Ford F-150 - 2000 Fuse Box Diagram

Ford F-150 - 2000 Fuse Box Diagram

Always transport children 12 years old and under in the back
seat and always properly use appropriate child restraints.
National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 25 cm (10 inches)
between an occupant’s chest and the driver air bag module.
Never place your arm over the air bag module as a deploying air
bag can result in serious arm fractures or other injuries.
Steps you can take to properly position yourself away from the air bag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the Air Bag
Supplemental Restraint System or its fuses. See your Ford or
Lincoln Mercury dealer.
Children and air bags
For additional important safety information, read all information on
safety restraints in this guide.
Children must always be properly restrained. Failure to follow these
instructions may increase the risk of injury in a collision.
An infant in a rear-facing seat faces a high risk of serious or fatal
injuries from a deploying passenger air bag. Rear facing infant
seats should NEVER be placed in the front seats, unless the passenger
air bag is turned off. See
Passenger air bag ON/OFF switch.
Seating and safety restraints
114
Use extra caution while becoming familiar with your vehicle. Know the
capabilities and limitations of both you as a driver and your vehicle.
AUTOMATIC TRANSMISSION OPERATION (IF EQUIPPED)
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the ON position unless brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed:
1. Apply the parking brake, turn ignition key to LOCK, then remove the
key.
2. Insert the key and turn it to OFF. Apply the brake pedal and shift to N
(Neutral).
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
If your vehicle gets stuck in mud or snow it may be rocked out by
shifting from forward and reverse gears, stopping between shifts, in a
steady pattern. Press lightly on the accelerator in each gear.
Do not rock the vehicle if the engine is not at normal operating
temperature or damage to the transmission may occur.
Do not rock the vehicle for more than a few minutes or damage
to the transmission and tires may occur or the engine may
overheat.
Always set the parking brake fully and make sure the gearshift is
latched in P (Park). Turn off the ignition whenever you leave
your vehicle.
Driving
144
Removing snowplow
Read the following instructions before removing a snowplow:
After removing a snowplow from the vehicle, ensure the vehicle’s front
toe alignment and front ride height are within specification (reset if
required). These specifications are located in the vehicle’s Workshop
Manual. Adherence to the toe and ride height specification is
important for proper tire wear, ride, handling and headlight aim.
Snowplowing with your air bag equipped vehicle
Your vehicle is equipped with driver
and passenger air bags. The air bags
are designed to deploy in a collision
with a solid barrier at a range of 13
to 23 km/h (8 to 14 mph) or a
parked car at a range of 25 to 45
km/h (16 to 28 mph).
Careless or high speed driving while plowing snow which results in
vehicle decelerations equivalent to or greater than the air bag
deployment impact speeds listed above can deploy the air bag. Such
driving also increases the risk of accidents.
All occupants of the vehicle, including the driver, should always
properly wear their safety belts, even when an air bag SRS is
provided.
Never remove or defeat the “tripping mechanisms” designed into the
snow removal equipment by its manufacturer. Doing so may cause
damage to the vehicle and the snow removal equipment as well as
possible air bag deployment.
Do not attempt to service, repair, or modify the Air Bag
Supplemental Restraint System or its fuses. See your Ford or
Lincoln Mercury dealer.
Driving
173
The fuel pump shut-off switch is
located in the passenger’s foot well,
by the kick panel.
Use the following procedure to reset the fuel pump shut-off switch.
1. Turn the ignition to the OFF position.
2. Check the fuel system for leaks.
3. If no fuel leak is apparent, reset the fuel pump shut-off switch by
pushing in on the reset button.
4. Turn the ignition to the ON position. Pause for a few seconds and
return the key to the OFF position.
5. Make a further check for leaks in the fuel system.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
15
Roadside emergencies
177
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause
severe wire damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
Rating
Mini
Fuses
Standard
Fuses
Maxi
Fuses
Cartridge
Maxi
Fuses
Fuse Link
Cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Roadside emergencies
178
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the panel cover to access the fuses.
To remove a fuse use the fuse puller tool provided on the fuse panel
cover.
FUSE1
12
22
2
13
23
6
17
27
7
18
28
8
19
29
9
30
20
31
21
11
10
RELAY
5
RELAY
4
RELAY
3
RELAY
2
RELAY
1
3
14
24
4
15
25
5
16
26
Roadside emergencies
179
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
1
15A
Audio
2
5A
Powertrain Control Module (PCM),
Cluster
3
20A
Cigar Lighter, OBD-II Scan Tool
Connector
4
5A
Remote Entry Module, Mirrors
5
15A
Speed Control Module, Reverse
Lamp, Climate Mode Switch,
Daytime Running Lamp Relay
6
5A
Cluster, Brake Shift Interlock
Solenoid, GEM Module
7
Not Used
8
5A
Radio, Remote Entry Module, GEM
Module
9
Not Used
10
Not Used
11
30A
Front Washer Pump Relay, Wiper
Run/Park Relay, Wiper Hi/LO Relay,
Windshield Wiper Motor
12
Not Used
13
20A
Stop Lamp Switch (Lamps),
Turn/Hazard Flasher, Speed Control
Module
14
15A
Battery Saver Relay, Interior Lamp
Relay, Accessory Delay Relay (Power
Windows)
15
5A
Stop Lamp Switch, (Speed Control,
Brake Shift Interlock, ABS, PCM
Module Inputs), GEM Module, RABS
Test Connector
16
20A
Headlamps (Hi Beams), Cluster (Hi
Beam Indicator)
17
Not Used
Roadside emergencies
180
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
18
5A
Instrument Illumination (Dimmer
Switch Power)
19
Not Used
20
5A
Audio, GEM (or CTM) Module,
Powertrain Control Module (PCM),
21
15A
Starter Relay, Clutch Switch, Fuse 20
22
10A
Air Bag Module, Passenger Airbag
Deactivation Module, Climate Mode
Switch (Blower Relay)
23
10A
Trailer Tow Battery Charge Relay,
Turn/Hazard Flasher, 4x4 Solenoids,
4x4 Relays, Overhead Console, 4
Wheel Anti-Lock Brake System
(4WABS) Module
24
Not Used
25
Not Used
26
10A
Right Side Low Beam Headlamp
27
5A
Foglamp Relay and Foglamp
Indicator
28
10A
Left Side Low Beam Headlamp
29
5A
Autolamp Module, Transmission
Overdrive Control Switch
30
30A
Passive Anti Theft Transceiver,
Cluster, Ignition Coils, Powertrain
Control Module Relay
31
Not Used
Relay 1
Interior Lamp Relay
Relay 2
Battery Saver Relay
Relay 3
Not Used
Relay 4
One Touch Down Window Relay
Relay 5
ACC Delay Relay
Roadside emergencies
181
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
Always replace the cover to the Power Distribution Box before
reconnecting the battery or refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and care
chapter.
MAXI
FUSE
115
MAXI
FUSE
116
MAXI
FUSE
117
MAXI
FUSE
118
MAXI
FUSE
111
MAXI
FUSE
112
MAXI
FUSE
113
MAXI
FUSE
114
MAXI
FUSE
107
MAXI
FUSE
108
MAXI
FUSE
109
MAXI
FUSE
110
MAXI
FUSE
103
MAXI
FUSE
104
MAXI
FUSE
105
MAXI
FUSE
106
MAXI
FUSE
101
MAXI
FUSE
102
CB601
CB602
FUSE 17
FUSE 18
FUSE 21
FUSE 22
FUSE 19
FUSE 20
FUSE 23
FULL
RELAY 302
R 401
D 501
FUSE 24
FUSE 15
FUSE 16
FUSE 13
FUSE 14
FUSE 11
FUSE 12
FUSE 9
FUSE 10
FUSE 7
FUSE 8
FUSE 5
FUSE 6
FUSE 3
FUSE 4
FUSE 1
FUSE 2
D 503
D 502
FULL
RELAY 301
HALF
RELAY
207
FULL
RELAY 305
FULL
RELAY 306
FULL
RELAY 303
FULL
RELAY 304
HALF
RELAY
201
HALF
RELAY
202
HALF
RELAY 208
HALF
RELAY 209
HALF
RELAY 205
HALF
RELAY 206
HALF
RELAY
203
HALF
RELAY
204
Roadside emergencies
182
The high-current fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
1
20A *
Power Point
2
30A*
Powertrain Control Module
3
30A*
Headlamps/Autolamps
4
Not Used
5
20A*
Trailer Tow Backup/Park Lamps
6
15A*
Parklamps/Autolamps, Passenger
Fuse Panel Feed Fuse #18
7
20A*
Horn
8
15A*
Power Door Locks
9
15A*
Daytime Running Lamps (DRL), Fog
Lamps
10
20A*
Fuel Pump
11
20A*
Alternator Field
12
20A*
Rear Auxiliary Power Point
13
15A*
A/C Clutch
14
Not Used
15
Not Used
16
Not Used
17
Not Used
18
15A*
Powertrain Control Module, Fuel
Injectors, Fuel Pump Relay, Idle Air
Control, Mass Air Flow Sensor
19
10A*
Trailer Tow Stop and Right Turn
Lamp
20
10A*
Trailer Tow Stop and Left Turn
Lamp
21
Not Used
22
Not Used
23
15A*
HEGO Sensor, Canister Vent,
Automatic Transmission, CMS Sensor
24
Not Used
Roadside emergencies
183
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
101
30A**
Trailer Tow Battery Charge
102
50/20A**
Four Wheel Antilock Brake
Module/Rear Wheel Antilock Brake
Module
103
50A**
Junction Block Battery Feed
104
30A**
4x4 Shift Motor & Clutch
105
40A**
Climate Control Front Blower
106
20A**
Inter Cooler Pump (Lightning only)
107
Not Used
108
30A**
Trailer Tow Electric Brake
109
Not Used
110
30A**
Power Windows
111
40A**
Ignition Switch Battery Feed (Start
and Run Circuits)
112
30A**
Drivers Power Seat, Adjustable
Pedals
113
40A**
Ignition Switch Battery Feed (Run
and Accessory Circuits)
114
Not Used
115
20A**
Power Door Locks (SuperCrew only)
116
Not Used
117
Not Used
118
Not Used
201
Trailer Tow Park Lamp Relay
202
Front Wiper Run/Park Relay
203
Trailer Tow Backup Lamp Relay
204
A/C Clutch Relay
205
Horn Relay
206
Fog Lamp Relay
207
Front Washer Pump Relay
208
Inter Cooler Pump Relay (Lightning
only)
Roadside emergencies
184
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
209
Front Wiper Hi/Lo Relay
301
Fuel Pump Relay
302
Trailer Tow Battery Charge Relay
303
Not Used
304
Powertrain Control Module Relay
305
Fuel Pump Hi/Lo Relay (Lightning
only)
306
Inertia Switch Relay (Lightning only)
401
Not Used
501
Powertrain Control Module Diode
502
A/C Compressor Diode
503
Not Used
601
CB
Power Windows, Moonroof
(SuperCrew only)
602
Not Used
*Mini fuses **Maxi fuses
CHANGING THE TIRES
If you get a flat tire while driving, do not apply the brake heavily.
Instead, gradually decrease your speed. Hold the steering wheel firmly
and slowly move to a safe place on the side of the road.
Spare tire information
Your vehicle is equipped with a spare tire that may be used as a spare or
a regular tire. The spare tire wheel may not match the road wheel, and is
not equipped with wheel trim. The wheel trim from the wheel/tire may
be used on the spare if the wheels match.
If your vehicle is equipped with 4WD, a spare tire of a different
size than the road tires should not be used. Such a tire could
result in damage to driveline components and make the vehicle
difficult to control.
Roadside emergencies
185