Ford F-350 - 1999 Fuse Box Diagram

Ford F-350 - 1999 Fuse Box Diagram

Steps you can take to properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the Air Bag
Supplemental Restraint System or its fuses. See your Ford or
Lincoln-Mercury dealer.
Children and air bags
For additional important safety information, read all information on
safety restraints in this guide.
Children must always be properly restrained. Failure to follow these
instructions may increase the risk of injury in a collision.
An infant in a rear-facing seat faces a high risk of serious or fatal
injuries from a deploying passenger air bag. Rear facing infant
seats should NEVER be placed in the front seats, unless the passenger
air bag is turned off. See
Passenger air bag ON/OFF switch.
How does the air bag supplemental restraint system work?
The air bag SRS is designed to
activate when the vehicle sustains
sufficient longitudinal deceleration.
Seating and safety restraints
95
TRACTION-LOK AXLE (IF EQUIPPED)
This axle provides added traction on slippery surfaces, particularly when
one wheel is on a poor traction surface. Under normal conditions, the
Traction-Lok axle functions like a standard rear axle.
Extended use of other than the manufacturer’s specified size tires on a
Traction-Lok rear axle could result in a permanent reduction in
effectiveness. This loss of effectiveness does not affect normal driving
and should not be noticeable to the driver.
To avoid injury, never run the engine with one wheel off the
ground, such as when changing a tire.
TRANSMISSION OPERATION
AUTOMATIC TRANSMISSION OPERATION (IF EQUIPPED)
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift from being moved from P (Park) unless the brake pedal is
depressed.
If you cannot move the gearshift out of P (Park) with the brake pedal
depressed:
1. Apply the parking brake, turn ignition key to LOCK, then remove the
key.
2. Insert the key and turn it to OFF. Apply the brake pedal and shift to N
(Neutral).
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift, it is
possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
If your vehicle gets stuck in mud or snow it may be rocked out by
shifting from forward and reverse gears, stopping between shifts, in a
steady pattern. Press lightly on the accelerator in each gear.
Driving
119
Snowplowing with your air bag equipped vehicle
Your vehicle is equipped with driver
and passenger (if equipped) air bag
Supplemental Restraint System
(SRS). The SRS is designed to
activate when the vehicle sustains
sufficient longitudinal deceleration.
Careless or high speed driving while plowing snow which results in
sufficient vehicle decelerations can deploy the air bag. Such driving also
increases the risk of accidents.
All occupants of the vehicle, including the driver, should always
properly wear their safety belts, even when an air bag SRS is
provided.
Never remove or defeat the “tripping mechanisms” designed into the
snow removal equipment by its manufacturer. Doing so may cause
damage to the vehicle and the snow removal equipment as well as
possible air bag deployment.
Do not attempt to service, repair, or modify the Air Bag
Supplemental Restraint System or its fuses. See your Ford or
Lincoln-Mercury dealer.
Driving
147
The fuel pump shut-off switch is
located in the passenger’s foot well,
behind the kick panel.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause
severe wire damage and could start a fire.
15
Roadside emergencies
150
Standard fuse amperage rating and color
COLOR
Fuse
Rating
Mini
Fuses
Standard
Fuses
Maxi
Fuses
Cartridge
Maxi
Fuses
Fuse Link
Cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Orange
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the panel cover to access the fuses.
To remove the fuse panel cover,
turn the panel fasteners
counterclockwise.
Roadside emergencies
151
To remove a fuse use the fuse puller
tool provided on the fuse panel
cover.
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Description
1
20A
Electronic Flasher
2
5A
Instrument Cluster, Powertrain Control
Module (PCM) Keep Alive Memory
3
20A
Cigar Lighter, OBDII
4
10A
Glove Box Lamp, Map Lamps, Power Mirrors,
Underhood Lamp
5
Not Used
FUSE1
RELAY
1
RELAY
3
(NOT
USED)
RELAY
4
RELAY
5
12
22
2
13
23
3
14
24
4
16
15
25
5
26
6
17
27
7
18
28
8
19
29
11
21
31
9
30
10
20
Roadside emergencies
152
Fuse/Relay
Location
Fuse Amp
Rating
Description
6
Not Used
7
5A
Power Window Lock Switch Illumination
8
5A
Radio, Headlamp Switch Illumination
9
Not Used
10
Not Used
11
10A
Washer Pump, Wiper Run/Park Relay Coil,
Wiper Hi/LO Relay Coil, Washer Pump Relay
Coil
12
15A
Horn
13
20A
Stop Lamps, Center High-mount Stop Lamp,
Trailer Tow Stop Lamp
14
10A
Dome Lamp, Cargo Lamp, Courtesy Lamps
15
5A
Generic Electronic Module (GEM),
Powertrain Control Module (PCM), Anti-lock
Brake System (ABS) Module, Brake Shift
Interlock, Speed Control
16
15A
Instrument Cluster, Hi-beam Headlamps
17
Not Used
18
Not Used
19
10A
Auxiliary Powertrain Control Module (APCM)
(Diesel only), Instrument Cluster, GEM
Module, Overdrive Cancel Switch, Idle
Validation Switch (Diesel only), Overhead
Console
20
15A
Starter Motor Relay Coil, PCM (Gasoline
only)
21
Not Used
22
10A
Air Bag Module, Passenger Air Bag Activation
Switch, Blower Motor Relay Coil
23
10A
Electronic Flasher
24
10A
Blend Door Actuator, Trailer Tow Battery
Charge Relay Coil
Roadside emergencies
153
Fuse/Relay
Location
Fuse Amp
Rating
Description
25
5A
4-Wheel Anti-Lock Brake System (4WABS)
Module
26
Not Used
27
10A
Ignition Run Power Feed (Customer Access)
28
10A
Brake Shift Interlock, DRL Relay Coil, Speed
Control Module, Backup Lamps, Trailer Tow
Backup Lamp Relay Coil, Electronic Shift On
The Fly Hub Lock Solenoid
29
5A
Instrument Cluster (Charge and Airbag
Warning Lamps)
30
30A
PCM Relay Coil, Ignition Coil (Gasoline only),
Fuel Heater (Diesel only), Wastegate
Solenoid (Diesel only), Injector Driver
Module Relay Coil (Diesel only)
31
Not Used
Relay 1
Interior Lamp Relay
Relay 2
Not Used
Relay 3
Horn
Relay 4
Power Window One Touch Down Relay
Relay 5
Accessory Delay Relay
Power distribution box
The power distribution box, trailer tow and electronic shift on the fly
relay blocks are located in the engine compartment near the brake
master cylinder.
The power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
Always replace the cover to the Power Distribution Box before
reconnecting the battery or refilling fluid reservoirs.
Roadside emergencies
154
The high-current fuses and relays are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Description
1
7.5A *
Trailer Tow Left Stop/Turn Lamp
2
10A*
Air Bag Module
3
7.5A*
Trailer Tow Right Stop/Turn Lamp
4
20A*
Trailer Tow Backup Lamps, Trailer
Tow Park Lamps
5
20A*
(Gasoline only)
5A*
(Diesel only)
Gasoline only-PCM, Two Speed Fuel
Pump Relay Coil, Fuel Pump Relay
Coil, Mass Air Flow Sensor, Fuel
Injectors
Diesel only-Dual Alternator
9
A
9
Field
19
29
18
28
30
31
32
33
34
35
37
36
17
27
16
26
15
25
14
24
13
11
12
9
10
7
8
5
6
3
4
1
2
23
22
21
20
Roadside emergencies
155
Fuse/Relay
Location
Fuse Amp
Rating
Description
6
- (Gasoline only)
10A*
(Diesel only)
Gasoline only-Not Used
Diesel only-Single or Dual Alternator
9
A
9
Field, Regulator
7
20A*
(Gasoline only)
5A*
(Diesel only)
Gasoline only-Vapor Managment Valve,
HEGO Sensors, Intake Manifold
Communication Control, EVR
Solenoid, PCM, Canister Vent Solenoid
Diesel only-Dual Alternator
9
A
9
Field
8
15A*
Trailer Tow Electronic Brake
Illumination, Park Lamps, Trailer Tow
Park Lamp Relay Coil
9
10A*
Left Headlamp
10
25A*
Power Point
11
10A*
Right Headlamp (Low Beam)
12
10A*
Daytime Running Lamps (DRL)
Resistor
13
30A**
Multi-function Switch, Headlamps
14
60A**
Anti-Lock Brake System
15
30A**
Windshield Wiper Motor
16
30A**
Trailer Tow Battery Charge
17
30A**
Electronic Shift On The Fly Relay,
Transfer Case Shift Motor
18
30A**
Power Seat
19
20A**
Fuel Pump Motor, PCM
20
50A**
Ignition Switch (B4 & B5)
21
50A**
Ignition Switch (B1 & B3)
22
50A**
Instrument Panel Junction Box
23
40A**
Blower Motor
24
30A**
Power Distribution Box
25
30A***
Power Windows
Roadside emergencies
156
Fuse/Relay
Location
Fuse Amp
Rating
Description
26
20A**
If equipped with Remote Keyless
Entry-Driver Door Unlock Relay Coil,
All Door Unlock Relay Coil, All Door
Lock Relay Coil, Park Lamp Flash
Relay, If not equipped with Remote
Keyless Entry-Power Door Lock
Motors
27
- (Gasoline only)
30A*
(Diesel only)
Gasoline only-Not Used
Diesel only-Injector Driver Module
28
30A**
Trailer Tow Electronic Brake
Controller
29
20A**
Radio
30
--
PCM Power Relay
31
--
Blower Motor Relay
32
--
Two Speed Fuel Pump Relay (Gasoline
only), Injector Driver Module Power
Relay (Diesel only)
33
--
Washer Pump Relay
34
--
Windshield Wiper Park/Run Relay
35
--
Windshield Wiper HI/LO Relay
36
--
Not Used
37
--
PCM Relay Diode
38
--
Trailer Tow Backup Lamp Relay
39
--
Trailer Tow Battery Charge Relay
40
--
Electronic Shift On The Fly Relay #1,
Electronic Shift On The Fly Relay #2
* Mini Fuses ** Maxi Fuses ***Circuit Breaker
Roadside emergencies
157