the risk of
injuries related to the deployment of
side airbags (including side air
curtain systems).
The side air curtain system consists
of the following:
An inflatable curtain with a gas
generator concealed behind the
headliner and above the doors.
The headliner will flex to open
above the side doors to allow air
curtain deployment.
The same warning light, electronic control and diagnostic unit as used
for the front airbags.
Seating and Safety Restraints
122
Some noise is normal during operation. If the noise is excessive, check
for a low power steering fluid level before seeking service by your
authorized dealer.
Heavy or uneven steering efforts may be caused by a low power
steering fluid level. Check for a low power steering fluid level before
seeking service by your authorized dealer.
Do not fill the power steering fluid reservoir above the MAX mark on
the reservoir.
If the power steering system breaks down (or if the engine is turned
off), you can steer the vehicle manually, but it takes more effort.
If the steering wanders or pulls, check for:
An improperly inflated tire
Uneven tire wear
Loose or worn suspension components
Loose or worn steering components
Improper steering alignment
A high crown in the road or high crosswinds may also make the steering
seem to wander/pull.
BRAKE-SHIFT INTERLOCK
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the on position unless the brake pedal is pressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the on position and the brake pedal pressed, it is possible that a fuse has
blown or the vehicle’s brakelamps are not operating properly. Refer to
Fuses and relays
in the
Roadside Emergencies
chapter.
Driving
184
If the fuse is not blown and the brakelamps are working properly, the
following procedure will allow you to move the gearshift lever from P
(Park):
1. Apply the parking brake, turn
ignition key to off, then remove the
key.
2. Using a screwdriver (or similar
tool), remove the protective cover
to the interlock release access hole
on the console.
3. Insert the screwdriver (or similar
tool) into the access hole and press
downward while pulling the
gearshift lever out of the P (Park)
position and into the N (Neutral)
position.
4. Remove the tool and reinstall the
protective cover.
5. Start the vehicle and release the parking brake.
See your authorized dealer as soon as possible if this procedure
is used.
WARNING:
Do not drive your vehicle until you verify that the
brakelamps are working.
WARNING:
Always set the parking brake fully and make sure
the gearshift is latched in P (Park). Turn the ignition to the off
position and remove the key whenever you leave your vehicle.
WARNING:
If the parking brake is fully released, but the brake
warning lamp remains illuminated, the brakes may not be
working properly. See your authorized dealer.
Driving
185
Note:
With extended use, the flasher may run down your battery.
FUEL PUMP SHUT-OFF SWITCH
This device stops the electric fuel pump from sending fuel to the engine
when your vehicle has had a substantial jolt.
After an accident, if the engine cranks but does not start, this switch
may have been activated.
This switch is located in the front
passenger’s footwell, behind the kick
panel access cover.
To reset the switch:
1. Turn the ignition off.
2. Check the fuel system for leaks.
3. If no leaks are apparent, reset the
switch by pressing in on the reset
button.
4. Turn the ignition to the on position.
5. Wait a few seconds and return the key to off.
6. Make another check for leaks.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
15
Roadside Emergencies
193
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
Yellow
70A
Tan
Brown
80A
Natural
Black
Black
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the fuse panel cover to gain access to the fuses.
To remove a fuse use the fuse puller tool provided on the fuse panel
cover.
Roadside Emergencies
194
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Protected circuits
1
30A
Not used (spare)
2
15A
Brake switch (high-mount brake
lamp)
3
15A
Not used (spare)
4
30A
Not used (spare)
5
10A
Shift interlock
6
20A
Right front turn lamp/Left front
turn lamp, Rear stop/turn lamps
7
10A
Left low beam headlamp
8
10A
Right low beam headlamp
9
15A
Interior lamps
10
15A
Instrument panel backlighting
Roadside Emergencies
195
Fuse/Relay
Location
Fuse Amp
Rating
Protected circuits
11
10A
Not used (spare)
12
7.5A
Power mirrors
13
5A
SYNC
±
14
10A
Not used (spare)
15
10A
Recirculated air, Air conditioning
16
15A
Global positioning system (GPS)
module
17
20A
Power locks, Trunk release
18
20A
Heated seats
19
25A
Not used (spare)
20
15A
Data link connector
21
15A
Fog lamps, Fog lamp indicator
22
15A
Parking lamps
23
15A
High beam lamps
24
20A
Horn
25
10A
Demand lamps, Trunk lamps
26
10A
Instrument cluster
27
20A
Ignition switch
28
5A
Radio (Start)
29
5A
Instrument cluster (Run/Start)
30
5A
Not used (spare)
31
10A
Not used (spare)
32
10A
Restraints control module
33
10A
Not used (spare)
34
5A
Not used (spare)
35
10A
Anti-lock brake system (ABS)
36
5A
Passive anti-theft system (PATS)
module
37
10A
Climate control (Run/Start)
38
20A
Subwoofer
Roadside Emergencies
196
Fuse/Relay
Location
Fuse Amp
Rating
Protected circuits
39
20A
Radio, Center information display,
Electronic finish panel
40
20A
Not used (spare)
41
15A
Door lock/sunroof switch
illumination, Auto dimming rear
view mirror, Ambient lighting
42
10A
Not used (spare)
43
10A
Heated seats relay
44
10A
Not used (spare)
45
5A
Front wipers (logic)
46
7.5A
Front passenger sensing system
47
30A (circuit
breaker)
Sunroof, Power windows
48
Delayed accessory relay
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
WARNING:
Always disconnect the battery before servicing high
current fuses.
WARNING:
To reduce risk of electrical shock, always replace
the cover to the power distribution box before reconnecting the
battery or refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
Roadside Emergencies
197
To remove a fuse, use the fuse puller tool provided on the inside of the
passenger compartment fuse panel cover.
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Protected circuits
1
15A
Heated mirror
2
30A
Rear defrost
3
20A
Power point
4
20A
Fuel pump
5
10A
Powertrain control module (PCM)
keep alive power, Canister Vent
6
15A
Alt sense
7
10A
Reverse lamps
8
Not used
9
40A
Anti-lock brake system (ABS)
motor
10
30A
Wipers
11
30A
Starter
12
40A
Blower
13
10A
A/C clutch
14
10A
PCM relay coil
15
20A
Power point
16
20A
Cooling fan—low
17
30A
Cooling fan—high
Roadside Emergencies
198
Fuse/Relay
Location
Fuse Amp
Rating
Protected circuits
18
20A
ABS solenoid
19
Not used
20
A/C clutch relay
21A
Rear defrost relay
21B
Not used
21C
Blower relay
21D
PCM relay
22
10A
Fuel injector
23
Not used
24
Not used
25
Not used
26
15A
PCM – emission related
powertrain components
27
Not used
28
15A
PCM
29
15A
Ignition
30A
Cooling fan low speed relay
30B
Starter relay
30C
Not used
30D
Cooling fan high speed relay
31A
Reverse lamp relay
31B
Fuel pump relay
31C
Wiper power relay
31D
Not used
31E
Not used
31F
Not used
32
Not used
33
EEC diode
34
One touch integrated start (OTIS)
diode
35
10A
Run/Start
Roadside Emergencies
199
FUSE BOX LOCATIONS
Engine compartment fuse box
This fuse box is located in the engine
compartment See
Maintenance
(page
185).
Passenger compartment fuse
box
E130170
E130171
1.
Pinch the retaining clips to release the
cover.
2.
Lower the fuse box cover and pull it
towards you.
Install in the reverse order.
Load compartment fuse box
E130147
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by a properly trained
technician.
Switch the ignition and all electrical
equipment off before touching or
attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Note:
You can identify a blown fuse by
a break in the filament.
Note:
All fuses, except high current
fuses, are a push fit.
Note:
A fuse puller is located in the
engine compartment fuse box.
174
Fuses
FUSE SPECIFICATION CHART
Engine compartment fuse box
E129925
Circuits protected
Ampere
rating
Fuse
ABS pump, Electronic Stability Program (ESP) pump
40
7
Electronic Stability Program (ESP) valve
30
8
Heated rear window
30
9
Heater blower
40
10
Voltage quality module
30
11
Engine Control Relay
30
12
Starter relay
30
13
Heated windscreen (right-hand side)
40
14
Not used
-
15
175
Fuses
Circuits protected
Ampere
rating
Fuse
Heated windscreen (left-hand side)
40
16
Fuel operated heater
20
17
Windscreen wipers
20
18
ABS, Electronic Stability Program (ESP) module
5
19
Horn
15
20
Stop lamp switch
5
21
Battery monitoring system
15
22
Relay coils, light switch module
5
23
Rear power outlet
20
24
Electric exterior mirrors
10
25
Transmission control module
15
26
Air conditioning clutch
15
27
Forward looking radar
5
28
Headlamp washer
20
29
Engine control module
5
30
Intercooler fan - 1.6L Duratorq TDCi
15
31
EGR Valve, swirl control valves, HEGO sensor (engine
management)
10
32
Ignition Coils
10
33
Injectors
10
34
Diesel filter heater, active grille shutters
15
35
Engine control module
10
36
ABS
5
37
Engine control module, transmission control module
15
38
Headlamp control module
5
39
Electric power assisted steering
5
40
Body Control Module
20
41
176
Fuses
Circuits protected
Ampere
rating
Fuse
Rear window wiper
15
42
Headlamp levelling
15
43
Forward looking radar (FLR), forward sensing module
(FSM), adaptive cruise control module
5
44
Heated washer jets
10
45
Power windows (front)
25
46
Heated exterior mirrors
7.5
47
Vapouriser - 2.0L Duratorq TDCi
15
48
177
Fuses
Passenger compartment fuse box
E129926
178
Fuses
Circuits protected
Ampere
rating
Fuse
Fuel pump supply
20
56
Not used
-
57
Not used
-
58
Passive anti theft system (PATS) supply
5
59
Interior lamp, driver's door switch pack, glove box,
OHCSB
10
60
Cigar lighter, rear power outlet
20
61
Rain sensor module, humidity sensor, interior mirror
5
62
Forward sensing module (adaptive cruise control)
10
63
Not used
-
64
Liftgate release
10
65
Driver's door lock, double locking
20
66
Multi function display, GPS, BVC
7.5
67
Steering column lock
15
68
Instrument cluster
5
69
Central locking
20
70
Air conditioning
10
71
Steering wheel control module
7.5
72
Battery backup sounder (alarm system), OBD II (board
computer diagnostics)
5
73
Main beam
15
74
Front fog lamps
15
75
Reversing lamp
10
76
Washer pump
20
77
Ignition switch or start button
5
78
Radio, hazard and door lock buttons
15
79
Power sunroof, power sunblind
20
80
179
Fuses
Circuits protected
Ampere
rating
Fuse
Interior motion sensor, RF receiver
5
81
Washer pump ground
20
82
Central locking ground
20
83
Driver's door lock and double locking ground
20
84
PTC heater, passenger airbag deactivation switch,
heated seats switch, parking heater, manual air condi-
tioning heater module
7.5
85
Restraint system, passenger airbag deactivation
10
86
Not used
-
87
Not used
-
88
Not used
-
89
Load compartment fuse box
E129927
Circuits protected
Ampere
rating
Fuse
Not used
-
1
Keyless vehicle module
10
2
Keyless vehicle door handles
5
3
180
Fuses
Circuits protected
Ampere
rating
Fuse
Door module (left-hand front) (power windows, central
locking, electric folding exterior mirror, heated exterior
mirror)
25
4
Door module (right-hand front) (window up/down, central
locking, electric folding mirror, heated mirror)
25
5
Door module (left-hand rear) (window up/down)
25
6
Door module (right-hand rear) (window up/down)
25
7
Security Horn
10
8
Electric driver's seat
25
9
Not used
-
10
Not used
-
11
Air conditioning module (with voltage quality module)
10
12
Instrument cluster (with voltage quality module)
5
13
Multi function display, GPS module (with voltage quality
module)
7.5
14
Audio unit, audio unit control panel (with voltage quality
module)
15
15
Not used
-
16
Not used
-
17
Not used
-
18
Not used
-
19
Not used
-
20
Not used
-
21
Not used
-
22
Not used
-
23
Not used
-
24
Not used
-
25
Accessories, trailer module
40
26
181
Fuses
Circuits protected
Ampere
rating
Fuse
Not used
-
27
Not used
-
28
Blind spot information system, forward looking camera,
rear view camera (without Voltage Quality Module)
5
29
Park aid module
5
30
Not used
-
31
Not used
-
32
Not used
-
33
Heated driver's seat
15
34
Heated front passenger seat
15
35
Not used
-
36
Power sunroof
5
37
Not used
-
38
Not used
-
39
Not used
-
40
Not used
-
41
Not used
-
42
Not used
-
43
Not used
-
44
Not used
-
45
Blind spot information system, forward looking camera,
rear view camera (with voltage quality module)
10
46
182
Fuses
ENGINE COMPARTMENT OVERVIEW - 1.6L DURATEC-16V
TI-VCT (SIGMA)
E130030
A
B
C
D
E
F
G
H
I
Engine coolant reservoir
*
: See
Engine coolant check
(page 193).
A
Brake and clutch fluid reservoir (right-hand drive)
*
: See
Brake and clutch
fluid check
(page 194).
B
Engine oil filler cap
*
: See
Engine oil check
(page 192).
C
Brake and clutch fluid reservoir (left-hand drive)
*
: See
Brake and clutch
fluid check
(page 194).
D
Battery: See
Vehicle battery
(page 199).
E
Engine compartment fuse box: See
Fuses
(page 174).
F
Air cleaner: No maintenance necessary.
G
187
Maintenance
Brake and clutch fluid reservoir (left-hand drive). See
Brake and clutch
fluid check
(page 194).
C
Battery. See
Vehicle battery
(page 199).
D
Engine compartment fuse box. See
Fuses
(page 174).
E
Air cleaner. No maintenance necessary.
F
Engine oil dipstick
1
. See
Engine oil check
(page 192).
G
Screen washer fluid reservoir. See
Washer fluid check
(page 194).
H
Engine coolant reservoir. See
Engine coolant check
(page 193).
I
1
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINECOMPARTMENTOVERVIEW-1.6LDURATORQ-TDCI
(DV) DIESEL
E130031
A
B
C
D
E
F
G
H
I
189
Maintenance
Engine coolant reservoir
*
: See
Engine coolant check
(page 193).
A
Brake and clutch fluid reservoir (right-hand drive)
*
: See
Brake and clutch
fluid check
(page 194).
B
Engine oil filler cap
*
: See
Engine oil check
(page 192).
C
Brake and clutch fluid reservoir (left-hand drive)
*
: See
Brake and clutch
fluid check
(page 194).
D
Battery: See
Vehicle battery
(page 199).
E
Engine compartment fuse box: See
Fuses
(page 174).
F
Air cleaner: No maintenance necessary.
G
Engine oil dipstick
*
: See
Engine oil check
(page 192).
H
Screen washer fluid reservoir
*
: See
Washer fluid check
(page 194).
I
*
For easy identification, filler caps and the engine oil dipstick are marked in colour.
190
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.0L DURATORQ-
TDCI (DW) DIESEL
E130032
A
B
C
D
E
F
G
H
I
Engine coolant reservoir
*
: See
Engine coolant check
(page 193).
A
Brake and clutch fluid reservoir (right-hand drive)
*
: See
Brake and clutch
fluid check
(page 194).
B
Engine oil dipstick
*
: See
Engine oil check
(page 192).
C
Brake and clutch fluid reservoir (left-hand drive)
*
: See
Brake and clutch
fluid check
(page 194).
D
Battery: See
Vehicle battery
(page 199).
E
Engine compartment fuse box: See
Fuses
(page 174).
F
Air cleaner: No maintenance necessary.
G
191
Maintenance
Note:
Where applicable, the audio
system must be reprogrammed with the
keycode.
The battery is located in the engine
compartment. See
Maintenance
(page
185).
BATTERY CONNECTION
POINTS
CAUTION
Do not connect to the negative
(–) terminal of the flat battery.
E130431
The ground connection point is located
to the right of the battery near the engine
compartment fuse box.
200
Vehicle battery