Ford Fiesta - 2013 Fuse Box Diagram

Ford Fiesta - 2013 Fuse Box Diagram

PRINCIPLES OF OPERATION
WARNING:
Airbags DO NOT inflate slowly or gently, and the
risk of injury from a deploying airbag is the greatest close to the
trim covering the airbag module.
WARNING:
All occupants of the vehicle, including the driver,
should always properly wear their safety belts, even when an
airbag supplemental restraint system is provided.
WARNING:
Always transport children 12 years old and under in
the back seat and always properly use appropriate child
restraints.
WARNING:
Never place your arm over the airbag module as a
deploying airbag can result in serious arm fractures or other
injuries.
WARNING:
Airbags can kill or injure a child in a child seat.
NEVER place a rear-facing child seat in front of an active airbag.
If you must use a forward-facing child seat in the front seat, move the
seat all the way back.
WARNING:
Do not attempt to service, repair, or modify the
airbag supplemental restraint systems or its fuses. Contact your
authorized dealer as soon as possible.
WARNING:
Several airbag system components get hot after
inflation. Do not touch them after inflation.
WARNING:
If the airbag has deployed, the airbag will not
function again and must be replaced immediately. If the airbag is
not replaced, the unrepaired area will increase the risk of injury in a
collision.
42
Supplementary Restraints System
2013 Fiesta
(fie)
Owners Guide gf, 1st Printing
USA
(fus)
DO NOT attempt to repair or service the system; take your vehicle
immediately to an authorized dealer.
If it is necessary to modify an advanced front airbag system to
accommodate a person with disabilities, contact the Ford Customer
Relationship Center at the phone number shown in the
Customer
Assistance
section of this owner’s guide.
SIDE AIRBAGS
WARNING:
Do not place objects or mount equipment on or near
the airbag cover, on the side of the seatbacks (of the front seats),
or in front seat areas that may come into contact with a deploying
airbag. Failure to follow these instructions may increase the risk of
personal injury in the event of a collision.
WARNING:
Do not use accessory seat covers. The use of
accessory seat covers may prevent the deployment of the side
airbags and increase the risk of injury in an accident.
WARNING:
Do not lean your head on the door. The side airbag
could injure you as it deploys from the side of the seatback.
WARNING:
Do not attempt to service, repair, or modify the
airbag, its fuses or the seat cover on a seat containing an airbag.
Contact your authorized dealer as soon as possible.
WARNING:
If the side airbag has deployed,
the airbag will not
function again. The side airbag system (including the seat)
must be inspected and serviced by an authorized dealer.
If the
airbag is not replaced, the unrepaired area will increase the risk of
injury in a collision.
The side airbags are fitted on the outboard side of the seatbacks of the
front seats. In certain lateral collisions, the airbag on the side affected by
the collision will be inflated. The airbag was designed to inflate between
the door panel and occupant to further enhance the protection provided
occupants in side impact collisions.
50
Supplementary Restraints System
2013 Fiesta
(fie)
Owners Guide gf, 1st Printing
USA
(fus)
The system consists of the following:
A label or embossed side panel indicating
that side airbags are fitted to your vehicle.
Side airbags located inside the seatback of
the driver and front passenger seats.
Crash sensors and monitoring system with readiness
indicator. Refer to
Crash sensors and airbag indicator
later in this chapter.
Front passenger sensing system
Note:
The passenger sensing system will deactivate the passenger
seat-mounted side airbag if it detects an empty, unbuckled passenger
seat.
The design and development of the side airbag system included
recommended testing procedures that were developed by a group of
automotive safety experts known as the Side Airbag Technical Working
Group. These recommended testing procedures help reduce the risk of
injuries related to the deployment of side airbags.
SIDE CURTAIN AIRBAGS
WARNING:
Do not place objects or mount equipment on or near
the headliner at the siderail that may come into contact with a
deploying side curtain airbag. Failure to follow these instructions may
increase the risk of personal injury in the event of a collision.
WARNING:
Do not lean your head on the door. The curtain
airbag could injure you as it deploys from the headliner.
WARNING:
Do not attempt to service, repair, or modify the side
curtain airbags, its fuses, the A, B, or C pillar trim, or the
headliner on a vehicle containing side curtain airbags. Contact your
authorized dealer as soon as possible.
Supplementary Restraints System
51
2013 Fiesta
(fie)
Owners Guide gf, 1st Printing
USA
(fus)
AUXILIARY POWER POINTS
WARNING:
Do not plug optional electrical accessories into the
cigarette lighter socket (if equipped). Improper use of the lighter
can cause damage not covered by your warranty, and can result in fire
or serious injury.
Note:
Do not insert objects other than an accessory plug into the power
point. This will damage the outlet and blow the fuse.
Note:
Do not hang any type of accessory or accessory bracket from the
plug.
Note:
Do not use the power point over the vehicle capacity of 12 volts
DC 180 watts or a fuse may blow.
Note:
Do not use the power point for operating a cigarette lighter
element.
Note:
Improper use of the power point can cause damage not covered
by your warranty.
Note:
Always keep the power point caps closed when not in use.
Run the engine for full capacity use of the power point. To prevent the
battery from being discharged:
Do not use the power point longer than necessary when the engine is
not running.
Do not leave devices plugged in overnight or when the vehicle is
parked for extended periods.
Locations
Power points may be found:
on the instrument panel
on the rear of the center console
inside the center console storage bin.
126
Auxiliary Power Points
2013 Fiesta
(fie)
Owners Guide gf, 1st Printing
USA
(fus)
If you cannot move the gearshift lever out of P (Park) with ignition in
the on position and the brake pedal pressed, it is possible that a fuse has
blown or the vehicle’s brake lamps are not operating properly. Refer to
the
Fuses
chapter for more information.
If the fuse is not blown and the brake lamps are working properly, the
following procedure will allow you to move the gearshift lever from P (Park):
1. Apply the parking brake, turn the
ignition key to the off position and
remove the key.
2. Using a screwdriver (or similar
tool), carefully pry off and remove
the passenger side console cover to
expose the inside of the shifter
assembly.
3. Locate the brake shift interlock
lever on the passenger side of the
shifter assembly.
4. Apply the brake pedal. Using a
screwdriver (or similar tool), press
and hold the brake shift interlock
lever forward below the metal blade
while pulling the gearshift lever out
of the P (Park) position and into
the N (Neutral) position.
5. Install the console cover.
6. Apply the brake pedal, start the vehicle and release the parking brake.
Note:
See your authorized dealer as soon as possible if this procedure is
used.
If Your Vehicle Gets Stuck in Mud or Snow
Note:
Do not rock the vehicle if the engine is not at normal operating
temperature or damage to the transmission may occur.
Note:
Do not rock the vehicle for more than a minute or damage to the
transmission and tires may occur, or the engine may overheat.
If your vehicle gets stuck in mud or snow, it may be rocked out by
shifting between forward and reverse gears, stopping between shifts in a
steady pattern. Press lightly on the accelerator in each gear.
Transmission
147
2013 Fiesta
(fie)
Owners Guide gf, 1st Printing
USA
(fus)
CHANGING A FUSE
Fuses
If electrical components in the vehicle
are not working, a fuse may have
blown. Blown fuses are identified by a
broken wire within the fuse. Check
the appropriate fuses before replacing
any electrical components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
Standard Fuse Amperage Rating and Color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
Yellow
70A
Tan
Brown
80A
Natural
Black
Black
15
188
Fuses
2013 Fiesta
(fie)
Owners Guide gf, 1st Printing
USA
(fus)
FUSE SPECIFICATION CHART
Power Distribution Box
WARNING:
Always disconnect the battery before servicing high
current fuses.
WARNING:
To reduce risk of electrical shock, always replace the
cover to the power distribution box before reconnecting the
battery or refilling fluid reservoirs.
The power distribution box is located in the engine compartment. It has
high-current fuses that protect your vehicle’s main electrical systems
from overloads.
If the battery has been disconnected and reconnected, refer to
Changing the vehicle battery
in the
Maintenance
chapter.
R11
R8
R12
R9
R5
R3
R6
R4
R13
R10
R2
R1
R15
R14
R7
F41
F35
F26
F17
F27
F18
F28
F19
F29
F20
F30
F21
F31
F22
F32
F23
F33
F24
F34
F25
F42
F36
F43
F37
F44
F38
F45
F39
F40
F6
F1
F7
F2
F8
F3
F9
F4
F10
F5
F14
F11
F15
F12
F16
F13
F46
Fuses
189
2013 Fiesta
(fie)
Owners Guide gf, 1st Printing
USA
(fus)
The high-current fuses are coded as follows:
Fuse/Relay
Number
Fuse Amp
Rating
Protected Components
F1
40A*
Anti-lock brake system pump
F2
50A*
Transmission control module
F3
40A*
Engine cooling fan relay and
motor
F4
40A*
Heater blower relay and motor
F5
60A*
Passenger compartment fuse
panel
F6
30A*
Body control module – door locks
F7
60A*
Passenger compartment fuse
panel (ignition relay)
F8
40A*
Powertrain control module, Power
distribution box
F9
20A*
Anti-lock brake system module
valve
F10
30A*
Starter inhibit relay, Starter motor
F11
30A*
Electronic fuel pump relay, Fuel
tank, Ignition coil
F12
Not used
F13
Not used
F14
Not used
F15
Not used
F16
Not used
F17
20A**
High beam relay
F18
Not used
F19
20A**
Low beam relay
F20
15A**
Heated exhaust gas oxygen
sensor, Catalyst module sensor
F21
7.5A**
Low and High beams coil relay
control
190
Fuses
2013 Fiesta
(fie)
Owners Guide gf, 1st Printing
USA
(fus)
Fuse/Relay
Number
Fuse Amp
Rating
Protected Components
F22
15A**
Mass air flow sensor, Powertrain
control module, Fuel injectors,
Vehicle speed sensor, Variable
camshaft timing, Canister purge
F23
15A**
Daytime running lights
F24
Not used
F25
15A**
Body control module – exterior
lighting
F26
20A**
Body control module – battery
saver, horn
F27
Not used
F28
15A**
Body control module – turn
signals
F29
Not used
F30
10A**
A/C clutch solenoid and relay
F31
Not used
F32
7.5A**
Transmission control module,
Powertrain control module
F33
15A**
Ignition coil
F34
30A**
Body control module – rear
window defroster
F35
10A**
Left headlamp (low beam)
F36
10A**
Right headlamp (low beam)
F37
10A**
Left headlamp (high beam)
F38
10A**
Right headlamp (high beam)
F39
2A**
Natural vacuum leak detection
F40
Not used
F41
Not used
F42
Not used
F43
Not used
F44
Not used
F45
Not used
Fuses
191
2013 Fiesta
(fie)
Owners Guide gf, 1st Printing
USA
(fus)
Fuse/Relay
Number
Fuse Amp
Rating
Protected Components
F46
Not used
R1
Not used
R2
Not used
R3
Powertrain control module relay
R4
Heater blower relay
R5
Engine cooling fan relay
R6
Air condition clutch relay
R7
Not used
R8
Daytime running lamp
R9
Starter inhibit relay
R10
High beam relay
R11
Low beam relay
R12
Reverse lamp relay (automatic
transmission only)
R13
Coil pack relay (Mexico only)
R14
Not used
R15
Not used
*Cartridge fuses **Mini fuses
192
Fuses
2013 Fiesta
(fie)
Owners Guide gf, 1st Printing
USA
(fus)
Passenger Compartment Fuse Panel
The fuse panel is located behind the glove box. Open the glove box,
press the sides inward and swing the glove box down.
The fuses are coded as follows:
Fuse/Relay
Number
Fuse Amp
Rating
Protected Components
F1
15A
Ignition switch, Keyless entry
ignition and accessory relays
F2
10A
Electronic mirror, Air conditioning
clutch, Engine compartment fuse
panel
F3
7.5A
Instrument cluster
F4
7.5A
Passenger airbag deactivation
indicator, Occupant classification
system
F5
15A
Diagnostic connector
F6
10A
Backup lamp
F25
F19
F10
F1
F11
F13
F15
F17
F2
F4
F6
F8
F12
F14
F16
F18
F34
F35
F36
F31
F32
F33
F3
F5
F7
F9
F20
F21
F22
F23
F24
F26
F27
F28
F29
F30
R1
R7
R4
R3
R2
R5
R6
R8
R9
Fuses
193
2013 Fiesta
(fie)
Owners Guide gf, 1st Printing
USA
(fus)
Fuse/Relay
Number
Fuse Amp
Rating
Protected Components
F7
7.5A
Instrument panel display,
Intelligent access antenna, Manual
climate controls
F8
7.5A
Front dome lamp, Moonroof
F9
20A
Keyless vehicle module
F10
15A
Radio, SYNC
±
module, Global
positioning system module
F11
20A
Body control module – front
wipers
F12
20A
Tire pressure monitoring system
F13
15A
Body control module – rear wiper
F14
20A
Intelligent access module
F15
15A
Wiper switch
F16
7.5A
Power mirror switch, Driver
window switch
F17
15A
Heated seats
F18
10A
Stop lamps, Turn signals
F19
7.5A
Instrument cluster
F20
10A
Airbag module
F21
10A
Body control module – ignition
switch, Climate control, Passive
anti-theft system transceiver,
Electronic power steering module,
Instrument cluster, Engine
compartment fuse panel
F22
7.5A
Accelerator pedal position sensor,
Powertrain control module, Gear
shifter, Anti-lock brake system
ignition feed
F23
10A
Transmission control unit ignition
feed, Tire pressure monitoring
system ignition feed
194
Fuses
2013 Fiesta
(fie)
Owners Guide gf, 1st Printing
USA
(fus)
Fuse/Relay
Number
Fuse Amp
Rating
Protected Components
F24
Not used
F25
7.5A
Exterior mirrors
F26
7.5A
Tire pressure monitoring system
F27
Not used
F28
Not used
F29
Not used
F30
Not used
F31
30A
Rear power window switches
F32
20A
Passenger compartment fuse
panel battery saver relay
F33
20A
Power points
F34
30A
Front power window switches
F35
20A
Moonroof
F36
Not used
R1
Ignition relay
R2
Left rear stop/turn lamp relay
(4-door only)
R3
Right rear stop/turn lamp relay
(4-door only)
R4
Driver heated seat relay
R5
Passenger heated seat relay
R6
Intelligent access module –
accessory relay
R7
Intelligent access module –
ignition relay
R8
Battery saver relay, Rear
powerpoints
R9
Not used
Fuses
195
2013 Fiesta
(fie)
Owners Guide gf, 1st Printing
USA
(fus)
CHANGING A BULB
Lamp Assembly Condensation
Exterior lamps are vented to accommodate normal changes in pressure.
Condensation can be a natural by-product of this design. When moist air
enters the lamp assembly through the vents, there is a possibility that
condensation can occur when the temperature is cold. When normal
condensation occurs, a thin film of mist can form on the interior of the
lens. The thin mist eventually clears and exits through the vents during
normal operation. Clearing time may take as long as 48 hours under dry
weather conditions.
Examples of acceptable condensation are:
Presence of thin mist (no streaks, drip marks or droplets)
Fine mist covers less than 50% of the lens
Examples of unacceptable moisture (usually caused by a lamp water
leak) are:
Water puddle inside the lamp
Large water droplets, drip marks or streaks present on the interior of
the lens
Take your vehicle to a dealer for service if any of the above conditions of
unacceptable moisture are present.
Replacing Bulbs
Note:
Before changing bulb, verify the corresponding fuse is not blown.
The low beam headlamps, high beam headlamps, front turn signals and
side marker lamps are located in the headlamp assembly and can be
replaced individually by removing the headlamp assembly as a unit.
Replacing Headlamp Bulbs
Note:
Handle a halogen headlamp bulb carefully and keep out of
children’s reach. Grasp the bulb by only its plastic base and do not touch
the glass. The oil from your hand could cause the bulb to break the next
time the headlamps are operated.
Note:
If the bulb is accidentally touched, it should be cleaned with
rubbing alcohol before being used.
Maintenance
211
2013 Fiesta
(fie)
Owners Guide gf, 1st Printing
USA
(fus)
PRINCIPLES OF OPERATION
WARNING:
Airbags do not inflate slowly or gently, and the risk
of injury from a deploying airbag is the greatest close to the trim
covering the airbag module.
WARNING:
All occupants of your vehicle, including the driver,
should always properly wear their safety belts, even when an
airbag supplemental restraint system is provided.
WARNING:
Always transport children 12 years old and under in
the back seat and always properly use appropriate child
restraints.
WARNING:
Never place your arm over the airbag module as a
deploying airbag can result in serious arm fractures or other
injuries.
WARNING:
Airbags can kill or injure a child in a child seat.
NEVER place a rear-facing child seat in front of an active airbag.
If you must use a forward-facing child seat in the front seat, move the
seat all the way back.
WARNING:
Do not attempt to service, repair, or modify the
airbag supplemental restraint systems or its fuses. Contact your
authorized dealer as soon as possible.
WARNING:
Several airbag system components get hot after
inflation. Do not touch them after inflation.
WARNING:
If the airbag has deployed, the airbag will not
function again and must be replaced immediately. If the airbag is
not replaced, the unrepaired area will increase the risk of injury in a
crash.
The airbags are a supplemental restraint system and are designed to
work with the safety belts to help protect the driver and right front
Supplementary Restraints System
43
2013 Fiesta
(fie)
Owners Guide gf, 2nd Printing
USA
(fus)
SIDE AIRBAGS
WARNING:
Do not place objects or mount equipment on or near
the airbag cover, on the side of the seat backs (of the front
seats), or in front seat areas that may come into contact with a
deploying airbag. Failure to follow these instructions may increase the
risk of personal injury in the event of a crash.
WARNING:
Do not use accessory seat covers. The use of
accessory seat covers may prevent the deployment of the side
airbags and increase the risk of injury in an accident.
WARNING:
Do not lean your head on the door. The side airbag
could injure you as it deploys from the side of the seat back.
WARNING:
Do not attempt to service, repair, or modify the
airbag, its fuses or the seat cover on a seat containing an airbag.
Contact your authorized dealer as soon as possible.
WARNING:
If the side airbag has deployed, the airbag will not
function again. The side airbag system (including the seat) must
be inspected and serviced by an authorized dealer. If the airbag is not
replaced, the unrepaired area will increase the risk of injury in a crash.
The side airbags are located on the outboard side of the seat backs of
the front seats. In certain lateral crashes, the airbag on the side affected
by the crash will be inflated. The airbag was designed to inflate between
the door panel and occupant to further enhance the protection provided
occupants in side impact crashes.
Supplementary Restraints System
51
2013 Fiesta
(fie)
Owners Guide gf, 2nd Printing
USA
(fus)
The system consists of the
following:
a tag on the seat back indicating
that side airbags are found on
your vehicle
side airbags located inside the
seat back of the driver and front
passenger seats.
crash sensors and monitoring system with readiness
indicator. See
Crash Sensors and Airbag Indicator
later in
this chapter.
front passenger sensing system.
Note:
The passenger sensing system will deactivate the passenger
seat-mounted side airbag if it detects an empty, unbuckled passenger
seat.
The design and development of the side airbag system included
recommended testing procedures that were developed by a group of
automotive safety experts known as the Side Airbag Technical Working
Group. These recommended testing procedures help reduce the risk of
injuries related to the deployment of side airbags.
SIDE CURTAIN AIRBAGS
WARNING:
Do not place objects or mount equipment on or near
the headliner at the siderail that may come into contact with a
deploying side curtain airbag. Failure to follow these instructions may
increase the risk of personal injury in the event of a crash.
WARNING:
Do not lean your head on the door. The curtain
airbag could injure you as it deploys from the headliner.
WARNING:
Do not attempt to service, repair, or modify the side
curtain airbags, its fuses, the A, B, or C pillar trim, or the
headliner on a vehicle containing side curtain airbags. Contact your
authorized dealer as soon as possible.
52
Supplementary Restraints System
2013 Fiesta
(fie)
Owners Guide gf, 2nd Printing
USA
(fus)
AUXILIARY POWER POINTS
WARNING:
Do not plug optional electrical accessories into the
cigarette lighter socket (if equipped). Improper use of the lighter
can cause damage not covered by your warranty, and can result in fire
or serious injury.
Note:
If used when the engine is not running, the battery will discharge.
There may be insufficient power to restart your engine.
Note:
Do not insert objects other than an accessory plug into the power
point. This will damage the outlet and blow the fuse.
Note:
Do not hang any type of accessory or accessory bracket from the
plug.
Note:
Do not use the power point over the vehicle capacity of 12 volts
DC 180 watts or a fuse may blow.
Note:
Do not use the power point for operating a cigarette lighter
element.
Note:
Improper use of the power point can cause damage not covered
by your warranty.
Note:
Always keep the power point caps closed when not in use.
Run the engine for full capacity use of the power point. To prevent the
battery from being discharged:
Do not use the power point longer than necessary when the engine is
not running.
Do not leave devices plugged in overnight or when the vehicle is
parked for extended periods.
Locations
Power points may be found:
on the instrument panel
on the rear of the center console
inside the center console storage bin.
128
Auxiliary Power Points
2013 Fiesta
(fie)
Owners Guide gf, 2nd Printing
USA
(fus)
Upshifts when accelerating
(recommended for best fuel economy)
Shift from:
1 - 2
15 mph (24 km/h)
2 - 3
25 mph (40 km/h)
3 - 4
40 mph (64 km/h)
4 - 5
45 mph (72 km/h)
5 - 6
50 mph (80 km/h)
The instrument cluster will show the current selected gear you are in.
SelectShift will automatically make some downshifts for you if it has
determined that you have not downshifted in time. Although SelectShift
will make some downshifts for you, it will still allow you to downshift at
any time as long as SelectShift determines that the engine will not be
damaged from over-revving.
Note:
If manual control is no longer desired, return the gear shift lever
from S (Sport) to D (Drive).
Note:
Engine damage may occur if excessive engine revving is held
without shifting.
Brake-Shift Interlock
WARNING:
Do not drive your vehicle until you verify that the
brake lamps are working.
WARNING:
When doing this procedure, you will be taking the
vehicle out of park which means the vehicle can roll freely. To
avoid unwanted vehicle movement, always fully set the parking brake
prior to doing this procedure. Use wheel chocks if appropriate.
WARNING:
If the parking brake is fully released, but the brake
warning lamp remains illuminated, the brakes may not be
working properly. See your authorized dealer.
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the on position unless the brake pedal is pressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the on position and the brake pedal pressed, it is possible that a fuse has
Transmission
149
2013 Fiesta
(fie)
Owners Guide gf, 2nd Printing
USA
(fus)
blown or the vehicle’s brake lamps are not operating properly. Refer to
the
Fuses
chapter for more information.
If the fuse is not blown and the brake lamps are working properly, the
following procedure will allow you to move the gearshift lever from P
(Park):
1. Apply the parking brake, turn the
ignition key to the off position and
remove the key.
2. Using a screwdriver (or similar
tool), carefully pry off and remove
the passenger side console cover to
expose the inside of the shifter
assembly.
3. Locate the brake shift interlock
lever on the passenger side of the
shifter assembly.
4. Apply the brake pedal. Using a
screwdriver (or similar tool), press
and hold the brake shift interlock
lever forward below the metal blade
while pulling the gearshift lever out
of the P (Park) position and into
the N (Neutral) position.
5. Install the console cover.
6. Apply the brake pedal, start the vehicle and release the parking brake.
Note:
See your authorized dealer as soon as possible if this procedure is
used.
If Your Vehicle Gets Stuck in Mud or Snow
Note:
Do not rock the vehicle if the engine is not at normal operating
temperature or damage to the transmission may occur.
Note:
Do not rock the vehicle for more than a minute or damage to the
transmission and tires may occur, or the engine may overheat.
If your vehicle gets stuck in mud or snow, it may be rocked out by
shifting between forward and reverse gears, stopping between shifts in a
steady pattern. Press lightly on the accelerator in each gear.
150
Transmission
2013 Fiesta
(fie)
Owners Guide gf, 2nd Printing
USA
(fus)
CHANGING A FUSE
Fuses
WARNING:
Always replace a fuse with one that has the
specified amperage rating. Using a fuse with a higher amperage
rating can cause severe wire damage and could start a fire.
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Standard Fuse Amperage Rating and Color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
Yellow
70A
Tan
Brown
80A
Natural
Black
Black
15
Fuses
191
2013 Fiesta
(fie)
Owners Guide gf, 2nd Printing
USA
(fus)
FUSE SPECIFICATION CHART
Power Distribution Box
WARNING:
Always disconnect the battery before servicing high
current fuses.
WARNING:
To reduce risk of electrical shock, always replace the
cover to the power distribution box before reconnecting the
battery or refilling fluid reservoirs.
The power distribution box is located in the engine compartment. It has
high-current fuses that protect your vehicle’s main electrical systems
from overloads.
If the battery has been disconnected and reconnected, see
Changing the
Vehicle Battery
in the
Maintenance
chapter.
R11
R8
R12
R9
R5
R3
R6
R4
R13
R10
R2
R1
R15
R14
R7
F41
F35
F26
F17
F27
F18
F28
F19
F29
F20
F30
F21
F31
F22
F32
F23
F33
F24
F34
F25
F42
F36
F43
F37
F44
F38
F45
F39
F40
F6
F1
F7
F2
F8
F3
F9
F4
F10
F5
F14
F11
F15
F12
F16
F13
F46
192
Fuses
2013 Fiesta
(fie)
Owners Guide gf, 2nd Printing
USA
(fus)
The high-current fuses are coded as follows:
Fuse or relay
number
Fuse amp
rating
Protected components
F1
40A*
Anti-lock brake system pump
F2
50A*
Transmission control module
F3
40A*
Engine cooling fan relay and
motor
F4
40A*
Heater blower relay and motor
F5
60A*
Passenger compartment fuse
panel
F6
30A*
Body control module – door locks
F7
60A*
Passenger compartment fuse
panel (ignition relay)
F8
40A*
Powertrain control module, Power
distribution box
F9
20A*
Anti-lock brake system module
valve
F10
30A*
Starter inhibit relay, Starter motor
F11
30A*
Electronic fuel pump relay, Fuel
tank, Ignition coil
F12
Not used
F13
Not used
F14
Not used
F15
Not used
F16
Not used
F17
20A**
High beam relay
F18
Not used
F19
20A**
Low beam relay
F20
15A**
Heated exhaust gas oxygen
sensor, Catalyst module sensor
F21
7.5A**
Low and High beams coil relay
control
Fuses
193
2013 Fiesta
(fie)
Owners Guide gf, 2nd Printing
USA
(fus)
Fuse or relay
number
Fuse amp
rating
Protected components
F22
15A**
Mass air flow sensor, Powertrain
control module, Fuel injectors,
Vehicle speed sensor, Variable
camshaft timing, Canister purge
F23
15A**
Daytime running lights
F24
Not used
F25
15A**
Body control module – exterior
lighting
F26
20A**
Body control module – battery
saver, horn
F27
Not used
F28
15A**
Body control module – turn
signals
F29
Not used
F30
10A**
A/C clutch solenoid and relay
F31
Not used
F32
7.5A**
Transmission control module,
Powertrain control module
F33
15A**
Ignition coil
F34
30A**
Body control module – rear
window defroster
F35
10A**
Left headlamp (low beam)
F36
10A**
Right headlamp (low beam)
F37
10A**
Left headlamp (high beam)
F38
10A**
Right headlamp (high beam)
F39
2A**
Natural vacuum leak detection
F40
Not used
F41
Not used
F42
Not used
F43
Not used
F44
Not used
F45
Not used
194
Fuses
2013 Fiesta
(fie)
Owners Guide gf, 2nd Printing
USA
(fus)
Fuse or relay
number
Fuse amp
rating
Protected components
F46
Not used
R1
Not used
R2
Not used
R3
Powertrain control module relay
R4
Heater blower relay
R5
Engine cooling fan relay
R6
Air condition clutch relay
R7
Not used
R8
Daytime running lamp
R9
Starter inhibit relay
R10
High beam relay
R11
Low beam relay
R12
Reverse lamp relay (automatic
transmission only)
R13
Coil pack relay (Mexico only)
R14
Not used
R15
Not used
*Cartridge fuses **Mini fuses
Fuses
195
2013 Fiesta
(fie)
Owners Guide gf, 2nd Printing
USA
(fus)
Passenger Compartment Fuse Panel
The fuse panel is located behind the glove box. Open the glove box,
press the sides inward and swing the glove box down.
The fuses are coded as follows:
Fuse or relay
number
Fuse amp
rating
Protected components
F1
15A
Ignition switch, Keyless entry
ignition and accessory relays
F2
10A
Electronic mirror, Air conditioning
clutch, Engine compartment fuse
panel
F3
7.5A
Instrument cluster
F4
7.5A
Passenger airbag deactivation
indicator, Occupant classification
system
F5
15A
Diagnostic connector
F6
10A
Backup lamp
F25
F19
F10
F1
F11
F13
F15
F17
F2
F4
F6
F8
F12
F14
F16
F18
F34
F35
F36
F31
F32
F33
F3
F5
F7
F9
F20
F21
F22
F23
F24
F26
F27
F28
F29
F30
R1
R7
R4
R3
R2
R5
R6
R8
R9
196
Fuses
2013 Fiesta
(fie)
Owners Guide gf, 2nd Printing
USA
(fus)
Fuse or relay
number
Fuse amp
rating
Protected components
F7
7.5A
Instrument panel display,
Intelligent access antenna, Manual
climate controls
F8
7.5A
Front dome lamp, Moonroof
F9
20A
Keyless vehicle module
F10
15A
Radio, SYNC® module, Global
positioning system module
F11
20A
Body control module – front
wipers
F12
20A
Tire pressure monitoring system
F13
15A
Body control module – rear wiper
F14
20A
Intelligent access module
F15
15A
Wiper switch
F16
7.5A
Power mirror switch, Driver
window switch
F17
15A
Heated seats
F18
10A
Stop lamps, Turn signals
F19
7.5A
Instrument cluster
F20
10A
Airbag module
F21
10A
Body control module – ignition
switch, Climate control, Passive
anti-theft system transceiver,
Electronic power steering module,
Instrument cluster, Engine
compartment fuse panel
F22
7.5A
Accelerator pedal position sensor,
Powertrain control module, Gear
shifter, Anti-lock brake system
ignition feed
F23
10A
Transmission control unit ignition
feed, Tire pressure monitoring
system ignition feed
Fuses
197
2013 Fiesta
(fie)
Owners Guide gf, 2nd Printing
USA
(fus)
Fuse or relay
number
Fuse amp
rating
Protected components
F24
Not used
F25
7.5A
Exterior mirrors
F26
7.5A
Tire pressure monitoring system
F27
Not used
F28
Not used
F29
Not used
F30
Not used
F31
30A
Rear power window switches
F32
20A
Rear power point
F33
20A
Power points
F34
30A
Front power window switches
F35
20A
Moonroof
F36
Not used
R1
Ignition relay
R2
Left rear stop/turn lamp relay
(4-door only)
R3
Right rear stop/turn lamp relay
(4-door only)
R4
Driver heated seat relay
R5
Passenger heated seat relay
R6
Intelligent access module –
accessory relay
R7
Intelligent access module –
ignition relay
R8
Battery saver relay, Rear
powerpoints
R9
Not used
198
Fuses
2013 Fiesta
(fie)
Owners Guide gf, 2nd Printing
USA
(fus)
CHANGING A BULB
Lamp Assembly Condensation
Exterior lamps are vented to accommodate normal changes in pressure.
Condensation can be a natural by-product of this design. When moist air
enters the lamp assembly through the vents, there is a possibility that
condensation can occur when the temperature is cold. When normal
condensation occurs, a thin film of mist can form on the interior of the
lens. The thin mist eventually clears and exits through the vents during
normal operation. Clearing time may take as long as 48 hours under dry
weather conditions.
These are examples of acceptable condensation:
Presence of thin mist (no streaks, drip marks or droplets).
Fine mist covers less than 50% of the lens.
These are examples of unacceptable moisture (usually caused by a lamp
water leak):
Water puddle inside the lamp.
Large water droplets, drip marks or streaks present on the interior of
the lens.
Take your vehicle to a dealer for service if any of the above conditions of
unacceptable moisture are present.
Replacing Bulbs
Note:
Before changing bulb, verify the corresponding fuse is not blown.
The low beam headlamps, high beam headlamps, front turn signals and
side marker lamps are located in the headlamp assembly and can be
replaced individually by removing the headlamp assembly as a unit.
Replacing Headlamp Bulbs
Note:
Handle a halogen headlamp bulb carefully and keep out of
children’s reach. Grasp the bulb by only its plastic base and do not touch
the glass. The oil from your hand could cause the bulb to break the next
time the headlamps are operated.
Note:
If the bulb is accidentally touched, it should be cleaned with
rubbing alcohol before being used.
214
Maintenance
2013 Fiesta
(fie)
Owners Guide gf, 2nd Printing
USA
(fus)
FUSE BOX LOCATIONS
Engine compartment fuse box
E78332
Passenger compartment fuse box
This fuse box is located behind the glove
box. Open the glove box and empty the
contents. Press the sides inwards and
swivel the glove box downwards.
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by properly trained
technicians.
Switch the ignition and all electrical
equipment off before touching or
attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Note:
You can identify a blown fuse by a
break in the filament.
Note:
All fuses, except high current fuses,
are a push fit.
119
Fuses
FUSE SPECIFICATION CHART
Engine compartment fuse box
E113002
Circuits protected
Ampere rating
Fuse
ABS module
40
1
ABS ESP module
30
1
Cooling system fan high speed
60
2
Cooling system fan
40
3
Cooling system fan low speed
30
3
Heater blower
30
4
Passenger compartment fuse box supply (battery)
60
5
120
Fuses
Circuits protected
Ampere rating
Fuse
Body control module
30
6
Passenger compartment fuse box supply (ignition)
60
7
Glow plugs
60
8
Heated windscreen
60
9
Not used
-
10
Starter relay
30
11
Main beam left-hand relay
10
12
Main beam right-hand relay
10
13
Dipped beam left-hand relay
10
14
Dipped beam right-hand relay
10
15
Powertrain control module, high and low cooling fan
15
16
Heated oxygen (HEGO) sensors (Petrol engines)
15
17
Power supply module (Diesel engines)
20
17
FN (Automatic) transmission
10
18
Not used
-
19
Not used
-
20
Not used
-
21
Lighting control battery supply
15
22
Front fog lamps
15
23
Direction indicators
15
24
Daytime running lamps
10
25
Electric exterior mirrors switch, electric folding
mirrors, power window (driver's door)
7.5
26
Powertrain control module
7.5
27
ABS module, ESP
20
28
Air conditioning clutch
10
29
Not used
-
30
121
Fuses
Circuits protected
Ampere rating
Fuse
Not used
-
31
Horn, battery saver, keyless vehicle module
20
32
Heated rear window
20
33
Fuel pump relay, diesel fuel heater
20
34
Not used
-
35
Not used
-
36
Not used
-
37
Not used
-
38
Not used
-
39
Not used
-
40
Circuits switched
Relay
Cooling system fan
R1
Glow plugs (DV4 Stage 4 only), Heated windscreen
R2
Powertrain control module
R3
Main beam
R4
Dipped beam
R5
Daytime running lamps
R6
Engine cooling fan
R7
Starter
R8
Air conditioning clutch
R9
Front fog lamps
R10
Fuel pump, fuel heater
R11
Reverse lamp
R12
Heater blower
R13
122
Fuses
Passenger compartment fuse box - Type 1
E125747
Circuits protected
Ampere rating
Fuse
Ignition, rain sensor, heated windscreen
7.5
1
Stop lamps
10
2
Reversing lamp, Rear view camera (VP)
7.5
3
Headlamp levelling
7.5
4
Windscreen wipers
20
5
Rear window wiper
15
6
Washer pump
15
7
Parking aid (vehicles with front parking aid)
10
8
Not used
-
9
Heated seats
7.5
10
Not used
-
11
Airbag module
10
12
Ignition, electric power assisted steering, instrument
cluster, passive anti theft system, ABS
10
13
123
Fuses
Circuits protected
Ampere rating
Fuse
Powertrain control module, gear selector lever, fuel
pump,
7.5
14
Audio system, instrument cluster
7.5
15
Heated exterior mirror
7.5
16
Ignition switch
15
17
Cigar lighter, front power point
20
18
Data link connector
15
19
Trailer module
20
20
Audio system, Navigation, Bluetooth
15
21
Instrument cluster
7.5
22
Multi functional display, clock, internal scanner,
heating ventilating, air conditioning panel
7.5
23
Not used
-
24
Power windows (front)
30
25
Heated windscreen, left-hand side
30
26
Heated windscreen, right-hand side
30
27
Circuits switched
Relay
Ignition
R1
124
Fuses
Passenger compartment fuse box - Type 2
E125748
Circuits protected
Ampere rating
Fuse
Ignition, rain sensor, heated front screen
7.5
1
Stop lamps
10
2
Reversing lamp
7.5
3
Headlamp levelling
7.5
4
Windscreen wipers
20
5
Rear window wiper
15
6
Washer pump
15
7
125
Fuses
Circuits protected
Ampere rating
Fuse
Parking aid (vehicles with front parking aid)
10
8
Not used
-
9
Heated seats
7.5
10
Not used
-
11
Airbag module
10
12
Ignition, electric power assisted steering, instrument
cluster, passive anti theft system, ABS
10
13
Powertrain control module, gear selector lever, fuel
pump,
7.5
14
Audio system, instrument cluster
7.5
15
Heated exterior mirror
7.5
16
Ignition switch
15
17
Cigar lighter, Front power point
20
18
Data link connector
15
19
Trailer module
20
20
Audio system, Navigation, Bluetooth
15
21
Instrument cluster
7.5
22
Multi functional display, clock, internal scanner,
Heating Ventilating and Air Conditioning panel
7.5
23
Not used
-
24
Power windows (front)
30
25
Heated windscreen, left-hand side
30
26
Heated windscreen, right-hand side
30
27
Voltage Quality Module
30
28
Not used
-
29
Cigar lighter, Front power point
20
30
Power windows (rear)
30
31
Not used
-
32
126
Fuses
Circuits protected
Ampere rating
Fuse
Not used
-
33
Keyless entry
20
34
Keyless entry
20
35
Not used
-
36
Not used
-
37
Not used
-
38
Not used
-
39
Not used
-
40
Not used
-
41
Not used
-
42
Not used
-
43
Not used
-
44
Not used
-
45
Not used
-
46
Not used
-
47
Not used
-
48
Not used
-
49
Circuits switched
Relay
Ignition
R1
Power fold mirror 1
R2
Power fold mirror 2
R3
Not used
R4
Not used
R5
Keyless entry (accessory)
R6
Keyless entry (ignition)
R7
Not used
R8
127
Fuses
Circuits switched
Relay
Not used
R9
Not used
R10
Not used
R11
Not used
R12
128
Fuses
UNDER BONNET OVERVIEW - 1.25L DURATEC-16V (SIGMA)/1.4L
DURATEC-16V (SIGMA)/1.6L DURATEC-16V TI-VCT (SIGMA)
E103505
A
B
C
H
G
F
I
D
E
Engine coolant reservoir
*
:
See
Engine Coolant Check
(page 137).
A
Brake and clutch fluid reservoir (right-hand drive)
*
:
See
Brake and Clutch
Fluid Check
(page 138).
B
Engine oil filler cap
*
:
See
Engine Oil Check
(page 137).
C
Battery:
See
Vehicle battery
(page 143).
D
Brake and clutch fluid reservoir (left-hand drive)
*
:
See
Brake and Clutch Fluid
Check
(page 138).
E
Engine compartment fuse box. See
Fuses
(page 119).
F
Windscreen and rear window washer fluid reservoir:
See
Washer Fluid Check
(page 138).
G
133
Maintenance
Brake and clutch fluid reservoir (left-hand drive)
*
:
See
Brake and Clutch Fluid
Check
(page 138).
E
Engine compartment fuse box. See
Fuses
(page 119).
F
Windscreen and rear window washer fluid reservoir:
See
Washer Fluid Check
(page 138).
G
Air cleaner: No maintenance necessary.
H
Engine oil dipstick
*
:
See
Engine Oil Check
(page 137).
I
*
The filler caps and the engine oil dipstick are coloured for easy identification.
UNDER BONNET OVERVIEW - 1.6L DURATORQ-TDCI (DV) DIESEL
E103509
A
B
C
H
G
F
I
D
E
135
Maintenance
Engine coolant reservoir
*
:
See
Engine Coolant Check
(page 137).
A
Brake and clutch fluid reservoir (right-hand drive)
*
:
See
Brake and Clutch
Fluid Check
(page 138).
B
Engine oil filler cap
*
:
See
Engine Oil Check
(page 137).
C
Battery:
See
Vehicle battery
(page 143).
D
Brake and clutch fluid reservoir (left-hand drive)
*
:
See
Brake and Clutch Fluid
Check
(page 138).
E
Engine compartment fuse box. See
Fuses
(page 119).
F
Windscreen and rear window washer fluid reservoir:
See
Washer Fluid Check
(page 138).
G
Air cleaner: No maintenance necessary.
H
Engine oil dipstick
*
:
See
Engine Oil Check
(page 137).
I
*
The filler caps and the engine oil dipstick are coloured for easy identification.
ENGINE OIL DIPSTICK - 1.25L
DURATEC-16V (SIGMA)/1.4L
DURATEC-16V (SIGMA)/1.6L
DURATEC-16V TI-VCT (SIGMA)
E95540
B
A
MIN
A
MAX
B
ENGINE OIL DIPSTICK - 1.4L
DURATORQ-TDCI (DV)
DIESEL/1.6L DURATORQ-TDCI
(DV) DIESEL
Type 1
E90983
A
B
MIN
A
MAX
B
136
Maintenance
12 Volt DC Power Point
WARNING
Do not plug optional electrical
accessories into the cigar lighter
socket. Incorrect use of the lighter
can cause damage not covered by your
warranty, and can result in fire or serious
injury.
Note:
When you switch the ignition on, you
can use the socket to power 12 volt
appliances with a maximum current rating
of 20 amps.
After you switch the ignition off the power
supply will only work for a maximum of 30
minutes.
Note:
Do not insert objects other than an
accessory plug into the power point. This
will damage the outlet and blow the fuse.
Note:
Do not hang any type of accessory or
accessory bracket from the plug.
Note:
Do not use the power point over the
vehicle capacity of 12 volt DC 180 watt or a
fuse may blow.
Note:
Do not use the power point for
operating a cigar lighter element.
Note:
Incorrect use of the power point can
cause damage not covered by your
warranty.
Note:
Always keep the power point caps
closed when not in use.
Run the engine for full capacity use of the
power point.
To prevent the battery from running out of
charge:
Do not use the power point longer than
necessary when the engine is not
running.
Do not leave devices plugged in
overnight or when your vehicle is
parked for extended periods.
Location
Power points may be found:
on the center console
on the rear of the center console.
CIGAR LIGHTER
(IF EQUIPPED)
Note:
Do not hold the cigar lighter element
pressed in.
Note:
If you use the socket when the engine
is not running, the battery may lose charge.
Note:
When you switch the ignition on, you
can use the socket to power 12 volt
appliances with a maximum current rating
of 20 amps.
Note:
After you switch the ignition off the
power supply will only work for a maximum
of 30 minutes.
Note:
Use only Ford accessory connectors
or connectors specified for use with SAE
standard sockets.
Press the element in to use the cigar
lighter. It will pop out automatically.
95
Fiesta (CCN)
Auxiliary Power Points
FUSE BOX LOCATIONS
Engine Compartment Fuse Box
Passenger Compartment Fuse Box
This fuse box is located behind the glove
box. Open the glove box and empty the
contents. Press the sides inwards and
swivel the glove box downward.
142
Fiesta (CCN)
Fuses
FUSE SPECIFICATION CHART
Engine Compartment Fuse Box
Circuits protected
Fuse rating
Fuse
Anti-lock braking system module
40 A
1
Anti-lock braking system, electronic stability program
module
30 A
1
Cooling system fan high speed
60 A
2
Cooling system fan
40 A
3
Cooling system fan low speed
30 A
3
Heater blower
30 A
4
Passenger compartment fuse box supply (battery)
60 A
5
143
Fiesta (CCN)
Fuses
Circuits protected
Fuse rating
Fuse
Body control module
30 A
6
Passenger compartment fuse box supply (ignition)
60 A
7
Automatic transmission
50 A
8
Heated windshield
60 A
9
Not used
-
10
Starter relay
30 A
11
High beam left-hand relay
10 A
12
High beam right-hand relay
10 A
13
Water pump
10 A
14
Ignition coils
10 A
15
Powertrain control module, high and low cooling fan
15 A
16
Heated oxygen sensors (gasoline engines)
15 A
17
Power supply module (diesel engines)
20 A
17
Not used
-
18
Air conditioning compressor
7.5A
19
Not used
-
20
Cooling system fan (1.6L Duratorq-TDCi)
7.5A
21
Not used
-
22
Front fog lamps
15 A
23
Direction indicators
15 A
24
Exterior lighting left-hand side
15 A
25
Exterior lighting right-hand side
15 A
26
Powertrain control module
7.5 A
27
Anti-lock braking system, electronic stability program
20 A
28
Air conditioning clutch
10 A
29
Not used
-
30
Not used
-
31
144
Fiesta (CCN)
Fuses
Circuits protected
Fuse rating
Fuse
Horn, battery saver, keyless vehicle module
20 A
32
Heated rear window
20 A
33
Fuel pump relay, diesel fuel heater
20 A
34
Category one alarm system
15 A
35
Automatic transmission controller
7.5A
36
Front door module left-hand side
25 A
37
Front door module right-hand side
25 A
38
Rear door module left-hand side
25 A
39
Rear door module right-hand side
25 A
40
Circuits switched
Relay
Cooling system fan
R1
Heated windshield
R2
Power control module
R3
High beam
R4
Not used
R5
Not used
R6
Engine cooling fan
R7
Starter
R8
Air conditioning clutch
R9
Front fog lamps
R10
Fuel pump, diesel fuel heater
R11
Reversing lamp
R12
Heater blower
R13
145
Fiesta (CCN)
Fuses
Passenger Compartment Fuse Box
Circuits protected
Fuse rating
Fuse
Ignition, autowipers, heated
windshield, dome lamp,
interior mirror
7.5 A
1
Stop lamps
10 A
2
Reversing lamp
7.5 A
3
Headlamp leveling
7.5 A
4
Windshield wipers
20 A
5
146
Fiesta (CCN)
Fuses
Circuits protected
Fuse rating
Fuse
Rear window wiper
15 A
6
Washer pump
15 A
7
Not used
-
8
Passenger heated seat
15 A
9
Driver heated seat
15 A
10
Not used
-
11
Airbag module
10 A
12
Ignition, electric power
assisted steering, instrument
cluster, passive anti-theft
system, anti-lock braking
system
10 A
13
Powertrain control module,
transmission selector lever,
fuel pump
7.5 A
14
Audio system, instrument
cluster
7.5 A
15
Not used
-
16
Not used
-
17
Not used
-
18
Data link connector
15 A
19
Trailer module
20 A
20
Audio system
15 A
21
Instrument cluster
7.5 A
22
Multi functional display,
clock, internal scanner,
heating vents, air condi-
tioning panel
7.5 A
23
SYNC, Bluetooth
10 A
24
Not used
-
25
147
Fiesta (CCN)
Fuses
Circuits protected
Fuse rating
Fuse
Heated windshield left-hand
side
30 A
26
Heated windshield right-
hand side
30 A
27
High quality power supply
(vehicles with Start-Stop)
30 A
28
Rear power point
20 A
29
Cigar lighter, front auxiliary
power point
20 A
30
Not used
-
31
Not used
-
32
Not used
-
33
Keyless entry
20 A
34
Keyless entry
20 A
35
Ignition switch
15 A
36
Not used
-
37
Not used
-
38
Not used
-
39
Not used
-
40
Not used
-
41
Rear view camera
7.5 A
42
Active city stop
10 A
43
Passenger airbag deactiva-
tion indicator
7.5 A
44
Not used
-
45
Not used
-
46
Not used
-
47
Not used
-
48
Not used
-
49
148
Fiesta (CCN)
Fuses
Circuits switched
Relay
Ignition
R1
Cigar lighter, front auxiliary power point
R2
Not used
R3
Active city stop
R4
Not used
R5
Keyless entry (accessory)
R6
Keyless entry (ignition)
R7
Rear auxiliary power point
R8
Not used
R9
Not used
R10
Not used
R11
Not used
R12
CHANGING A FUSE
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by an authorized dealer.
Switch the ignition and all electrical
equipment off before attempting to
change a fuse.
Always replace a fuse with one that
has the specified amperage rating.
Using a fuse with a higher amperage
rating can cause severe wire damage and
could start a fire.
If electrical components in your vehicle are
not working, a fuse may have blown. A
break in the fuse wire will indicate a blown
fuse. Check the appropriate fuses before
replacing any electrical components.
149
Fiesta (CCN)
Fuses
UNDER HOOD OVERVIEW - 1.0L ECOBOOST
Engine coolant reservoir
*
: See
Engine Coolant Check
(page 161).
A
Brake and clutch fluid reservoir (right-hand drive)
*
: See
Brake and Clutch
Fluid Check
(page 162).
B
Engine oil filler cap
*
: See
Engine Oil Check
(page 160).
C
Battery: See
Changing the 12V Battery
(page 162).
D
Brake and clutch fluid reservoir (left-hand drive)
*
: See
Brake and Clutch Fluid
Check
(page 162).
E
Engine compartment fuse box. See
Fuses
(page 142).
F
Windshield and rear window washer fluid reservoir: See
Washer Fluid Check
(page 162).
G
Air cleaner: No maintenance necessary.
H
Engine oil dipstick
*
: See
Engine Oil Check
(page 160).
I
*
The filler caps and the engine oil dipstick are colored for easy identification.
152
Fiesta (CCN)
Maintenance
UNDER HOOD OVERVIEW - 1.25L DURATEC-16V (SIGMA)
Engine coolant reservoir
*
: See
Engine Coolant Check
(page 161).
A
Brake and clutch fluid reservoir (right-hand drive)
*
: See
Brake and Clutch
Fluid Check
(page 162).
B
Engine oil filler cap
*
: See
Engine Oil Check
(page 160).
C
Battery: See
Changing the 12V Battery
(page 162).
D
Brake and clutch fluid reservoir (left-hand drive)
*
: See
Brake and Clutch Fluid
Check
(page 162).
E
Engine compartment fuse box. See
Fuses
(page 142).
F
Windshield and rear window washer fluid reservoir: See
Washer Fluid Check
(page 162).
G
Air cleaner: No maintenance necessary.
H
Engine oil dipstick
*
: See
Engine Oil Check
(page 160).
I
*
The filler caps and the engine oil dipstick are colored for easy identification.
153
Fiesta (CCN)
Maintenance
UNDER HOOD OVERVIEW - 1.4L DURATEC-16V (SIGMA)
Engine coolant reservoir
*
: See
Engine Coolant Check
(page 161).
A
Brake and clutch fluid reservoir (right-hand drive)
*
: See
Brake and Clutch
Fluid Check
(page 162).
B
Engine oil filler cap
*
: See
Engine Oil Check
(page 160).
C
Battery: See
Changing the 12V Battery
(page 162).
D
Brake and clutch fluid reservoir (left-hand drive)
*
: See
Brake and Clutch Fluid
Check
(page 162).
E
Engine compartment fuse box. See
Fuses
(page 142).
F
Windshield and rear window washer fluid reservoir: See
Washer Fluid Check
(page 162).
G
Air cleaner: No maintenance necessary.
H
Engine oil dipstick
*
: See
Engine Oil Check
(page 160).
I
*
The filler caps and the engine oil dipstick are colored for easy identification.
154
Fiesta (CCN)
Maintenance
UNDER HOOD OVERVIEW - 1.6L DURATEC-16V TI-VCT (SIGMA)
Engine coolant reservoir
*
: See
Engine Coolant Check
(page 161).
A
Brake and clutch fluid reservoir (right-hand drive)
*
: See
Brake and Clutch
Fluid Check
(page 162).
B
Engine oil filler cap
*
: See
Engine Oil Check
(page 160).
C
Battery: See
Changing the 12V Battery
(page 162).
D
Brake and clutch fluid reservoir (left-hand drive)
*
: See
Brake and Clutch Fluid
Check
(page 162).
E
Engine compartment fuse box. See
Fuses
(page 142).
F
Windshield and rear window washer fluid reservoir: See
Washer Fluid Check
(page 162).
G
Air cleaner: No maintenance necessary.
H
Engine oil dipstick
*
: See
Engine Oil Check
(page 160).
I
*
The filler caps and the engine oil dipstick are colored for easy identification.
155
Fiesta (CCN)
Maintenance
UNDER HOOD OVERVIEW - 1.6L ECOBOOST
Engine coolant reservoir
*
: See
Engine Coolant Check
(page 161).
A
Brake and clutch fluid reservoir (right-hand drive)
*
: See
Brake and Clutch
Fluid Check
(page 162).
B
Engine oil filler cap
*
: See
Engine Oil Check
(page 160).
C
Engine oil dipstick
*
: See
Engine Oil Check
(page 160).
D
Battery: See
Changing the 12V Battery
(page 162).
E
Brake and clutch fluid reservoir (left-hand drive)
*
: See
Brake and Clutch Fluid
Check
(page 162).
F
Engine compartment fuse box: See
Fuses
(page 142).
G
Windshield and rear window washer fluid reservoir: See
Washer Fluid Check
(page 162).
H
Air cleaner: No maintenance necessary.
I
*
The filler caps and the engine oil dipstick are colored for easy identification.
156
Fiesta (CCN)
Maintenance
UNDER HOOD OVERVIEW - 1.5L DURATORQ-TDCI
Engine coolant reservoir
*
: See
Engine Coolant Check
(page 161).
A
Brake and clutch fluid reservoir (right-hand drive)
*
: See
Brake and Clutch
Fluid Check
(page 162).
B
Engine oil filler cap
*
: See
Engine Oil Check
(page 160).
C
Battery: See
Changing the 12V Battery
(page 162).
D
Brake and clutch fluid reservoir (left-hand drive)
*
: See
Brake and Clutch Fluid
Check
(page 162).
E
Engine compartment fuse box. See
Fuses
(page 142).
F
Windshield and rear window washer fluid reservoir: See
Washer Fluid Check
(page 162).
G
Air cleaner: No maintenance necessary.
H
Engine oil dipstick
*
: See
Engine Oil Check
(page 160).
I
*
The filler caps and the engine oil dipstick are colored for easy identification.
157
Fiesta (CCN)
Maintenance
UNDER HOOD OVERVIEW - 1.6L DURATORQ-TDCI (DV) DIESEL
Engine coolant reservoir
*
: See
Engine Coolant Check
(page 161).
A
Brake and clutch fluid reservoir (right-hand drive)
*
: See
Brake and Clutch
Fluid Check
(page 162).
B
Engine oil filler cap
*
: See
Engine Oil Check
(page 160).
C
Battery: See
Changing the 12V Battery
(page 162).
D
Brake and clutch fluid reservoir (left-hand drive)
*
: See
Brake and Clutch Fluid
Check
(page 162).
E
Engine compartment fuse box. See
Fuses
(page 142).
F
Windshield and rear window washer fluid reservoir: See
Washer Fluid Check
(page 162).
G
Air cleaner: No maintenance necessary.
H
Engine oil dipstick
*
: See
Engine Oil Check
(page 160).
I
*
The filler caps and the engine oil dipstick are colored for easy identification.
158
Fiesta (CCN)
Maintenance
FIRST AID KIT
(G1071278)
E102206
First aid kit is stored in the glove box. It
contains spare fuses, spare bulbs and
emergency medical treatment kit. Use it
under emergency situations.
WARNING TRIANGLE
(G1344138)
Space is provided in the luggage
compartment.
88
(G1071278)
Fiesta ()
Roadside Emergencies
FUSE BOX LOCATIONS
(G1477126)
Engine compartment fuse box
E78332
Passenger compartment fuse box
- RHD
This fuse box is located behind the glove
box. Open the glove box and empty the
contents. Press the sides inwards and
swivel the glove box downwards.
CHANGING A FUSE
(G842014)
WARNINGS
Do not modify the electrical system
of your vehicle in any way. Have
repairs to the electrical system and
the replacement of relays and high current
fuses carried out by properly trained
technicians.
Switch the ignition and all electrical
equipment off before touching or
attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Note:
You can identify a blown fuse by a
break in the filament.
Note:
All fuses, except high current fuses,
are a push fit.
89
(G1477126)
Fiesta ()
Fuses
FUSE SPECIFICATION CHART
(G1406847)
Engine compartment fuse box
E130152
Circuits protected
Ampere
rating
Fuse
ABS module
40
1
Cooling system fan high speed
60
2
Cooling system fan low speed
40
3
Heater blower
30
4
Passenger compartment fuse box supply (battery)
60
5
Body control module (BCM)
30
6
Ignition relay
60
7
90
(G1406847)
Fiesta ()
Fuses
Circuits protected
Ampere
rating
Fuse
Glow plug
60
8 (Diesel
only)
Automatic transmission unit
20
9
Automatic transmission unit
20
10
Starter relay
30
11
Head lamp switch assembly
7.5
12
Back up lamp
7.5
13
Not used
-
14
Not used
-
15
Powertrain control module, engine control
15
16
Fuel pump relay
15
17 (Petrol
only)
Fuel heater
20
17 (Diesel
only)
Dipped beam left-hand relay
10
18
Dipped beam right-hand relay
10
19
Main beam left-hand relay
10
20
Main beam right-hand relay
10
21
(BCM) Lighting control battery supply
15
22
Front fog lamps
15
23
Direction indicators
15
24
Not used
-
25
Electric exterior mirrors switch, electric folding mirrors,
power window (driver door)
7.5
26
Powertrain control module (PCM)
10
27 (Petrol
only)
Powertrain control module (PCM)
7.5
27 (Diesel
only)
Horn
20
28
91
(G1406847)
Fiesta ()
Fuses
Circuits protected
Ampere
rating
Fuse
Air conditioning clutch
10
29
Not used
-
30
Not used
-
31
Battery saver, horn
20
32
Heated rear window
20
33
Fuel tank, fuel pump relay, fuel heater
20
34
Not used
-
35
ABS valve (ESP only)
20
36
Not used
-
37
Not used
-
38
Not used
-
39
Not used
-
40
Circuits switched
Relay
Cooling system fan (High speed)
R1
Ignition
R2
Powertrain control module (PCM)
R3
Main beam
R4
Dipped beam
R5
Backup lamp (automatic transmission only)
R6
Cooling system fan (Low speed)
R7
Starter
R8
Air conditioning clutch
R9
Front fog lamps
R10
92
(G1406847)
Fiesta ()
Fuses
Circuits switched
Relay
Fuel pump, fuel heater
R11
Dual horn
R12
Heater blower
R13
Passenger compartment fuse box
E113003
Circuits protected
Ampere rating
Fuse
Audio system, instrument cluster
7.5
1
Airbag module
10
2
Not used
-
3
93
(G1406847)
Fiesta ()
Fuses
Circuits protected
Ampere rating
Fuse
Not used
-
4
Not used
-
5
Passive anti theft system, electric power assisted steering
(EPAS), instrument cluster, BCM
10
6
Gear shift
10
7
Not used
-
8
Stop lamp switch
10
9
BCM (windscreen wiper)
20
10
Multi functional display, clock, internal scanner, heating
ventilating, air conditioning (HVAC) panel
7.5
11
Audio system
15
12
Cigar lighter
20
13
Not used
-
14
Data link connector
15
15
Not used
-
16
Ignition switch
15
17
Instrument Cluster
7.5
18
Fog lamp relay
7.5
19
Blower control, A/C clutch
7.5
20
Not used
-
21
Wiper switch, washer pump
15
22
Not used
-
23
Body control module and rear wiper
15
24
Power windows (rear)
30
25
Power windows (front)
30
26
94
(G1406847)
Fiesta ()
Fuses
UNDER BONNET OVERVIEW - 1.5L DURATEC-16V TI-VCT
(81KW/110PS) - SIGMA
(G1397288)
A
B
C
D
E
F
G
H
E137668
Engine coolant reservoir*: See
Engine Coolant Check
(page
102).
A
Brake and clutch fluid reservoir*:
See
Brake and Clutch Fluid
Check
(page 102).
B
Engine oil filler cap*: See
Engine Oil Check
(page 101).
C
Battery: See
Vehicle battery
(page 108).
D
Engine compartment fuse box:
See
Fuses
(page 89).
E
Windscreen and rear window
washer fluid reservoir: See
Washer Fluid Check
(page 102).
F
Air cleaner: No maintenance
necessary.
G
Engine oil dipstick*: See
Engine
Oil Check
(page 101).
H
*The filler caps and the engine oil dipstick
are coloured for easy identification.
99
(G1397288)
Fiesta ()
Maintenance
UNDER BONNET OVERVIEW - 1.5L DURATORQ-TDCI
(67KW/91PS)
(G1397292)
A
B
D
G
F
H
E
C
E137751
Engine coolant reservoir*: See
Engine Coolant Check
(page
102).
A
Brake and clutch fluid reservoir*:
See
Brake and Clutch Fluid
Check
(page 102).
B
Engine oil filler cap*: See
Engine Oil Check
(page 101).
C
Battery: See
Vehicle battery
(page 108).
D
Engine compartment fuse box:
See
Fuses
(page 89).
E
Windscreen and rear window
washer fluid reservoir: See
Washer Fluid Check
(page 102).
F
Air cleaner: No maintenance
necessary.
G
Engine oil dipstick*: See
Engine
Oil Check
(page 101).
H
100
(G1397292)
Fiesta ()
Maintenance