Ford Focus - 2005 Fuse Box Diagram

Ford Focus - 2005 Fuse Box Diagram

Place the Velcro hook onto the
side of the aftermarket
transmitter opposite of the
button.
Place the transmitter into storage
compartment, button down.
Place the provided height
adaptors onto the back of the
door as needed.
Close the door.
Press the depression in the door
to activate the transmitter.
AUXILIARY POWER POINT (IF EQUIPPED)
Power outlets are designed for
accessory plugs only. Do not
hang any type of accessory or
accessory bracket from the plug.
Improper use of the power
outlet can cause damage not
covered by your warranty.
The auxiliary power points are
located on the instrument panel and in the center console utility
compartment.
Do not plug optional electrical accessories into the cigarette lighter. Use
the power point.
Do not use the power point for operating the cigarette lighter element.
The Maximum power each power point can supply depends on the fuse
rating. For example: a 20A fuse should supply a maximum of 240 Watts,
a 15A fuse should supply a maximum of 180 Watts and a 10A fuse should
supply a maximum of 120 Watts. Exceeding these limits will result in a
blown fuse.
Always keep the power point caps closed when not being used.
2005 Focus
(foc)
Owners Guide (post-2002-fmt)
USA English
(fus)
Driver Controls
43
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the air bag
supplemental restraint systems or its fuses. See your Ford or
Lincoln Mercury dealer.
Children and air bags
Children must always be properly
restrained. Accident statistics
suggest that children are safer when
properly restrained in the rear
seating positions than in the front
seating position. Failure to follow
these instructions may increase the
risk of injury in a collision.
Air bags can kill or injure a
child in a child seat.
NEVER
place a rear-facing child
seat in front of an active air bag. If
you must use a forward-facing
child seat in the front seat, move
the seat all the way back.
2005 Focus
(foc)
Owners Guide (post-2002-fmt)
USA English
(fus)
Seating and Safety Restraints
83
A series of five beeps will be heard. The tone pattern will repeat
periodically until the problem and/or light are repaired.
If any of these things happen, even intermittently, have the supplemental
restraint system serviced at your dealership or by a qualified technician
immediately. Unless serviced, the system may not function properly in
the event of a collision.
Side air bag system (if equipped)
Do not place objects or mount equipment on or near the air bag
cover on the side of the seatbacks of the front seats or in front
seat areas that may come into contact with a deploying air bag. Failure
to follow these instructions may increase the risk of personal injury in
the event of a collision.
Do not use accessory seat covers. The use of accessory seat
covers may prevent the deployment of the side air bags and
increase the risk of injury in an accident.
Do not lean your head on the door. The side air bag could injure
you as it deploys from the side of the seatback.
Do not attempt to service, repair, or modify the air bag SRS, its
fuses or the seat cover on a seat containing an air bag. See your
Ford or Lincoln Mercury dealer.
All occupants of the vehicle should always wear their safety belts
even when an air bag SRS is provided.
2005 Focus
(foc)
Owners Guide (post-2002-fmt)
USA English
(fus)
Seating and Safety Restraints
89
an improperly inflated tire
uneven tire wear
loose or worn suspension components
loose or worn steering components
improper steering alignment
A high crown in the road or high crosswinds may also make the steering
seem to wander/pull.
AUTOMATIC TRANSMISSION OPERATION (IF EQUIPPED)
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the ON position unless the brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed:
1. Apply the parking brake, turn ignition key to LOCK, then remove the
key.
When the key is in the ignition and in the OFF position, the
automatic transmission shift lever can be moved from the P
(Park) position without the brake pedal depressed. To avoid unwanted
vehicle movement, always set the parking brake.
2. Using a screwdriver (or similar
tool), remove the protective cover
to the interlock access hole on the
console. Insert the key to release
the interlock.
3. Apply the parking brake, then shift to N (Neutral).
4. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle
s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
Emergencies
chapter.
2005 Focus
(foc)
Owners Guide (post-2002-fmt)
USA English
(fus)
Driving
110
This switch is located in the front
passenger
s footwell, behind the kick
panel access cover.
To reset the switch:
1. Turn the ignition OFF.
2. Check the fuel system for leaks.
3. If no leaks are apparent, reset the
switch by pushing in on the reset
button.
4. Turn the ignition ON.
5. Wait a few seconds and return the key to OFF.
6. Make another check for leaks.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
15
2005 Focus
(foc)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
127
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the CD stowage box to access the fuses.
To remove a fuse, use the fuse puller tool provided on the power
distribution box cover located in the engine compartment.
2005 Focus
(foc)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
128
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
R17
Starter relay
R18
Rear wiper intermittent relay
R19
Front wiper intermittent relay
R20
Not used
R21
Not used
R22
Decklid/Liftgate release relay
R23
Horn relay
R24
Battery saver relay
R25
Rear defrost/Heated mirror relay
30
10A
Parking lamps
31
20A
Radio
32
15A
Turn signal (GEM)
2005 Focus
(foc)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
129
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
33
20A
Horn
34
20A
Stand-alone decklid relay (sedan
only), Power sunroof
35
7.5A
Interior lamps, Power mirrors
36
7.5A
A/C switch, Instrument cluster
37
25A
Decklid/Liftgate release
38
Not used
39
Not used
40
10A
Back-up lamps (automatic
transaxle only)
41
7.5A
Radio and cluster (accessory)
42
15A
Stop lamps
43
15A
Rear wiper, Sunroof (ignition)
44
20A
Fog lamps
45
7.5A
Recirculated air, Air conditioning
46
7.5A
Anti-lock Brake System (ABS)
47
20A
Cigar lighter/Power point
48
10A
Data link connector
49
25A
Rear defroster
50
7.5A
Heated mirror, Heated backlite
indicator
51
7.5A
Front passenger sensing system
52
15A
Heated seats
53
10A
Back-up lamps (manual transaxle
only), Speed control
54
25A
Rear power windows
55
25A
Front power windows
56
20A
Front wipers
57
7.5A
Position and side lights
(right-hand side)
58
7.5A
Position and side lights (left-hand
side), License plate lamps
2005 Focus
(foc)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
130
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
59
7.5A
Light switch (headlamps)
60
7.5A
Air bag module
61
7.5A
PATS modules, Instrument cluster
62
7.5A
Radio (Start)
63
20A
Power locks (GEM)
Fuse 63 is located on the back of the fuse panel. See your dealer or a
certified technician for service of this fuse.
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle
s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
Always replace the cover to the power distribution box before
reconnecting the battery or refilling fluid reservoirs
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
2005 Focus
(foc)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
131
To remove a fuse, use the fuse puller tool provided on the power
distribution box cover.
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
1
40A
Main power supply (to passenger
compartment fuse panel)
2
30A
Engine cooling fan (Secondary
fuse)
3
40A
Heater blower motor
4
30A
Air pump motor (PZEV engine
only)
5
Not used
6
50A
Engine cooling fan (Primary fuse)
7
40A
Main power supply (to passenger
compartment fuse panel)
8
30A
Ignition switch, Starter solenoid
9
20A
Engine management
10
1A
Battery voltage sense
2005 Focus
(foc)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
132
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
11
30A
Anti-lock Brake System (ABS)
(pumps)
12
15A
Fuel pump
13
Not used
14
Not used
15
10A
A/C clutch solenoid
16
10A
Low beam (left-hand side)
17
10A
Low beam (right-hand side)
18
15A
Heated Exhaust Gas Oxygen
(HEGO) sensors
19
Not used
20
10A
Engine module (KAP)
21
20A
ABS (valves)
22
20A
Daytime Running Lights (DRL)
23
Not used
24
30A
Subwoofer
25
Not used
26
10A
Left high beam
27
10A
Right high beam
28
Not used
29
Not used
R1
Ignition relay
R2
Air pump motor relay (PZEV
engine only)
R3
Cooling fan (high-speed)
R4
Cooling fan (medium-speed)
R5
High beams relay
R6
Low beams relay
R7
Fuel pump relay
R8
Engine management relay
R9
Cooling fan relay
2005 Focus
(foc)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
133
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
R10
Cooling fan relay
R11
A/C clutch solenoid relay
R12
DRL relay
R13
Fog lamps relay
R14
Not used
R15
Not used
R16
Not used
D1
PCM diode
D2
Cooling fan diode
D3
A/C clutch diode
D4
Cooling fan diode
CHANGING A FLAT TIRE
If you get a flat tire while driving:
do not brake heavily.
gradually decrease the vehicle
s speed.
hold the steering wheel firmly.
slowly move to a safe place on the side of the road.
The use of tire sealants may damage your tires.
Temporary spare tire information
The temporary spare tire for your vehicle is labeled as such. It is smaller
than a regular tire and is designed for emergency use only. Replace the
temporary spare tire with a full-size tire as soon as possible.
If you use the temporary spare tire continuously or do not follow
these precautions, the tire could fail, causing you to lose control
of the vehicle, possibly injuring yourself or others.
When driving with the temporary spare tire
do not:
use more than one temporary spare tire at a time
exceed 50 mph (80 km/h)
2005 Focus
(foc)
Owners Guide (post-2002-fmt)
USA English
(fus)
Roadside Emergencies
134
Roadside emergencies
127
FUSES
Switch off the ignition and
all the electrical equipment
before changing a fuse.
Always replace a faulty fuse with a
new one of the same rating.
Auxiliary
fuse box
Central
fuse box
Any improper alterations to
the electrical or fuel system
can endanger the safety of the
vehicle as they could constitute a
fire hazard or cause engine
damage. Have any work involving
these systems or the replacement
of relays or high current carrying
fuses carried out by experts.
Auxiliary fuse box
This is located on the left-hand side
of the engine compartment.
To check or replace a fuse, remove
the cover of the fuse box by
releasing the catch and lifting up.
Changing a fuse
A fuse puller is located in the lid of
the auxiliary fuse box.
Roadside emergencies
128
Fuses in the auxiliary fuse box
(in the engine compartment)
Fuse
Ampere
rating
Colour
Circuits protected
1
1
40
orange
Main power supply to electrical system
2
Not used
3
40
orange
Glow plug heater 2
4
1
50
red
Heated front screen
5
1
60
blue
Diesel glow plug
6
1
30
green
Engine cooling fan (air conditioning)
7
1
40
orange
Main power supply to electrical system
8
1
30
green
Ignition
9
1
20
yellow
Engine management
10
1
black
Battery voltage sensor
11
30
green
ABS pump
12
15
blue
Fuel pump, diesel injection pump
13
30
green
Headlight washer system
14
10
red
Daytime running lights (parking lights)
15
10
red
A/C clutch solenoid
16
15
blue
Dipped beam left-hand side
17
15
blue
Dipped beam right-hand side
1
The replacement of these fuses requires specialist knowledge.
Roadside emergencies
129
Fuses in the auxiliary fuse box
(in the engine compartment)
Fuse
Ampere
rating
Colour
Circuits protected
18
10
red
H02S sensor transmitter
(catalytic converter)
19
Not used
20
10
red
Engine management
21
20
yellow
ABS valves
22
20
yellow
Daytime running lights (Xenon headlights
only)
23
20
yellow
Auxiliary heater (diesel engine), power sup-
ply for battery backup sounder
(ST170 only)
24
30
green
Glow plug heater 1,
subwoofer
(ST170 only)
25
15
blue
Daytime running lights (conventional
headlights only)
26
10
red
Main beam left-hand side
27
10
red
Main beam right-hand side
28
10
red
Heated front screen, diesel fuel fired heater,
diesel engine
29
30
green
Engine cooling fan (air conditioning)
64
30
green
Heater blower motor
65
30
green
Engine cooling fan
1
The replacement of these fuses requires specialist knowledge.
Roadside emergencies
130
Central fuse box
This is located on the left-hand side
underneath the instrument panel.
Open the glove compartment. Push
in both sides of the glove
compartment and swivel it down
completely.
Roadside emergencies
131
Central fuse box
Fuse
Ampere
rating
Colour
Circuits protected
30
10
red
Light switch
31
15
blue
Radio
32
15
blue
Direction indicator (GEM)
33
20
yellow
Horn, power seat
34
20
yellow
Power sunroof
35
7.5
brown
Interior lights, power mirrors
36
7.5
brown
Electronic modules, instrument
cluster
37
25
white
Power windows, central global
closing (left-hand side)
38
25
white
Power windows, central global
closing (right-hand side)
39
Not used
40
10
red
Reversing light
41
7.5
brown
Radio (accessory)
42
15
blue
Brake lights
43
15
blue
Power windows, rear screen wiper
44
20
yellow
Front and rear fog lights
45
7.5
brown
Air conditioning, recirculated air
46
7.5
brown
ABS module
47
15
blue
Cigar lighter, centre power point
48
10
red
Data link connector
49
25
white
Heated rear screen
50
7.5
brown
Heated mirrors
Roadside emergencies
132
Central fuse box
Fuse
Ampere
rating
Colour
Circuits protected
51
Not used
52
15
blue
Heated front seats
53
10
red
Reversing light, heated washer jets
54
Not used
55
25
white
Front power windows
56
20
yellow
Front screen wiper
57
7.5
brown
Side lights right-hand side
58
7.5
brown
Side lights left-hand side
59
10
red
Light switch
60
7.5
brown
Air bag module
61
7.5
brown
Electronic modules, instrument
cluster
62
7.5
brown
Number plate lights
63
20
yellow
Central locking (on the rear side of
the fuse box)
Maintenance and care
147
Engine compartment
Position
Description
See page
Power steering fluid reservoir
154
Engine oil filler cap
1
152
Brake/clutch fluid reservoir
152
Auxiliary fuse box
127
Air cleaner
No maintenance
necessary
Screen washer fluid reservoir
154
Battery
139
Vehicle identification plate
158
Engine oil dipstick
1
151
Engine coolant reservoir
153
1
For easy identification, filler caps and the engine oil dipstick are marked in colour.
1.4 l/1.6 l Zetec±SE 16V
J