Ford F-550 - 2007 Fuse Box Diagram

Ford F-550 - 2007 Fuse Box Diagram

Storage compartment (if equipped)
Press the release on the door to
open the storage compartment.
The storage compartment may be
used to secure sunglasses or a
similar object and the front tab can
be used for holding tickets, paper,
envelopes, etc. The front bin may be
used to store small objects.
AUXILIARY POWER POINT (12VDC)
Power outlets are designed for accessory plugs only. Do not insert
any other object in the power outlet for this will damage the
outlet and blow the fuse. Do not hang any type of accessory or
accessory bracket from the plug. Improper use of the power
outlet can cause damage not covered by your warranty.
The auxiliary power point is located
on the instrument panel.
Do not use the power point for
operating the cigarette lighter
element (if equipped).
To prevent the fuse from being
blown, do not use the power
point(s) over the vehicle capacity of
12 VDC/180W.
To prevent the battery from being
discharged, do not use the power point longer than necessary when the
engine is not running.
Always keep the power point caps closed when not being used.
Cigar lighter (if equipped)
Do not plug optional electrical accessories into the cigarette lighter
socket.
Do not hold the lighter in with your hand while it is heating, this will
damage the lighter element and socket. The lighter will be released from
its heating position when it is ready to be used.
Improper use of the lighter can cause damage not covered by your
warranty.
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)
Driver Controls
59
UPFITTER CONTROLS (IF EQUIPPED)
Your vehicle may be equipped with
the Upfitter option package which
will provide four switches, mounted
in the center of the instrument
panel, labeled AUX 1, AUX 2, AUX 3
and AUX 4. These switches will only
operate while the ignition is in the 4
(ON) position, whether the engine
is running or not. It is, however, recommended that the engine remain
running to maintain battery charge when using the Upfitter switches for
extended duration or higher current draws. (This is even more important
for vehicles with diesel engines since the glow plugs are also draining
battery power when the ignition key is in the 4 [ON] position.)
When switched on by the operator they provide 10 amps or 30 amps of
electrical battery power for a variety of personal or commercial uses.
If your vehicle is equipped with this
option, there will also be a relay box
with a fuse located inside the glove
box.
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)
Driver Controls
67
The relays and fuse in the glove box are coded as shown in the
accompanying illustration.
There will also be one power lead
for each switch found as a blunt-cut
and sealed wire located behind the
passenger compartment fuse panel.
They are coded as follows:
Switch
Circuit number
Wire color
Fuse
AUX 1
1936
Orange with
Light Green
Trace
30A
AUX 2
1933
Orange
30A
AUX 3
1934
Orange with
Yellow Trace
10A
AUX 4
1935
Orange with
Light Blue Trace
10A
More detailed information about the Upfitter switches can be found in
the
Electrical Wiring
section of the
Ford Truck Body Builders Layout
Book
, found at www.fleet.ford.com/truckbbas.
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)
Driver Controls
68
Do not attempt to service, repair, or modify the airbag
supplemental restraint systems or its fuses. See your authorized
dealer.
The front passenger air bag is not designed to offer protection to
an occupant in the center front seating position.
Modifying or adding equipment to the front end of the vehicle
(including frame, bumper, front end body structure and tow
hooks) may affect the performance of the airbag system, increasing the
risk of injury. Do not modify the front end of the vehicle.
Additional equipment such as snowplow equipment may effect
the performance of the airbag sensors increasing the risk of
injury. Please refer to the
Ford Truck Body Builders Layout Book
for
instructions about the appropriate installation of additional equipment.
Removing the blocker beam without installing snow plow
attachment hardware may effect airbag deployment in a crash.
Do not operate the truck unless either the blocker beam or snow plow
attachment hardware is installed on the vehicle.
Children and airbags
For additional important safety information, read all information on
safety restraints in this guide.
Children must always be properly restrained. Failure to follow these
instructions may increase the risk of injury in a collision.
An infant in a rear-facing seat faces a high risk of serious or fatal
injuries from a deploying passenger airbag. Rear facing infant
seats should NEVER be placed in the front seats, unless the passenger
airbag is turned off. See
Passenger airbag ON/OFF switch.
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)
Seating and Safety Restraints
112
Tires
All trailer tires should be of the same size, and construction.
Select tires that meet the trailer loading requirements.
Always check tow vehicle and trailer tire pressure before towing.
Launching or retrieving a boat
When backing down a ramp during boat launching or retrieval,
Do not allow the static water level to rise above the bottom edge of
the rear bumper.
Do not allow waves to break higher than 6 inches (15 cm) above the
bottom edge of the rear bumper.
Disconnect the trailer tow electrical connector to prevent blown fuses
caused by water entering into your trailer’s electrical wiring.
Exceeding these limits may allow water to enter critical vehicle
components, adversely affecting driveability, emissions and reliability.
Replace front and rear axle lubricants any time the axles have been
submerged in water. Axle lubricant quantities are not to be checked
unless a leak is suspected.
RECREATIONAL TOWING
This applies to all 4x2 trucks with rear wheel drive capability.
An example of recreational towing is towing your vehicle behind a
motorhome. The following recreational towing guidelines are designed to
ensure that your transmission is not damaged.
Place the transmission in N (Neutral).
Maximum speed is 35 mph (56 km/h).
Maximum distance is 50 miles (80 km).
If a distance of 50 miles (80 km) or a speed of 35 mph (56 km/h) must
be exceeded, you must disconnect the driveshaft. Ford recommends the
driveshaft be removed/installed only by a qualified technician. See your
local authorized dealer for driveshaft removal/installation.
Improper removal/installation of the driveshaft can cause
transmission fluid loss, damage to the driveshaft and internal
transmission components.
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)
Tires, Wheels and Loading
167
If you cannot move the gearshift lever out of P (Park) with ignition in
the 4 (ON) position and the brake pedal depressed:
1. Apply the parking brake, turn ignition key to 2 (LOCK), then remove
the key.
2. Insert the key and turn it to 3 (OFF).
Apply the brake pedal and
shift to N (Neutral)
.
When the key is in the ignition and in the OFF position, the
automatic transmission shift lever can be moved from the P
(Park) position without the brake pedal depressed. To avoid unwanted
vehicle movement, always set the parking brake.
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
Emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
Always set the parking brake fully and make sure the gearshift is
latched in P (Park). Turn the ignition to the LOCK position and
remove the key whenever you leave your vehicle.
If the parking brake is fully released, but the brake warning lamp
remains illuminated, the brakes may not be working properly.
See your authorized dealer as soon as possible.
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)
Driving
179
The attached snowplow blade restricts airflow to the radiator, and may
cause the engine to run at a higher temperature:
If you are driving more than 15 miles (24 km) where outside air
temperatures are above freezing, then angle the plow blade to full left
or right to maximize airflow to the radiator.
If you are driving less than 15 miles (24 km) at speeds up to 40 mph
(64 km/h) in cold weather you will not need to adjust blade position
Follow the severe duty schedule in your
scheduled maintenance
information
for engine oil and transmission fluid change intervals.
Snowplowing with your airbag-equipped vehicle
Your vehicle is equipped with a driver and passenger airbag
Supplemental Restraint System (SRS) The SRS is designed to activate in
certain frontal and offset frontal collisions when the vehicle sustains
sufficient longitudinal deceleration.
Careless or high speed driving while plowing snow which results in
sufficient vehicle decelerations can deploy the airbag. Such driving also
increases the risk of accidents.
All occupants of the vehicle, including the driver, should always
properly wear their safety belts, even when an air bag
supplemental restraint system (SRS) is provided.
Never remove or defeat the “tripping mechanisms” designed into the
snow removal equipment by its manufacturer. Doing so may cause
damage to the vehicle and the snow removal equipment as well as
possible airbag deployment.
Do not attempt to service, repair, or modify the air bag
supplemental restraint system (SRS) or its fuses. See your Ford
or Lincoln Mercury dealer.
Additional equipment such as snowplow equipment may effect
the performance of the airbag sensors increasing the risk of
injury. Please refer to the
Ford Truck Body Builders Layout Book
for
instructions about the appropriate installation of additional equipment.
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)
Driving
203
This switch is located in the front
passenger’s footwell, behind the kick
panel access cover.
To reset the switch:
1. Turn the ignition off.
2. Check the fuel system for leaks.
3. If no leaks are apparent, reset the
switch by pushing in on the reset
button.
4. Turn the ignition on.
5. Wait a few seconds and return
the key to off.
6. Make another check for leaks.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
15
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
208
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the panel cover to access the fuses.
To remove the fuse panel cover, pull
the panel downward by the finger
slots on top of the panel. When the
top clips of the panel disengage, let
the panel fall easily.
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
209
To remove a fuse use the fuse puller
tool provided on the fuse panel
cover.
To reinstall the cover, align and
engage the two hooked clips at the
bottom of the cover onto the
instrument panel, then lift the panel
and press the top clips firmly into
place.
Always disconnect the battery before servicing high current
fuses.
Always replace the cover to the passenger compartment fuse
panel before reconnecting the battery.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
210
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
1
15A*
Adjustable pedals
2
10A*
Cluster
3
10A*
Upfitter #3
4
20A*
Power point (Instrument panel)
5
10A*
Upfitter #4
6
Not used
7
30A*
High beam headlamps,
Flash-to-pass
8
20A*
Back-up lamps
9
Not used
10
Not used
11
20A*
Radio (Main)
12
20A*
Cigar lighter, OBD II
13
5A*
Power mirrors
14
Not used
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
211
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
15
Not used
16
Not used
17
15A*
Exterior lamps
18
20A*
Flasher, Brake On-Off (BOO)
lamps
19
10A*
Body Security Module (BSM)
(Security)
20
15A*
Trailer tow Electric Brake
Controller (EBC)
21
20A*
Heated seats
22
20A*
Engine control
23
20A*
Engine control (gasoline engine
only)/Climate control (Diesel
engine only)
24
15A*
Tow haul, Blower relay, Electronic
Automatic Temperature Control
(EATC)
25
Not used
26
10A*
Airbags
27
15A*
Ignition switch RUN feed
28
10A*
Trailer tow EBC logic
29
10A*
Customer access
30
15A*
High beam headlamps
31
15A*
Starter relay
32
5A*
Radio (start)
33
15A*
Cluster, 4x4, Wipers
34
10A*
BOO switch (Low current)
35
10A*
Instrument cluster
36
Not used
37
15A*
Horn
38
20A*
Trailer tow park lamps
39
15A*
Heated mirrors
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
212
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
40
20A*
Fuel pump
41
10A*
Instrument cluster
42
15A*
Delayed accessory
43
10A*
Fog lamps
44
Not used
45
10A*
Ignition switch RUN/START feed
46
10A*
Left-hand low beam headlamp
47
10A*
Right-hand low beam headlamp
48
Not used
101
30A**
Trailer tow EBC
102
30A**
BSM (Door locks)
103
30A**
Ignition switch
104
Not used
105
Not used
106
Not used
107
20A**
Trailer tow battery charge
108
30A**
Upfitter #1
109
30A**
Upfitter #2
110
30A**
Ignition switch
111
Not used
112
30A**
Power seat (Driver)
113
30A**
Starter
114
30A**
Power seat (Passenger)
115
20A**
Upfitter control
116
30A**
Ignition switch
210
Not used
211
1
±
2
ISO relay
Back-up lamps
212
Not used
301
Full ISO relay
Trailer tow battery charge
302
Full ISO relay
Powertrain Control Module (PCM)
303
Not used
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
213
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
304
Not used
305
Full ISO relay
Upfitter control
306
Full ISO relay
Delayed accessory
307
Full ISO relay
Starter
601
30A circuit
breaker
Delayed accessory, Power
windows, Moonroof
602
Not used
* Mini fuse ** Cartridge fuse
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
To reduce risk of electrical shock, always replace the cover to
the Power Distribution Box before reconnecting the battery or
refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
214
The high-current fuses and relays are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
1
30A*
Wipers
2
40A*
Blower
3
30A*
Electronic Shift on the Fly
(ESOF)
4
Not used
5
50A*
Injector Driver Module (IDM)
(Diesel engine only)
6
Not used
7
Not used
8
Shunt
9
20A**
Trailer tow turn signals
10
10A**
Powertrain Control Module (PCM)
keep alive power, Canister vent
solenoid (gasoline engine only)
11
10A**
Anti-lock Brake System (ABS)
12
2A**
Brake pressure switch
13
15A**
Daytime Running Lamps (DRL)
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
215
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
14
Not used
15
15A**
IDM logic (Diesel engine only)
16
Not used
17
10A**
A/C clutch
18
10A**
IDM relay (Diesel engine only)
19
Not used
20
10A**
Trailer tow back-up lamps
21
Not used
22
60A***
ABS (Coils)
23
60A***
ABS (Pump)
201
1
±
2
ISO relay
Trailer tow right turn signal/stop
lamp
202
1
±
2
ISO relay
Trailer tow left turn signal/stop
lamp
203
1
±
2
ISO relay
A/C clutch
204
Not used
205
1
±
2
ISO relay
DRL #1
206
1
±
2
ISO relay
DRL #2
301
Full ISO relay
DRL #3
302
Not used
303
Full ISO relay
Blower
304
High-current
relay
IDM (Diesel engine only)
* Cartridge Fuse ** Mini Fuses *** Maxi fuse
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)
Roadside Emergencies
216