Ford Focus - 2007 Fuse Box Diagram

Ford Focus - 2007 Fuse Box Diagram

Installing a garage door opener (if equipped)
The storage compartment can be converted to accommodate a variety of
aftermarket garage door openers:
Place the VELCRO
±
hook onto
the side of the aftermarket
transmitter opposite of the
button.
Place the transmitter into storage
compartment, button down.
Place the provided height
adaptors onto the back of the
door as needed.
Close the door.
Press the depression in the door
to activate the transmitter.
AUXILIARY POWER POINT (12VDC)
Power outlet is designed for accessory plugs only. Do not insert
any other object in the power outlet as this will damage the
outlet and blow the fuse. Do not hang any type of accessory or
accessory bracket from the plug. Improper use of the power
outlet can cause damage not covered by your warranty.
The auxiliary power point is located
on the instrument panel.
Do not use the power point for
operating the cigarette lighter
element (if equipped).
To prevent the fuse from being
blown, do not use the power point
over the vehicle capacity of 12
VDC/180W.
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Driver Controls
42
All occupants of the vehicle, including the driver, should always
properly wear their safety belts, even when an air bag
supplemental restraint system (SRS) is provided.
Always transport children 12 years old and under in the back
seat and always properly use appropriate child restraints.
The National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 10 inches (25 cm)
between an occupant’s chest and the driver airbag module.
Never place your arm over the airbag module as a deploying
airbag can result in serious arm fractures or other injuries.
To properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly one or two degrees from the upright position.
Do not put anything on or over the airbag module. Placing
objects on or over the airbag inflation area may cause those
objects to be propelled by the airbag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the airbag
supplemental restraint systems or its fuses. See your authorized
dealer.
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Seating and Safety Restraints
84
A difficulty with the system is indicated by one or more of the following:
The readiness light (same light
for front and side airbag system)
will either flash or stay lit.
The readiness light will not
illuminate immediately after ignition is turned on.
A series of five beeps will be heard. The tone pattern will repeat
periodically until the problem and/or light are repaired.
If any of these things happen, even intermittently, have the supplemental
restraint system serviced at an authorized dealer immediately. Unless
serviced, the system may not function properly in the event of a
collision.
Seat-mounted side airbag system (if equipped)
Do not place objects or mount equipment on or near the airbag
cover on the side of the seatbacks of the front seats or in front
seat areas that may come into contact with a deploying airbag. Failure
to follow these instructions may increase the risk of personal injury in
the event of a collision.
Do not use accessory seat covers. The use of accessory seat
covers may prevent the deployment of the side airbags and
increase the risk of injury in an accident.
Do not lean your head on the door. The side airbag could injure
you as it deploys from the side of the seatback.
Do not attempt to service, repair, or modify the airbag SRS, its
fuses or the seat cover on a seat containing an airbag. See your
authorized dealer.
All occupants of the vehicle should always wear their safety belts
even when an airbag SRS is provided.
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Seating and Safety Restraints
92
loose or worn steering components
improper steering alignment
A high crown in the road or high crosswinds may also make the steering
seem to wander/pull.
AUTOMATIC TRANSMISSION OPERATION (IF EQUIPPED)
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the ON position unless the brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed:
1. Apply the parking brake, turn ignition key to LOCK, then remove the
key.
When the key is in the ignition and in the OFF position, the
automatic transmission shift lever can be moved from the P
(Park) position without the brake pedal depressed. To avoid unwanted
vehicle movement, always set the parking brake.
2. Using a screwdriver (or similar
tool), remove the protective cover
to the interlock access hole on the
console. Insert the key to release
the interlock.
3. Apply the parking brake, then shift to N (Neutral).
4. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
Emergencies
chapter.
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Driving
136
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
15
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
145
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the CD stowage box to access the fuses.
To remove a fuse, use the fuse puller tool provided on the power
distribution box cover located in the engine compartment.
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
R17
Starter relay
R18
Not used
R19
Not used
R20
Not used
R21
Daytime running lamps
R22
Not used
R23
Not used
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
146
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
R24
Not used
R25
Rear defrost/Heated mirror relay
30
10A
Parking lamps
31
20A
Radio
32
15A
Turn signal (GEM)
33
20A
Sunroof
34
20A
Horn
35
7.5A
A/C switch, Instrument cluster
36
7.5A
Interior lamps, Power mirrors
37
Not used
38
Not used
39
2A
PCM relay coil
40
25A
Rear defroster
41
Not used
42
10A
Stop lamps, Shift interlock
43
15A
Rear wiper, Sunroof (ignition)
44
15A
Daytime Running Lamps (DRL)
45
7.5A
Recirculated air, Air conditioning
46
Not used
47
20A
Cigar lighter/Power point
48
10A
Data link connector
49
7.5A
Heated mirror, Heated backlite
indicator
50
10A
Back- up lamps (automatic
transaxle only)
51
7.5A
Front passenger sensing system
52
15A
Heated seats
53
10A
Back-up lamps (manual transaxle
only), Speed control
54
25A
Rear power windows
55
25A
Front power windows
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
147
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
56
20A
Front wipers
57
7.5A
Radio and cluster (accessory)
58
Not used
59
7.5A
Light switch (headlamps)
60
7.5A
Air bag module
61
7.5A
PATS modules, Instrument cluster
62
7.5A
Radio (Start)
63
20A
Power locks (GEM)
Fuse 63 is located on the back of the fuse panel. See your authorized
dealer for service of this fuse.
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
To reduce risk of electrical shock, always replace the cover to
the Power Distribution Box before reconnecting the battery or
refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
148
To remove a fuse, use the fuse puller tool provided on the power
distribution box cover.
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
1
40A
Main power supply (to passenger
compartment fuse panel)
2
Not used
3
Not used
4
30A
Air pump motor (PZEV engine
only)
5
30A
Anti-lock Brake System (ABS)
(pumps)
6
50A
Engine cooling fan (Primary fuse)
7
40A
Main power supply (to passenger
compartment fuse panel)
8
30A
Ignition switch, Starter solenoid
9
20A
Engine management
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
149
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
10
1A
Battery voltage sense
11
30A
Subwoofer
12
15A
Fuel pump motor
13
20A
Anti-lock Brake System (ABS)
(valves)
14
Not used
15
Not used
16
10A
Low beam (left-hand side)
17
10A
Low beam (right-hand side)
18
15A
Heated Exhaust Gas Oxygen
(HEGO) sensors
19
40A
Heater blower motor
20
10A
Engine module (KAP)
21
10A
A/C
22
20A
Low beams
23
15A
High beams, Fog lamps
24
Not used
25
Not used
26
Not used
27
Not used
28
Not used
29
10A
ABS module, Speed control
R1
Ignition relay
R2
High beam relay, Fog lamps relay
R3
Cooling fan (high-speed)
R4
Cooling fan (low-speed)
R5
A/C relay
R6
Low beams relay
R7
Fuel pump relay
R8
Engine management relay
R9
Cooling fan relay
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
150
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
R10
Cooling fan relay
R11
Not used
R12
Not used
R13
Not used
R14
Not used
R15
Air pump motor relay
R16
Not used
D1
Not used
D2
Not used
D3
A/C clutch diode
D4
Not used
CHANGING A FLAT TIRE
If you get a flat tire while driving:
do not brake heavily.
gradually decrease the vehicle’s speed.
hold the steering wheel firmly.
slowly move to a safe place on the side of the road.
The use of tire sealants may damage your tires.
Dissimilar spare tire/wheel information
Failure to follow these guidelines could result in an increased
risk of loss of vehicle control, injury or death.
If you have a dissimilar spare tire/wheel, then it is intended for
temporary use only. This means that if you need to use it, you should
replace it as soon as possible with a road tire/wheel that is the same size
and type as the road tires and wheels that were originally provided by
Ford. If the dissimilar spare tire or wheel is damaged, it should be
replaced rather than repaired.
A dissimilar spare tire/wheel is defined as a spare tire and/or wheel that
is different in brand, size or appearance from the road tires and wheels
and can be one of three types:
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
151
Place the VELCRO
²
hook onto
the side of the aftermarket
transmitter opposite of the
button.
Place the transmitter into storage
compartment, button down.
Place the provided height
adaptors onto the back of the
door as needed.
Close the door.
Press the depression in the door
to activate the transmitter.
AUXILIARY POWER POINT (12VDC)
Power outlet is designed for accessory plugs only. Do not insert
any other object in the power outlet as this will damage the
outlet and blow the fuse. Do not hang any type of accessory or
accessory bracket from the plug. Improper use of the power
outlet can cause damage not covered by your warranty.
The auxiliary power point is located
on the instrument panel.
Do not use the power point for
operating the cigarette lighter
element (if equipped).
To prevent the fuse from being
blown, do not use the power point
over the vehicle capacity of 12
VDC/180W.
To prevent the battery from being discharged, do not use the power
point longer than necessary when the engine is not running.
Always keep the power point caps closed when not being used.
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Driver Controls
41
All occupants of the vehicle, including the driver, should always
properly wear their safety belts, even when an air bag
supplemental restraint system (SRS) is provided.
Always transport children 12 years old and under in the back
seat and always properly use appropriate child restraints.
The National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 10 inches (25 cm)
between an occupant’s chest and the driver airbag module.
Never place your arm over the airbag module as a deploying
airbag can result in serious arm fractures or other injuries.
To properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly one or two degrees from the upright position.
Do not put anything on or over the airbag module. Placing
objects on or over the airbag inflation area may cause those
objects to be propelled by the airbag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the airbag
supplemental restraint systems or its fuses. See your authorized
dealer.
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Seating and Safety Restraints
82
A difficulty with the system is indicated by one or more of the following:
The readiness light (same light
for front and side airbag system)
will either flash or stay lit.
The readiness light will not
illuminate immediately after ignition is turned on.
A series of five beeps will be heard. The tone pattern will repeat
periodically until the problem and/or light are repaired.
If any of these things happen, even intermittently, have the supplemental
restraint system serviced at an authorized dealer immediately. Unless
serviced, the system may not function properly in the event of a
collision.
Seat-mounted side airbag system (if equipped)
Do not place objects or mount equipment on or near the airbag
cover on the side of the seatbacks of the front seats or in front
seat areas that may come into contact with a deploying airbag. Failure
to follow these instructions may increase the risk of personal injury in
the event of a collision.
Do not use accessory seat covers. The use of accessory seat
covers may prevent the deployment of the side airbags and
increase the risk of injury in an accident.
Do not lean your head on the door. The side airbag could injure
you as it deploys from the side of the seatback.
Do not attempt to service, repair, or modify the airbag SRS, its
fuses or the seat cover on a seat containing an airbag. See your
authorized dealer.
All occupants of the vehicle should always wear their safety belts
even when an airbag SRS is provided.
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Seating and Safety Restraints
90
loose or worn steering components
improper steering alignment
A high crown in the road or high crosswinds may also make the steering
seem to wander/pull.
AUTOMATIC TRANSMISSION OPERATION (IF EQUIPPED)
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the ON position unless the brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed:
1. Apply the parking brake, turn ignition key to LOCK, then remove the
key.
When the key is in the ignition and in the OFF position, the
automatic transmission shift lever can be moved from the P
(Park) position without the brake pedal depressed. To avoid unwanted
vehicle movement, always set the parking brake.
2. Using a screwdriver (or similar
tool), remove the protective cover
to the interlock access hole on the
console. Insert the key to release
the interlock.
3. Apply the parking brake, then shift to N (Neutral).
4. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
Emergencies
chapter.
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Driving
136
to turn them off. Use it when your vehicle is disabled and is creating a
safety hazard for other motorists.
Note:
With extended use, the flasher may run down your battery.
FUEL PUMP SHUT-OFF SWITCH
This device stops the electric fuel pump from sending fuel to the engine
when your vehicle has had a substantial jolt.
After an accident, if the engine cranks but does not start, this switch
may have been activated.
This switch is located in the front
passenger’s footwell, behind the kick
panel access cover.
To reset the switch:
1. Turn the ignition OFF.
2. Check the fuel system for leaks.
3. If no leaks are apparent, reset the
switch by pushing in on the reset
button.
4. Turn the ignition ON.
5. Wait a few seconds and return the key to OFF.
6. Make another check for leaks.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
15
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
144
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
Yellow
70A
Tan
Brown
80A
Natural
Black
Black
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the CD stowage box to access the fuses.
To remove a fuse, use the fuse puller tool provided on the power
distribution box cover located in the engine compartment.
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
145
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
R17
Starter relay
R18
Not used
R19
Not used
R20
Not used
R21
Daytime running lamps
R22
Not used
R23
Not used
R24
Not used
R25
Rear defrost/Heated mirror relay
30
10A
Parking lamps
31
20A
Radio
32
15A
Turn signal (GEM)
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
146
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
33
20A
Sunroof
34
20A
Horn
35
7.5A
A/C switch, Instrument cluster
36
7.5A
Interior lamps, Power mirrors
37
Not used
38
Not used
39
2A
PCM relay coil
40
25A
Rear defroster
41
Not used
42
10A
Stop lamps, Shift interlock
43
15A
Rear wiper, Sunroof (ignition)
44
15A
Daytime Running Lamps (DRL)
45
7.5A
Recirculated air, Air conditioning
46
Not used
47
20A
Cigar lighter/Power point
48
10A
Data link connector
49
7.5A
Heated mirror, Heated backlite
indicator
50
10A
Back- up lamps (automatic
transaxle only)
51
7.5A
Front passenger sensing system
52
15A
Heated seats
53
10A
Back-up lamps (manual transaxle
only), Speed control
54
25A
Rear power windows
55
25A
Front power windows
56
20A
Front wipers
57
7.5A
Radio and cluster (accessory)
58
Not used
59
7.5A
Light switch (headlamps)
60
7.5A
Air bag module
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
147
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
61
7.5A
PATS modules, Instrument cluster
62
7.5A
Radio (Start)
63
20A
Power locks (GEM)
Note:
Fuse 63 is located on the back of the fuse panel. See your
authorized dealer for service of this fuse.
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
To reduce risk of electrical shock, always replace the cover to
the Power Distribution Box before reconnecting the battery or
refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
148
To remove a fuse, use the fuse puller tool provided on the power
distribution box cover.
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
1
40A
Main power supply (to passenger
compartment fuse panel)
2
Not used
3
Not used
4
30A
Air pump motor (PZEV engine
only)
5
30A
Anti-lock Brake System (ABS)
(pumps)
6
50A
Engine cooling fan (Primary fuse)
7
40A
Main power supply (to passenger
compartment fuse panel)
8
30A
Ignition switch, Starter solenoid
9
20A
Engine management
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
149
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
10
1A
Battery voltage sense
11
30A
Subwoofer
12
15A
Fuel pump motor
13
20A
Anti-lock Brake System (ABS)
(valves)
14
Not used
15
Not used
16
10A
Low beam (left-hand side)
17
10A
Low beam (right-hand side)
18
15A
Heated Exhaust Gas Oxygen
(HEGO) sensors
19
40A
Heater blower motor
20
10A
Engine module (KAP)
21
10A
A/C
22
20A
Low beams
23
15A
High beams, Fog lamps
24
Not used
25
Not used
26
Not used
27
Not used
28
Not used
29
10A
ABS module, Speed control
R1
Ignition relay
R2
High beam relay, Fog lamps relay
R3
Cooling fan (high-speed)
R4
Cooling fan (low-speed)
R5
A/C relay
R6
Low beams relay
R7
Fuel pump relay
R8
Engine management relay
R9
Cooling fan relay
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
150
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
R10
Cooling fan relay
R11
Not used
R12
Not used
R13
Not used
R14
Not used
R15
Air pump motor relay
R16
Not used
D1
Not used
D2
Not used
D3
A/C clutch diode
D4
Not used
CHANGING A FLAT TIRE
If you get a flat tire while driving:
do not brake heavily.
gradually decrease the vehicle’s speed.
hold the steering wheel firmly.
slowly move to a safe place on the side of the road.
The use of tire sealants may damage your tires.
Dissimilar spare tire/wheel information
Failure to follow these guidelines could result in an increased
risk of loss of vehicle control, injury or death.
If you have a dissimilar spare tire/wheel, then it is intended for
temporary use only. This means that if you need to use it, you should
replace it as soon as possible with a road tire/wheel that is the same size
and type as the road tires and wheels that were originally provided by
Ford. If the dissimilar spare tire or wheel is damaged, it should be
replaced rather than repaired.
2007 Focus
(foc)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
151