Ford F-53 Motorhome Chassis - 2013 Fuse Box Diagram

Ford F-53 Motorhome Chassis - 2013 Fuse Box Diagram

Brake-shift interlock
WARNING:
To prevent vehicle movement when following this
procedure, park on a level surface, ensure parking brake is set,
and block the rear wheels.
WARNING:
If your brake lamps are not working properly or if
you have disconnected the vehicle battery cables, the vehicle
brake lamps and hazard flashers may not properly warn traffic of a
vehicle breakdown or approaching danger, which can increase the risk
of serious injury or death. To minimize the risk of serious injury or
death, be aware of your surroundings, use other hazard signaling
devices if available, and move the vehicle to a safe location away from
traffic as soon as possible.
WARNING:
Do not drive your vehicle until you verify that the
brake lamps are working.
WARNING:
Always set the parking brake fully and make sure
the gearshift is latched in P (Park). Turn the ignition to the lock
position and remove the key whenever you leave your vehicle.
WARNING:
If the parking brake is fully released, but the brake
warning lamp remains illuminated, the brakes may not be
working properly. See your authorized dealer.
The vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) unless the brake
pedal is pressed.
If you cannot move the gearshift lever out of P (Park) position with the
ignition in the 4 (on) position and the brake pedal pressed, a
malfunction may have occurred. It is possible that a fuse has blown or
the vehicle’s brake lamps are not operating properly. Refer to
Fuses and
relays
in the
Roadside Emergencies
chapter. If the fuses and brake
lamps are working properly, and the vehicle still will not shift out of (P)
Park, see your authorized dealer for service.
42
Transmission
2013 Motorhome
(mot)
Owners Guide gf, 1st Printing
USA
(fus)
CHANGING A FUSE
Fuses
If electrical components in the vehicle
are not working, a fuse may have
blown. Blown fuses are identified by a
broken wire within the fuse. Check
the appropriate fuses before replacing
any electrical components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
Standard Fuse Amperage Rating and Color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
Yellow
70A
Tan
Brown
80A
Natural
Black
Black
15
74
Fuses
2013 Motorhome
(mot)
Owners Guide gf, 1st Printing
USA
(fus)
FUSE SPECIFICATION CHART
Power Distribution Box
WARNING:
Always disconnect the battery before servicing high
current fuses.
WARNING:
To reduce risk of electrical shock, always replace the
cover to the power distribution box before reconnecting the
battery or refilling fluid reservoirs.
The power distribution box is located in the engine compartment. It has
high-current fuses that protect your vehicle’s main electrical systems
from overloads.
If the battery has been disconnected and reconnected, refer to
Changing the vehicle battery
in the
Maintenance
chapter.
19
29
18
28
17
27
16
26
15
25
14
24
13
11
12
9
10
7
8
5
6
3
4
1
2
23
22
21
20
R6
R5
R4
R3
R2
R1
DIODE2
DIODE1
Fuses
75
2013 Motorhome
(mot)
Owners Guide gf, 1st Printing
USA
(fus)
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Protected Components
1
5A*
Power brake assist module –
Hydromax
2
10A*
A/C compressor clutch
3
20A*
A/C clutch relay coil, Mass air
flow sensor with intake air
temperature, Vapor management
valve, Engine heated exhaust gas
oxygen sensor #11 and #21,
Catalyst monitor sensor
4
5A*
Powertrain control module
memory
5
20A*
Powertrain control module power
6
20A*
Park lamp feeds, Instrument panel
fuse #41, Warning chime module,
Trailer tow running lamp relay
coil, Instrument panel dimmer
module
7
20A*
Ignition coils, Radio capacitors
8
30A*
Hydromax – Anti-lock brake
system module
9
10A*
Starter main relay coil, Starter
ground relay coil
10
20A*
Daytime running lamps
11
20A*
Fuel pump relay coil, Powertrain
control module power
12
25A*
Trailer tow back-up lamps feed,
Instrument panel - backup lamp
feed
13
30A**
Trailer tow electric brake
controller feed
14
60A**
Instrument panel battery feed
(fuse #9, 15, 21)
15
20A**
Trailer tow park lamps
76
Fuses
2013 Motorhome
(mot)
Owners Guide gf, 1st Printing
USA
(fus)
Fuse/Relay
Location
Fuse Amp
Rating
Protected Components
16
60A**
Anti-lock brake system module –
Hydromax
40A**
Anti-lock brake system module –
Hydroboost
17
20A**
Horn feed
18
20A**
Transmission control indicator
light, Tow/haul switch, Backup
lamp feed
19
Not used
20
30A**
Powertrain control module relay
coil, Powertrain control module
relay (Power distribution box
fuses # 3, 5, 7, 18)
21
20A**
Fuel pump motor, Fuel injectors
22
20A**
Diagnostic tool connector, Cigar
lighter feed
23
40A**
Blower motor feed
24
50A**
Instrument panel battery feed
(fuses #4, 10, 16, 22)
25
40A**
Ignition switch feed (Instrument
panel fuses #1, 5, 7, 11, 13, 14,
17, 19, 23; Power distribution box
fuses #9, 11)
26
40A**
Ignition switch feed (Instrument
panel fuses #5, 11, 17, 23, 26, 38)
27
30A**
Multi-function switch (headlamps)
28
30A**
Starter solenoid
29
60A**
Power brake assist motor –
Hydromax
40A**
Anti-lock brake system module –
Hydroboost
R1
A/C clutch relay
R2
Fuel pump relay
R3
Horn relay
Fuses
77
2013 Motorhome
(mot)
Owners Guide gf, 1st Printing
USA
(fus)
Fuse/Relay
Location
Fuse Amp
Rating
Protected Components
R4
Starter relay
R5
Blower motor relay
R6
Powertrain control module relay
Diode 1
Fuel pump diode
Diode 2
A/C clutch diode
* Mini Fuses ** Maxi Fuses
Diode and Relay Module
The module box is located by the power distribution box in front of the
radiator in the engine compartment.
The components are coded as follows:
Relay Location
Description
1
One touch integrated start (ATO diode)
2
Not used
3
Not used
4
Daytime running lamps power relay
5
Hydromax – brake on/off signal isolating relay
6
Reverse lamps relay
7
Starter ground relay
8
Trailer tow parking lamps relay
1
4
5
7
6
8
2
3
78
Fuses
2013 Motorhome
(mot)
Owners Guide gf, 1st Printing
USA
(fus)
Fuse Holder Module
The fuse holder module is located next to the diode/relay module.
Fuse Location
Fuse Amp
Rating
Protected Circuits
1
10A
Hydromax – brake on/off signal
Passenger Compartment Fuse Panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the panel cover to access the fuses.
To remove a fuse use the fuse puller tool provided on the fuse panel
cover.
Fuses
79
2013 Motorhome
(mot)
Owners Guide gf, 1st Printing
USA
(fus)
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Protected circuits
1
20A
Turn/stop lamps, Turn indicators,
Body builder rear turn/stop feeds
2
Not used
3
Not used
4
10A
Instrument panel cluster
5
10A
Body builder accessory feed
(accessory and run)
6
Not used
7
15A
Blower motor relay coil
8
10A
Brake lamps feed
9
20A
Stop lamps: Vehicle turn/stop
lamps, Body builder rear turn/stop
feeds, Body builder stop lamp
feed
10
10A
Instrument cluster memory,
Power brake assist lamp –
Hydromax
11
30A
Wiper/washer module, Wiper feed
12
Not used
13
10A
Anti-lock brake system module –
Hydromax
14
10A
Warning chime module, Power
brake assist module – Hydromax,
Instrument cluster power,
Instrument cluster warning lamps,
Anti-lock brake system module –
Hydroboost
15
15A
Left turn signal feed
16
20A
Body builder battery (+12V) feed
17
5A
Body builder radio feed
18
Not used
80
Fuses
2013 Motorhome
(mot)
Owners Guide gf, 1st Printing
USA
(fus)
Fuse/Relay
Location
Fuse Amp
Rating
Protected circuits
19
5A
Daytime running lamps relays
20
Not used
21
15A
Right turn signal feed
22
20A
Trailer tow turn signals
23
10A
Cluster run/accessory
24
Not used
25
10A
Body builder right-hand low beam
headlamp feed
26
10A
Brake shift interlock actuator
27
Not used
28
Not used
29
Not used
30
Not used
31
10A
Body builder left-hand low beam
headlamp feed
32
Not used
33
10A
Reverse lamps
34
10A
Trailer tow reverse lamps, Body
builder reverse gear
35
20A
Body builder high beam feed,
High beam indicator, Daytime
running lamps
36
Not used
37
Not used
38
10A
Body builder run feed
39
Not used
40
Not used
41
10A
Instrument illumination
42
Not used
43
Not used
44
Not used
Relay 1
Trailer tow right turn signal
Fuses
81
2013 Motorhome
(mot)
Owners Guide gf, 1st Printing
USA
(fus)
Fuse/Relay
Location
Fuse Amp
Rating
Protected circuits
Relay 2
Trailer tow left turn signal
Relay 3
Right turn signal
Relay 4
Left turn signal
Relay 5
Not used
Relay 6
Daytime running lamps, Parking
brake
Relay 7
Daytime running lamps on/off
Diode 1
Brake transmission shift interlock
Diode 2
Brake transmission shift interlock
F1
Not used
F2
Not used
F3
Not used
F4
10A
Brake transmission shift interlock
F5
Not used
F6
Not used
F7
Not used
F8
Not used
F9
Not used
F10
Not used
F11
Not used
F12
Not used
82
Fuses
2013 Motorhome
(mot)
Owners Guide gf, 1st Printing
USA
(fus)