Ford Explorer Sport Trac - 2009 Fuse Box Diagram

Ford Explorer Sport Trac - 2009 Fuse Box Diagram

AUXILIARY POWER POINTS (12VDC)
Power outlets are designed for accessory plugs only. Do not insert
any other object in the power outlet as this will damage the
outlet and blow the fuse. Do not hang any type of accessory or
accessory bracket from the plug. Improper use of the power
outlet can cause damage not covered by your warranty.
The auxiliary power points are
located on the front of the center
console, inside the utility
compartment, and on the rear of the
console (accessible from the rear
seats).
Do not use the power point for
operating the cigarette lighter
element (if equipped).
To prevent the fuse from being
blown, do not use the power point(s) over the vehicle capacity of
12 VDC/180W. If the power point or cigar lighter socket is not working, a
fuse may have blown. Refer to
Fuses and relays
in the
Roadside
Emergencies
chapter for information on checking and replacing fuses.
To have full capacity usage of your power point, the engine is required to
be running to avoid unintentional discharge of the battery. To prevent
the battery from being discharged:
do not use the power point longer than necessary when the engine is
not running,
do not leave battery chargers, video game adapters, computers and
other devices plugged in overnight or when the vehicle is parked for
extended periods.
Always keep the power point caps closed when not being used.
Cigar/Cigarette lighter (if equipped)
Do not plug optional electrical accessories into the cigarette lighter
socket.
Do not hold the lighter in with your hand while it is heating, this will
damage the lighter element and socket. The lighter will be released from
its heating position when it is ready to be used.
Note:
Improper use of the lighter can cause damage not covered by your
warranty, and can result in fire or serious injury.
2009 07+ Explorer Sport Trac
(esp)
Owners Guide, 1st Printing
USA
(fus)
Driver Controls
71
WARNING:
Never place your arm over the airbag module as a
deploying airbag can result in serious arm fractures or other
injuries.
To properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly one or two degrees from the upright position.
WARNING:
Do not put anything on or over the airbag module.
Placing objects on or over the airbag inflation area may cause
those objects to be propelled by the airbag into your face and torso
causing serious injury.
WARNING:
Do not attempt to service, repair, or modify the
airbag supplemental restraint systems or its fuses. Contact your
authorized dealer as soon as possible.
WARNING:
Modifications to the front end of the vehicle,
including frame, bumper, front end body structure and non-Ford
tow hooks may effect the performance of the airbag sensors increasing
the risk of injury. Do not modify the front end of the vehicle with
anything other than authorized Ford accessories for your vehicle.
WARNING:
Additional equipment may affect the performance of
the airbag sensors increasing the risk of injury. Please refer to
the
Body Builders Layout Book
for instructions about the appropriate
installation of additional equipment.
2009 07+ Explorer Sport Trac
(esp)
Owners Guide, 1st Printing
USA
(fus)
Seating and Safety Restraints
161
Determining if the system is operational
The SRS uses a readiness light in the instrument cluster or a tone to
indicate the condition of the system. Refer to
Airbag readiness
section
in the
Instrument Cluster
chapter. Routine maintenance of the airbag is
not required.
A difficulty with the system is indicated by one or more of the following:
The readiness light will either
flash or stay lit.
The readiness light will not
illuminate immediately after
ignition is turned on.
A series of five beeps will be heard. The tone pattern will repeat
periodically until the problem and/or light are repaired.
If any of these things happen, even intermittently, contact your
authorized dealer as soon as possible. Unless serviced, the system may
not function properly in the event of a collision.
Seat-mounted side airbag system
WARNING:
Do not place objects or mount equipment on or
near the airbag cover on the side of the seatbacks of the front
seats or in front seat areas that may come into contact with a
deploying airbag. Failure to follow these instructions may increase the
risk of personal injury in the event of a collision.
WARNING:
Do not use accessory seat covers. The use of
accessory seat covers may prevent the deployment of the side
airbags and increase the risk of injury in an accident.
WARNING:
Do not lean your head on the door. The side airbag
could injure you as it deploys from the side of the seatback.
WARNING:
Do not attempt to service, repair, or modify the
airbag SRS, its fuses or the seat cover on a seat containing an
airbag. Contact your authorized dealer as soon as possible.
2009 07+ Explorer Sport Trac
(esp)
Owners Guide, 1st Printing
USA
(fus)
Seating and Safety Restraints
169
WARNING:
Do not attempt to service, repair, or modify the
Safety Canopy
±
system, its fuses, the A, B, or C pillar trim, or
the headliner on a vehicle containing a Safety Canopy
±
. Contact your
authorized dealer as soon as possible.
WARNING:
All occupants of the vehicle including the driver
should always wear their safety belts even when an airbag SRS
and Safety Canopy
±
system is provided.
WARNING:
To reduce risk of injury, do not obstruct or place
objects in the deployment path of the inflatable Safety Canopy
±
.
How does the Safety Canopy
²
system work?
The design and development of the
Safety Canopy
±
system included
recommended testing procedures
that were developed by a group of
automotive safety experts known as
the Side Airbag Technical Working
Group. These recommended testing
procedures help reduce the risk of
injuries related to the deployment of
side airbags (including the Safety
Canopy
±
).
The Safety Canopy
±
system consists
of the following:
An inflatable nylon curtain with
an inflator concealed behind the
headliner and above the doors
(one on each side of the vehicle).
A headliner that will flex to open
above the side doors to allow Safety Canopy
±
deployment.
The same warning light, electronic control and diagnostic unit as used
for the front airbags.
2009 07+ Explorer Sport Trac
(esp)
Owners Guide, 1st Printing
USA
(fus)
Seating and Safety Restraints
172
If you cannot move the gearshift lever out of P (Park) with ignition in
the on position and the brake pedal depressed:
1. Apply the parking brake, turn ignition key to off, then remove the key.
2. Remove the rubber pad at the
bottom of the cup holder to locate
the access cap of the floor shifter
assembly.
3. Using a screwdriver (or
equivalent), remove the access
panel and depress the shifter lever
on the shift mechanism.
4. Apply the brake and shift into N
(Neutral).
5. Return the cover plug to the console access hole. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
Emergencies
chapter.
WARNING:
Do not drive your vehicle until you verify that the
brakelamps are working.
WARNING:
Always set the parking brake fully and make sure
the gearshift is latched in P (Park). Turn the ignition to the off
position and remove the key whenever you leave your vehicle.
WARNING:
If the parking brake is fully released, but the brake
warning lamp remains illuminated, the brakes may not be
working properly. See your authorized dealer.
2009 07+ Explorer Sport Trac
(esp)
Owners Guide, 1st Printing
USA
(fus)
Driving
246
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini fuses
Standard
fuses
Maxi fuses
Cartridge
maxi fuses
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
40A
Orange
Green
50A
Red
Red
60A
Blue
Yellow
70A
Tan
80A
Natural
15
2009 07+ Explorer Sport Trac
(esp)
Owners Guide, 1st Printing
USA
(fus)
Roadside Emergencies
269
Passenger compartment fuse panel
The fuse panel is located below the
instrument panel on the driver’s
side.
To remove a fuse use the fuse puller tool provided on the fuse panel box.
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
1
20A
Moon roof, Adjustable pedals
2
5A
Microcontroller power (SJB)
3
20A
Radio, Navigation amplifier
4
10A
OBD II connector
CB1
4
3
2
1
8
7
6
5
12
11
10
9
16
15
14
13
20
19
18
17
24
23
22
21
28
27
26
25
2009 07+ Explorer Sport Trac
(esp)
Owners Guide, 1st Printing
USA
(fus)
Roadside Emergencies
270
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
5
5A
Moonroof, Power down back
window, Door lock switch
illumination, Rearview mirror with
microphone
6
20A
Door unlock/lock
7
15A
Trailer tow stop/turn lamps
8
15A
Ignition switch power, PATS,
Cluster
9
2A
6-speed transmission/PCM
(Ignition RUN/START), Fuel
pump relay
10
5A
Front wiper RUN/ACC (relay in
PDB)
11
5A
Radio start
12
5A
Radio, Trailer tow battery charge
(relay in PDB)
13
15A
Heated mirror
14
20A
Horn
15
10A
Reverse lamps
16
10A
Trailer tow reverse lamps
17
10A
RCM (restraints), Passenger
occupancy
18
10A
IVD switch, IVD, 4x4 module, 4x4
switch, Heated seat switches,
Compass, Electrochromatic
mirror, Reverse park aid
19
Not used
20
10A
Manual climate control, DEATC,
Brake shift
21
Not used
22
15A
Brake switch, Stop lamps, Turn
lamps
2009 07+ Explorer Sport Trac
(esp)
Owners Guide, 1st Printing
USA
(fus)
Roadside Emergencies
271
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
23
15A
Interior lamps, Puddle lamps,
Cargo lamp, Battery saver,
Instrument illumination
24
10A
Instrument cluster, Theft LED
25
15A
Trailer tow park lamps
26
15A
License plate lamps, Rear park
lamps, Front park lamps, Manual
climate control
27
15A
Not used
28
10A
Manual/DEATC climate control
CB1
25A
Windows
The following relays are located on either side of the passenger
compartment fuse panel. See your authorized dealer for service of these
relays.
Fuse/Relay Location
Description
Relay 1
Delayed ACC
Power distribution box
The power distribution box is
located in the engine compartment.
The power distribution box contains
high-current fuses that protect your
vehicle’s main electrical systems
from overloads.
WARNING:
Always disconnect the battery before servicing high
current fuses.
WARNING:
To reduce risk of electrical shock, always replace
the cover to the Power Distribution Box before reconnecting the
battery or refilling fluid reservoirs.
2009 07+ Explorer Sport Trac
(esp)
Owners Guide, 1st Printing
USA
(fus)
Roadside Emergencies
272
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Specifications
chapter.
The high-current fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
1
50A**
BATT 2 (SJB)
2
50A**
BATT 3 (SJB)
3
50A**
BATT 1 (SJB)
4
30A**
Fuel pump, Fuel injectors
5
Not used
6
40A**
ABS pump
7
40A**
Powertrain Control Module
(PCM)
8
Not used
9
Not used
10
20A**
Power down back window
11
30A**
Starter
12
Not used
2009 07+ Explorer Sport Trac
(esp)
Owners Guide, 1st Printing
USA
(fus)
Roadside Emergencies
273
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
13
30A**
Trailer tow battery charge
14
40A **
Power drivers seat
15
40A**
Heated mirror
16
40A**
Blower motor
17
30A**
Trailer tow electronic brakes
18
Not used
19
Not used
20
30A**
Front wiper motor
21
20A*
Rear of console power point
22
20A*
Subwoofer
23
20A*
4x4 module
24
10A*
Powertrain Control Module
(PCM) Keep Alive Power,
Canister vent
25
20A*
Front of console power
point/Cigar lighter
26
20A*
4x4 module, AWD module
27
20A*
6–speed transmission control
module (TCM) (4.6L engine
only)
28
20A*
Heated seats
29
15A*
Right high/low beam headlamp
30
20A*
Cargo bed power point
31
15A*
Fog lamps
32
5A*
Power mirrors
33
30A*
ABS valves
34
15A*
Left high/low beam headlamp
35
10A*
AC clutch
36
20A*
Console bin power point
37
30A*
Driver window motor
38
15A*
5–speed transmission (4.0L
engine only)
2009 07+ Explorer Sport Trac
(esp)
Owners Guide, 1st Printing
USA
(fus)
Roadside Emergencies
274
Fuse/Relay
Location
Fuse Amp
Rating
Protected Circuits
39
15A*
PCM power
40
15A*
Fan clutch, PCV valve, AC clutch
relay
41
15A*
SDARS, DVD, SYNC
42
15A*
Speed control deactivation
switch, EVMV, MAFS, HEGO,
EVR, CMS, (VCT1, VCT2, CMCV
on 4.6L only)
43
15A*
Coil on plug (4.6L engine), Coil
tower (4.0L engine)
44
15A*
Fuel injectors
45B
Not used
45A
Not used
46B
Not used
46A
Not used
49
Fuel pump relay
50B
A/C clutch relay
50A
Fog lamps relay
51
Not used
52
Not used
53
One Touch Integrated Start
(OTIS) (diode)
54
Trailer tow battery charge relay
55B
Front wiper relay
55A
PCM relay
56B
Starter relay
56A
Climate control blower relay
* Mini Fuses ** Cartridge Fuses
2009 07+ Explorer Sport Trac
(esp)
Owners Guide, 1st Printing
USA
(fus)
Roadside Emergencies
275