Ford Focus - 2000 Fuse Box Diagram

Ford Focus - 2000 Fuse Box Diagram

Instrumentation
6
Page 21
Luggage
compartment
control
Page 20, 54
Direction
indicators/
high beam
Page 8-18
Instrument
cluster
Page 55
Wiper lever
Page 56-59
Speed control
Page 54
Steering wheel
adjustment
Page 53
Ignition switch
Page 19-20
Headlamp control
Page 21
Panel dimmer
control
Page 159-167
Fuse panel
Seating
and safety restraints
98
NHTSA recommends a
minimum distance of at
least 25 cm (ten [10] inches)
between an occupant's chest and
the air bag module.
Steps you can take to properly
position yourself away from the air
bag:
Move your seat to the rear as far
as you can while still reaching the
pedals comfortably.
Recline your seat slightly (one or
two degrees) from the upright
position.
Do not put anything on or
over the air bag module.
Placing objects on or over the air
bag inflation area may cause
those objects to be propelled by
the air bag into your face and
torso causing serious injury.
Do not attempt to service,
repair, or modify the Air
Bag Supplemental Restraint
System or its fuses. See your
Ford or LincolnĆMercury dealer.
Seating
and safety restraints
104
Do not attempt to service,
repair, or modify the air bag
Supplemental Restraint System
or its fuses. See your Ford or
LincolnĆMercury dealer.
All occupants of the vehicle
including the driver should
always wear their safety belts
even when an air bag SRS is
provided.
How does the side air bag
system work?
The side air bag system consists of
the following:
An inflatable nylon bag (air bag)
with a gas generator concealed
behind the outboard bolster of the
driver and front passenger
seatbacks.
The same warning light,
electronic control and diagnostic
unit as used for the front air bags.
Two crash sensors located under
the outboard side of the front seats,
attached to the floor.
Side air bags, in combination with
seat belts, can help reduce the risk
of severe injuries in the event of a
significant side impact collision.
Driving
135
If it is necessary to use the above
procedure to move the gearshift, it
is possible that a fuse has blown or
the vehicle's brakelamps are not
operating properly. Refer to
Fuses
and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle
until you verify that the
brakelamps are working.
If your vehicle gets stuck in mud or
snow it may be rocked out by
shifting between forward and
reverse gears, stopping between
shifts, in a steady pattern. Press
lightly on the accelerator in each
gear.
Do not rock the vehicle for
more than a few minutes or
excessively spin the wheels.
The transaxle and tires may be
damaged or the engine may
overheat.
Always set the parking
brake fully and make sure
the gearshift is latched in P
(Park). Turn off the ignition
whenever you leave your vehicle.
Roadside
emergencies
159
FUSES
AND RELA
YS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Always replace a fuse with
one that has the specified
amperage rating. Using a fuse
with a higher amperage rating can
cause severe wire damage and
could start a fire.
Roadside
emergencies
160
Standard
fuse amperage rating and color
Color
Fuse rating
Mini fuses
Standard
fuses
Maxi fuses
Fuse link
cartridge
2A
3A
4A
5A
7.5A
10A
15A
20A
25A
30A
40A
50A
60A
70A
80A
Grey
Violet
Pink
Tan
Brown
Red
Blue
Yellow
Natural
Green
-
-
-
-
-
Grey
Violet
Pink
Tan
Brown
Red
Blue
Yellow
Natural
Green
-
-
-
-
-
-
-
-
-
-
-
-
Yellow
-
Green
Orange
Red
Blue
Tan
Natural
-
-
-
-
-
-
-
Blue
-
Pink
Orange
Red
Yellow
Brown
Black
Passenger
compartment fuse
panel
The fuse panel is located below and
to the left of the steering wheel by
the brake pedal. Remove the panel
cover to view the fuses.
Access the fuses from below the
panel cover.
Roadside
emergencies
161
The fuses and relays are coded as
follows.
Roadside
emergencies
162
Passenger
compartment fuse panel
Fuse
Fuse amp.
rating
Description
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
7.5
15
10
15
20
7.5
7.5
-
-
10
-
-
-
15
20
-
15
7.5
7.5
25
7.5
ABS
Radio
Light switch
Hazard flasher
Horn
Interior lamps, power mirrors
Central timer, electronic modules
Not used
Not used
BackĆup lamps
Not used
Not used
Not used
Rear wiper
Fog lamps
Not used
Cigar lighter
Side lights (left)
Side lights (right)
Rear defrost
Radio, central timer
Roadside
emergencies
163
Passenger
compartment fuse panel
Fuse
Fuse amp.
rating
Description
51
52
53
54
55
56
57
58
59
60
61
62
63
-
-
10
15
20
25
25
7.5
7.5
7.5
7.5
-
20
Not used
Not used
BackĆup lamps
Brake lamps
Front wipers
Front power windows
Rear power windows
Air conditioning, recirculated air
Electronic modules, instrument cluster
Air bag module
Light switch
Not used
Central lock module (on back side of fuse panel)
Relays
in the passenger compartment fuse panel
Relay
Description
17
18
19
20
21
22
23
24
25
Starter
Rear intermittent wiper (may be incorporated with relay 19)
Front intermittent wiper (may be incorporated with relay 18)
Not used
Not used
Not used
Horn
Battery saver
Rear defrost
Roadside
emergencies
164
Power distribution box
The power distribution box is
located in the engine compartment.
The power distribution box
contains highĆcurrent fuses that
protect your vehicle's main
electrical systems from overloads.
Always disconnect the
battery before servicing
high current fuses.
Always replace the cover to
the Power Distribution Box
before reconnecting the battery
or refilling fluid reservoirs.
Roadside
emergencies
165
The highĆcurrent fuses are coded as
follows.
Roadside
emergencies
166
Power distribution box
Fuse
Fuse amp.
rating
Description
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
64
65
40
30
-
-
-
50
40
30
20
10
30
15
-
-
-
10
10
10
-
10
20
20
-
-
-
10
10
-
-
30
-
Main power supply to electrical system
Engine cooling fan (A/C) 2nd fuse
Not used
Not used
Not used
Engine cooling fan (A/C) 1st fuse
Main power supply to electrical system
Ignition
Engine management
Battery voltage sensor, diagnostic plug
ABS
Fuel pump
Not used
Not used
Not used
Low beam (left side)
Low beam (right side)
Heated oxygen sensors
Not used
Engine management
ABS
DRL (low beams)
Not used
Not used
Not used
High beam (left side)
High beam (right side)
Not used
Not used
Heater blower motor
Not used
Maintenance
and care
184
IDENTIFYING
COMPONENTS IN THE ENGINE COMP
ARTMENT
2.0 SPI engine
Battery
Windshield
washer fluid
reservoir
Engine coolant
reservoir
(marked red
and black)
Brake/clutch
fluid
reservoir
Engine oil
filler cap
Transaxle
fluid
dipstick
Power
steering fluid
reservoir
Air filter
assembly
Fuse
box
Engine oil
dipstick
For ease of identification, most filler caps and the engine oil dipstick are
marked yellow and black.
Maintenance
and care
185
IDENTIFYING
COMPONENTS IN THE ENGINE COMP
ARTMENT
2.0 Zetec-E engine
Battery
Windshield
washer fluid
reservoir
Engine coolant
reservoir
(marked red and
black)
Brake/clutch
fluid
reservoir
Engine oil
filler cap
Engine oil
dipstick
Power
steering fluid
reservoir
Air filter
assembly
Fuse
box
Transaxle
fluid
dipstick
For ease of identification, most filler caps and the engine oil dipstick are
marked yellow and black.
Roadside emergencies
127
FUSES
Switch off the ignition and
all the electrical equipment
before changing a fuse.
Always replace a faulty fuse with a
new one of the same rating.
Auxiliary
fuse box
Central
fuse box
Any improper alterations to
the electrical or fuel system
can endanger the safety of the
vehicle as they could constitute a
fire hazard or cause engine
damage. Have any work involving
these systems or the replacement
of relays or high current carrying
fuses carried out by experts.
Auxiliary fuse box
This is located on the left-hand side
of the engine compartment.
To check or replace a fuse, remove
the cover of the fuse box by
releasing the catch and lifting up.
Changing a fuse
A fuse puller is located in the lid of
the auxiliary fuse box.
Roadside emergencies
128
Fuses in the auxiliary fuse box
(in the engine compartment)
Fuse
Ampere
rating
Colour
Circuits protected
1
1
40
orange
Main power supply to electrical system
2
Not used
3
40
orange
Glow plug heater 2
4
1
50
red
Heated front screen
5
1
60
blue
Diesel glow plug
6
1
30
green
Engine cooling fan (air conditioning)
7
1
40
orange
Main power supply to electrical system
8
1
30
green
Ignition
9
1
20
yellow
Engine management
10
1
black
Battery voltage sensor
11
30
green
ABS pump
12
15
blue
Fuel pump, diesel injection pump
13
30
green
Headlight washer system
14
10
red
Daytime running lights (parking lights)
15
10
red
A/C clutch solenoid
16
15
blue
Dipped beam left-hand side
17
15
blue
Dipped beam right-hand side
1
The replacement of these fuses requires specialist knowledge.
Roadside emergencies
129
Fuses in the auxiliary fuse box
(in the engine compartment)
Fuse
Ampere
rating
Colour
Circuits protected
18
10
red
H02S sensor transmitter
(catalytic converter)
19
Not used
20
10
red
Engine management
21
20
yellow
ABS valves
22
20
yellow
Daytime running lights (Xenon headlights
only)
23
20
yellow
Auxiliary heater (diesel engine), power sup-
ply for battery backup sounder
(ST170 only)
24
30
green
Glow plug heater 1,
subwoofer
(ST170 only)
25
15
blue
Daytime running lights (conventional
headlights only)
26
10
red
Main beam left-hand side
27
10
red
Main beam right-hand side
28
10
red
Heated front screen, diesel fuel fired heater,
diesel engine
29
30
green
Engine cooling fan (air conditioning)
64
30
green
Heater blower motor
65
30
green
Engine cooling fan
1
The replacement of these fuses requires specialist knowledge.
Roadside emergencies
130
Central fuse box
This is located on the left-hand side
underneath the instrument panel.
Open the glove compartment. Push
in both sides of the glove
compartment and swivel it down
completely.
Roadside emergencies
131
Central fuse box
Fuse
Ampere
rating
Colour
Circuits protected
30
10
red
Light switch
31
15
blue
Radio
32
15
blue
Direction indicator (GEM)
33
20
yellow
Horn, power seat
34
20
yellow
Power sunroof
35
7.5
brown
Interior lights, power mirrors
36
7.5
brown
Electronic modules, instrument
cluster
37
25
white
Power windows, central global
closing (left-hand side)
38
25
white
Power windows, central global
closing (right-hand side)
39
Not used
40
10
red
Reversing light
41
7.5
brown
Radio (accessory)
42
15
blue
Brake lights
43
15
blue
Power windows, rear screen wiper
44
20
yellow
Front and rear fog lights
45
7.5
brown
Air conditioning, recirculated air
46
7.5
brown
ABS module
47
15
blue
Cigar lighter, centre power point
48
10
red
Data link connector
49
25
white
Heated rear screen
50
7.5
brown
Heated mirrors
Roadside emergencies
132
Central fuse box
Fuse
Ampere
rating
Colour
Circuits protected
51
Not used
52
15
blue
Heated front seats
53
10
red
Reversing light, heated washer jets
54
Not used
55
25
white
Front power windows
56
20
yellow
Front screen wiper
57
7.5
brown
Side lights right-hand side
58
7.5
brown
Side lights left-hand side
59
10
red
Light switch
60
7.5
brown
Air bag module
61
7.5
brown
Electronic modules, instrument
cluster
62
7.5
brown
Number plate lights
63
20
yellow
Central locking (on the rear side of
the fuse box)
Maintenance and care
147
Engine compartment
Position
Description
See page
Power steering fluid reservoir
154
Engine oil filler cap
1
152
Brake/clutch fluid reservoir
152
Auxiliary fuse box
127
Air cleaner
No maintenance
necessary
Screen washer fluid reservoir
154
Battery
139
Vehicle identification plate
158
Engine oil dipstick
1
151
Engine coolant reservoir
153
1
For easy identification, filler caps and the engine oil dipstick are marked in colour.
1.4 l/1.6 l Zetec±SE 16V
J