Ford Focus - 2002 Fuse Box Diagram

Ford Focus - 2002 Fuse Box Diagram

Seating and Safety Restraints
147
NHTSA
recommends
a
minimum
distance
of
at
least
25±cm (ten
[10]
inches)
between
an
occupant's
chest and
the
air
bag
module.
Never
place
your arm over
the air bag
module
as
a
deploying
air bag
can result in
serious arm fractures
or
other
injuries.
Steps
you
can take
to properly
position
yourself
away from the
air
bag:
Move your
seat
to the
rear
as
far
as
you can while still reaching
the
pedals
comfortably.
Recline
your
seat
slightly
(one
or
two
degrees)
from
the
upright
position.
Do not put anything
on
or
over
the air
bag
module.
Placing
objects on
or
over
the
air
bag
inflation
area may
cause
those
objects
to be
propelled
by
the
air
bag
into your
face and
torso
causing
serious injury.
Do not attempt
to service,
repair, or
modify the
Air
Bag
Supplemental
Restraint
System
or
its fuses.
See
your
Ford
or
LincolnĆMercury
dealer.
Seating and Safety Restraints
152
Do
not
attempt
to service,
repair, or
modify the
air
bag
Supplemental
Restraint
System or
its
fuses.
See
your
Ford
or
LincolnĆMercury
dealer.
All
occupants
of the
vehicle
including
the driver should
always
wear
their
safety
belts
even
when an air
bag
SRS is
provided.
How does the side air bag
system work?
The
side
air
bag
system
consists
of
the
following:
An
inflatable
nylon
bag (air
bag)
with
a gas generator
concealed
behind
the outboard
bolster
of
the
driver
and front
passenger
seatbacks.
The
same
warning
light,
electronic
control and diagnostic
unit
as
used
for
the front air
bags.
Two
crash sensors
located
under
the
outboard
side
of the
front seats,
attached
to the floor.
Side
air
bags,
in combination
with
seat
belts, can help reduce
the
risk
of
severe
injuries in
the
event of
a
significant
side
impact collision.
Driving
185
If
it is
necessary
to use
the
above
procedure
to move
the
gearshift,
it
is
possible
that a
fuse
has blown or
the
vehicle's brakelamps
are
not
operating
properly.
Refer
to
Fuses
and
relays
in the
Roadside
Emergencies
chapter.
Do
not
drive
your
vehicle
until you
verify that the
brakelamps
are
working.
If
your
vehicle gets stuck in
mud or
snow
it
may
be
rocked
out by
shifting
between
forward
and
reverse
gears, stopping
between
shifts,
in
a
steady pattern.
Press
lightly
on
the accelerator
in
each
gear.
Do
not
rock the
vehicle
for
more
than a
few minutes
or
excessively
spin the wheels.
The transaxle
and
tires
may
be
damaged
or
the
engine
may
overheat.
Always
set
the parking
brake
fully
and make sure
the
gearshift
is latched
in
P
(Park).
Turn
off
the ignition
whenever
you
leave your
vehicle.
Roadside Emergencies
209
FUSES AND RELAYS
Fuses
If
electrical
components
in
the
vehicle
are
not working,
a
fuse may
have
blown.
Blown
fuses are
identified
by
a
broken
wire
within
the
fuse.
Check the appropriate
fuses
before
replacing
any
electrical
components.
Always replace
a
fuse with
one
that has the
specified
amperage
rating. Using
a
fuse
with
a higher amperage
rating
can
cause
severe
wire
damage
and
could
start a
fire.
Roadside Emergencies
210
Standard fuse amperage rating and color
Color
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Fuse
link
cartridge
2A
3A
4A
5A
7.5A
10A
15A
20A
25A
30A
40A
50A
60A
70A
80A
Grey
Violet
Pink
Tan
Brown
Red
Blue
Yellow
Natural
Green
-
-
-
-
-
Grey
Violet
Pink
Tan
Brown
Red
Blue
Yellow
Natural
Green
Orange
-
-
-
-
-
-
-
-
-
-
-
Yellow
-
Green
Orange
Red
Blue
Tan
Natural
-
-
-
-
-
-
-
Blue
-
Pink
Orange
Red
Yellow
Brown
Black
Passenger compartment fuse
panel
The
fuse
panel is located
below and
to
the
left
of
the steering
wheel
by
the
brake
pedal. Remove
the
panel
cover
to view the fuses.
Access
the fuses
from below the
panel
cover.
Roadside Emergencies
211
The
fuses
and relays are
coded
as
follows.
Roadside Emergencies
212
Passenger compartment fuse panel
Fuse
Fuse
amp.
rating
Description
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
10
15
15
20
20
7.5
7.5
-
-
15
10
7.5
15
15
20
7.5
7.5
20
10
25
7.5
Light switch
Radio
Turn
signal, hazard flasher
Horn, power
seat
Power
sunroof
Interior
lamps, power
mirrors
Electronic
modules,
instrument
cluster
Not used
Not used
Rear
power
point
BackĆup
lamps (automatic
transmission)
Radio (accessory)
Stop
lamps
Rear
wiper
Fog
lamps
Recirculated
air, air
conditioning
ABS
Cigar lighter, front power
point
Data
link connector
Rear
defrost
Heated mirrors
Roadside Emergencies
213
Passenger compartment fuse panel
Fuse
Fuse
amp.
rating
Description
51
52
53
54
55
56
57
58
59
60
61
62
63
-
15
10
25
25
20
7.5
7.5
7.5
7.5
7.5
7.5
20
Not used
Heated front seats
BackĆup
lamps (manual
transmission)
Rear
power
windows
Front power
windows
Front wipers
Side lights (right)
Side lights (left)
Light switch
Air
bag module
Electronic
modules,
instrument
cluster
License
plate
lamp
Power
locks (GEM)
(on
back side
of
fuse
panel)
Relays in the passenger compartment fuse panel
Relay
Description
17
18
19
20
21
22
23
24
25
Starter
Rear
intermittent
wiper
Front intermittent
wiper
Not
used
Not
used
Not
used
Horn
Battery saver
Rear
defrost,
heated
mirrors
Roadside Emergencies
214
Power distribution box
The
power
distribution
box
is
located
in
the engine compartment.
The
power
distribution
box
contains
highĆcurrent
fuses that
protect
your
vehicle's main
electrical
systems
from
overloads.
Always disconnect
the
battery before
servicing
high
current fuses.
Always replace the
cover
to
the Power
Distribution
Box
before
reconnecting
the
battery
or
refilling
fluid
reservoirs.
The
highĆcurrent
fuses are
coded
as
follows.
Roadside Emergencies
215
Power distribution box
Fuse
Fuse
amp.
rating
Description
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
64
65
40
30
-
-
-
50
40
30
20
10
30
15
-
-
10
10
10
10
10
10
20
20
-
30
-
10
10
-
-
40
-
Main
power
supply to electrical
system
Engine cooling
fan (A/C) 2nd
fuse
Not used
Not used
Not used
Engine cooling
fan (A/C) 1st
fuse
Main
power
supply to electrical
system
Ignition
switch, starter
Engine management
Battery
voltage
sensor, diagnostic
plug
ABS
Fuel
pump
Not used
Not used
AC
clutch
solenoid
Low
beam (left side)
Low
beam (right side)
Heated
oxygen
sensors
Low
beam (DRL)
Engine management
ABS
Low
beam (DRL)
Not used
Powered
subwoofer
Not used
High beam (left side)
High beam (right side)
Not used
Not used
Heater
blower
motor
Not used
Maintenance and Specifications
259
IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT
2.0 L SPI Engine
Engine
oil
filler
cap
Brake/clutch
fluid
reservoir
Fuse
box
Air
filter
assembly
Power
steering±fluid
reservoir
Battery
Windshield
washer
fluid
reservoir
Engine
coolant
reservoir
(marked
red
and black)
Transaxle
fluid
dipstick
Engine oil
dipstick
For
ease
of identification,
most filler caps and the
engine
oil
dipstick
are
marked
yellow and black.
Maintenance and Specifications
260
IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT
2.0 L Zetec-E Engine
Brake/clutch
fluid
reservoir
Engine
oil
filler
cap
Power
steering±fluid
reservoir
Air
filter
assembly
Fuse
box
Battery
Windshield
washer
fluid
reservoir
Engine
coolant
reservoir
(marked
red
and
black)
Engine oil
dipstick
Transaxle
fluid
dipstick
For
ease
of identification,
most filler caps and
the
engine oil
dipstick
are
marked
yellow and black.
Roadside emergencies
127
FUSES
Switch off the ignition and
all the electrical equipment
before changing a fuse.
Always replace a faulty fuse with a
new one of the same rating.
Auxiliary
fuse box
Central
fuse box
Any improper alterations to
the electrical or fuel system
can endanger the safety of the
vehicle as they could constitute a
fire hazard or cause engine
damage. Have any work involving
these systems or the replacement
of relays or high current carrying
fuses carried out by experts.
Auxiliary fuse box
This is located on the left-hand side
of the engine compartment.
To check or replace a fuse, remove
the cover of the fuse box by
releasing the catch and lifting up.
Changing a fuse
A fuse puller is located in the lid of
the auxiliary fuse box.
Roadside emergencies
128
Fuses in the auxiliary fuse box
(in the engine compartment)
Fuse
Ampere
rating
Colour
Circuits protected
1
1
40
orange
Main power supply to electrical system
2
Not used
3
40
orange
Glow plug heater 2
4
1
50
red
Heated front screen
5
1
60
blue
Diesel glow plug
6
1
30
green
Engine cooling fan (air conditioning)
7
1
40
orange
Main power supply to electrical system
8
1
30
green
Ignition
9
1
20
yellow
Engine management
10
1
black
Battery voltage sensor
11
30
green
ABS pump
12
15
blue
Fuel pump, diesel injection pump
13
30
green
Headlight washer system
14
10
red
Daytime running lights (parking lights)
15
10
red
A/C clutch solenoid
16
15
blue
Dipped beam left-hand side
17
15
blue
Dipped beam right-hand side
1
The replacement of these fuses requires specialist knowledge.
Roadside emergencies
129
Fuses in the auxiliary fuse box
(in the engine compartment)
Fuse
Ampere
rating
Colour
Circuits protected
18
10
red
H02S sensor transmitter
(catalytic converter)
19
Not used
20
10
red
Engine management
21
20
yellow
ABS valves
22
20
yellow
Daytime running lights (Xenon headlights
only)
23
20
yellow
Auxiliary heater (diesel engine), power sup-
ply for battery backup sounder
(ST170 only)
24
30
green
Glow plug heater 1,
subwoofer
(ST170 only)
25
15
blue
Daytime running lights (conventional
headlights only)
26
10
red
Main beam left-hand side
27
10
red
Main beam right-hand side
28
10
red
Heated front screen, diesel fuel fired heater,
diesel engine
29
30
green
Engine cooling fan (air conditioning)
64
30
green
Heater blower motor
65
30
green
Engine cooling fan
1
The replacement of these fuses requires specialist knowledge.
Roadside emergencies
130
Central fuse box
This is located on the left-hand side
underneath the instrument panel.
Open the glove compartment. Push
in both sides of the glove
compartment and swivel it down
completely.
Roadside emergencies
131
Central fuse box
Fuse
Ampere
rating
Colour
Circuits protected
30
10
red
Light switch
31
15
blue
Radio
32
15
blue
Direction indicator (GEM)
33
20
yellow
Horn, power seat
34
20
yellow
Power sunroof
35
7.5
brown
Interior lights, power mirrors
36
7.5
brown
Electronic modules, instrument
cluster
37
25
white
Power windows, central global
closing (left-hand side)
38
25
white
Power windows, central global
closing (right-hand side)
39
Not used
40
10
red
Reversing light
41
7.5
brown
Radio (accessory)
42
15
blue
Brake lights
43
15
blue
Power windows, rear screen wiper
44
20
yellow
Front and rear fog lights
45
7.5
brown
Air conditioning, recirculated air
46
7.5
brown
ABS module
47
15
blue
Cigar lighter, centre power point
48
10
red
Data link connector
49
25
white
Heated rear screen
50
7.5
brown
Heated mirrors
Roadside emergencies
132
Central fuse box
Fuse
Ampere
rating
Colour
Circuits protected
51
Not used
52
15
blue
Heated front seats
53
10
red
Reversing light, heated washer jets
54
Not used
55
25
white
Front power windows
56
20
yellow
Front screen wiper
57
7.5
brown
Side lights right-hand side
58
7.5
brown
Side lights left-hand side
59
10
red
Light switch
60
7.5
brown
Air bag module
61
7.5
brown
Electronic modules, instrument
cluster
62
7.5
brown
Number plate lights
63
20
yellow
Central locking (on the rear side of
the fuse box)
Maintenance and care
147
Engine compartment
Position
Description
See page
Power steering fluid reservoir
154
Engine oil filler cap
1
152
Brake/clutch fluid reservoir
152
Auxiliary fuse box
127
Air cleaner
No maintenance
necessary
Screen washer fluid reservoir
154
Battery
139
Vehicle identification plate
158
Engine oil dipstick
1
151
Engine coolant reservoir
153
1
For easy identification, filler caps and the engine oil dipstick are marked in colour.
1.4 l/1.6 l Zetec±SE 16V
J