Ford Explorer Sport - 2003 Fuse Box Diagram

Ford Explorer Sport - 2003 Fuse Box Diagram

AUXILIARY POWER POINT
The power point is an additional power source for electrical accessories.
NOTE:
Power outlets are designed for accessory plugs only. Do not hang
any type of accessory or accessory bracket from the plug. Improper use
of the power outlet can cause damage not covered by your warranty.
With a full console:
Without a full console:
The maximum current draw of any single power point should not exceed
it
s fuse rating, otherwise this will result in a blown fuse.
Do not use the the cigarette/cigar lighter element in any power point.
Keep power point caps closed when not in use.
Driver Controls
41
All occupants of the vehicle, including the driver, should always
properly wear their safety belts, even when an air bag (SRS) is
provided.
Always transport children 12 years old and under in the back
seat and always properly use appropriate child restraints.
National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 25 cm (10 inches)
between an occupant
s chest and the air bag module.
Never place your arm over the air bag module as a deploying air
bag can result in serious arm fractures or other injuries.
To properly position yourself away from the air bag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly one or two degrees from the upright position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the air bag
supplemental restraint systems or its fuses. See your Ford or
Lincoln Mercury dealer.
Modifying or adding equipment to the front end of the vehicle
(including frame, bumper, front end body structure and tow
hooks) may affect the performance of the air bag system, increasing
the risk of injury. Do not modify the front end of the vehicle.
Seating and Safety Restraints
80
A difficulty with the system is indicated by one or more of the following:
The readiness light will either
flash or stay lit.
The readiness light will not
illuminate immediately after
ignition is turned on.
A series of five beeps will be heard. The tone pattern will repeat
periodically until the problem and/or light are repaired.
If any of these things happen, even intermittently, have the SRS serviced
at your dealership or by a qualified technician immediately. Unless
serviced, the system may not function properly in the event of a
collision.
Side air bag system (if equipped)
Do not place objects or mount equipment on or near the air bag
cover on the side of the seatbacks of the front seats or in front
seat areas that may come into contact with a deploying air bag. Failure
to follow these instructions may increase the risk of personal injury in
the event of a collision.
Do not use accessory seat covers. The use of accessory seat
covers may prevent the deployment of the side air bags and
increase the risk of injury in an accident.
Do not lean your head on the door. The side air bag could injure
you as it deploys from the side of the seatback.
Do not attempt to service, repair, or modify the air bag SRS, its
fuses or the seat cover on a seat containing an air bag. See your
Ford or Lincoln Mercury dealer.
All occupants of the vehicle should always wear their safety belts
even when an air bag SRS is provided.
Seating and Safety Restraints
83
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed:
1. Apply the parking brake, turn ignition key to LOCK, then remove the
key.
2. Insert the key and turn it to OFF.
Apply the brake pedal and shift
to N (Neutral)
.
In the ignition OFF position, the automatic transmission shift
lever can be moved from the P (Park) position without the brake
pedal depressed. To avoid unwanted vehicle movement, always set the
parking brake.
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle
s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
Always set the parking brake fully and make sure the gearshift is
latched in P (Park). Turn the ignition to the LOCK position and
remove the key whenever you leave your vehicle.
If the parking brake is fully released, but the brake warning lamp
remains illuminated, the brakes may not be working properly.
See your dealer or a qualified service technician.
Driving
104
This switch is located in the front
passenger
s footwell, by the kick
panel access cover.
To reset the switch:
1. Turn the ignition OFF.
2. Check the fuel system for leaks.
3. If no leaks are apparent, reset the
switch by pushing in on the reset
button.
4. Turn the ignition ON.
5. Wait a few seconds and return
the key to OFF.
6. Make another check of leaks.
FUSES AND RELAYS
If electrical components are not
working, a fuse may have blown. If a
fuses is blown the wire in the fuse
will be broken.
Note:
Always replace a fuse with
one that has the specified amperage
rating.
Replacing a blown fuse with a fuse that has a higher amperage
can cause severe wire damage and could start a fire.
15
Roadside Emergencies
126
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is behind the end
cover at the left side of the
instrument panel. Pull the cover
outward to access the fuses.
To remove a fuse, use the tool on
the panel cover.
Roadside Emergencies
127
The fuses are:
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
1
5A
Mirrors, Autolamp
2
7.5A
Cluster, Autolamp. Generic
Electronic Module (GEM),
Keyless entry, 4x4
3
7.5A
Trailer tow right-hand stop/turn
lamps
4
7.5A
Starter
5
15A
Park lamps, Autolamps, I/P
dimming, Trailer tow
6
7.5A
Air bags, Cluster
7
7.5A
Trailer tow left-hand stop/turn
lamps
8
7.5A
Cluster, Audio, GEM
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
29
30
35
36
31
32
33
34
27
28
Roadside Emergencies
128
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
9
7.5A
Speed control, Anti-lock Brake
System (ABS), 4x4, Powertrain
Control Module (PCM), Park
interlock, Keyless entry
10
15A
Ignition, IPATS
11
15A
Subwoofer
12
15A
Climate control, Rear climate
control
13
15A
Stop lamps, Speed control,
Auxiliary Center High-Mounted
Stop Lamp (CHMSL)
14
10A
Air bags
15
15A
4x4 module
16
7.5A
Turn signals, Park interlock,
Overhead console, Climate
control, 4x4, Speed control
17
20A
Cigar lighter, On-Board
Diagnostics (OBD) II
18
20A
Power locks, Keyless entry
19
15A
Trailer tow park lamps
20
15A
Daytime Running Lamps (DRL),
Reverse lamps, PCM
21
20A
Heated seats
22
20A
I/P power point
23
10A
Front/Rear washers
24
30A
Front wiper
25
7.5A
Cluster, GEM
26
10A
Interior illumination, Battery saver
27
7.5A
Audio, Windows, GEM, Moonroof,
Rear window
28
15A
Rear wiper (on glass)
29
20A
Audio, Rear audio
Roadside Emergencies
129
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
30
25A
Seats
31
5A
Instrument panel dimming
(XLS)/Rear audio control (XLT)
32
Not used
33
15A
Highbeam headlamps
34
5A
Rear audio
35
5A
ABS module
36
Not used
Power distribution box
The power distribution box is in the
engine compartment. It contains
high-current fuses that protect the
main electrical systems from
overloads.
Note:
Always disconnect the
battery before servicing high-current
fuses.
Note:
Always replace the cover to
the power distribution box before
reconnecting the battery or refilling
fluid reservoirs.
If the battery has been disconnected
and reconnected, refer to the
Battery
section.
Roadside Emergencies
130
The high-current fuses are:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
1
50A Cartridge
fuse
Fuse Panel
2
Not Used
3
20A Cartridge
fuse
Moonroof
4
Not Used
5
Not Used
6
50A Cartridge
fuse
ABS Pump Motor
7
30A Cartridge
fuse
Powertrain Control
8
Not Used
9
Not Used
10
Not Used
11
50A Cartridge
fuse
Ignition Switch
Roadside Emergencies
131
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
12
Not Used
13
20A Cartridge
fuse
4X4 Motor
14
Not Used
15
Not Used
16
40A Cartridge
fuse
Blower Motor
17
30A Cartridge
fuse
Rear Defroster
18
Not Used
19
Not Used
20
Not Used
21
10A Mini fuse
PCM Memory
22
15A Mini fuse
Horn
23
20A Mini fuse
Fuel Pump Motor
24
25A Mini fuse
Headlamps
25
10A Mini fuse
A/C Clutch Solenoid
26
Not Used
27
20A Mini fuse
Rear power point
28
30A Mini fuse
4WABS Module
29
15A Mini fuse
Foglamps
30
Not Used
31
15A Mini fuse
Daytime Running Lamps
32
Not Used
33
Not Used
34
Not Used
35
Not Used
36
Not Used
37
Not Used
38
10A Mini fuse
Left Low Beam
39
Not Used
40
Not Used
Roadside Emergencies
132
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
41
15A Mini fuse
Heated Oxygen Sensors
42
10A Mini fuse
Right Low Beam
43
Not Used
44
2A Mini fuse
Speed Control
45A
Wiper Hi/Low Relay
45B
Wiper Run/Park Relay
46A
Not Used
46B
Rear Wiper Up Relay
47A
20A CB
Windows
47B
Not Used
48
Window Safety Relay
49
Starter Relay
50A
Not Used
50B
Fuel Pump Relay
51
Not Used
52
Not Used
53
PCM Diode
54
PCM Relay
55
Blower Relay
56A
Horn relay
56B
A/C clutch solenoid
CHANGING A FLAT TIRE
If you get a flat tire while driving:
do not brake heavily.
gradually decrease the vehicle’s speed.
hold the steering wheel firmly.
slowly move to a safe place on the side of the road.
The use of tire sealants is not recommended and may
compromise the integrity of your tires. The use of tire sealants
may also affect your tire pressure monitoring system (if equipped).
Roadside Emergencies
133
AUXILIARY POWER POINT
The power point is an additional power source for electrical accessories.
NOTE:
Power outlets are designed for accessory plugs only. Do not hang
any type of accessory or accessory bracket from the plug. Improper use
of the power outlet can cause damage not covered by your warranty.
With a full console:
Without a full console:
The maximum current draw of any single power point should not exceed
it
s fuse rating, otherwise this will result in a blown fuse.
Do not use the the cigarette/cigar lighter element in any power point.
Keep power point caps closed when not in use.
Driver Controls
43
To properly position yourself away from the air bag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly one or two degrees from the upright position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the air bag
supplemental restraint systems or its fuses. See your Ford or
Lincoln Mercury dealer.
Modifying or adding equipment to the front end of the vehicle
(including frame, bumper, front end body structure and tow
hooks) may affect the performance of the air bag system, increasing
the risk of injury. Do not modify the front end of the vehicle.
Children and air bags
Children must always be properly
restrained; accident statistics
suggest that children are safer when
properly restrained in the rear
seating positions than in the front
seating position. Failure to follow
these instructions may increase the
risk of injury in a collision.
Air bags can kill or injure a
child in a child seat.
NEVER
place a rear-facing child
seat in front of an active air bag. If
you must use a forward-facing
child seat in the front seat, move
the seat all the way back.
Seating and Safety Restraints
82
AUTOMATIC TRANSMISSION OPERATION (IF EQUIPPED)
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the ON position unless brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed:
1. Apply the parking brake, turn ignition key to LOCK, then remove the
key.
2. Insert the key and turn it to OFF.
Apply the brake pedal and shift
to N (Neutral)
.
When the key is in the ignition OFF position, the automatic
transmission shift lever can be moved from the P (Park) position
without the brake pedal depressed. To avoid unwanted vehicle
movement, always set the parking brake.
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle
s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
Always set the parking brake fully and make sure the gearshift is
latched in P (Park). Turn the ignition to the LOCK position and
remove the key whenever you leave your vehicle.
If the parking brake is fully released, but the brake warning lamp
remains illuminated, the brakes may not be working properly.
See your dealer or a qualified service technician.
Driving
103
This switch is located in the front
passenger
s footwell, by the kick
panel access cover.
To reset the switch:
1. Turn the ignition OFF.
2. Check the fuel system for leaks.
3. If no leaks are apparent, reset the
switch by pushing in on the reset
button.
4. Turn the ignition ON.
5. Wait a few seconds and return
the key to OFF.
6. Make another check of leaks.
FUSES AND RELAYS
If electrical components are not
working, a fuse may have blown. If a
fuses is blown the wire in the fuse
will be broken.
Note:
Always replace a fuse with
one that has the specified amperage
rating.
Replacing a blown fuse with a fuse that has a higher amperage
can cause severe wire damage and could start a fire.
15
Roadside Emergencies
125
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is behind the end
cover at the left side of the
instrument panel. Pull the cover
outward to access the fuses.
To remove a fuse, use the tool on
the panel cover.
Roadside Emergencies
126
The fuses are:
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
1
5A
Mirrors, Autolamp
2
7.5A
Cluster, Autolamp. Generic Electronic
Module (GEM), Keyless entry, 4x4
3
7.5A
Trailer tow right-hand stop/turn lamps
4
7.5A
Starter
5
15A
Park lamps, Autolamps, I/P dimming,
Trailer tow
6
7.5A
Air bags, Cluster
7
7.5A
Trailer tow left-hand stop/turn lamps
8
7.5A
Cluster, Audio, GEM
9
7.5A
Speed control, Anti-lock Brake System
(ABS), 4x4, Powertrain Control Module
(PCM), Park interlock, Keyless entry
10
15A
Ignition, IPATS
11
15A
Subwoofer
12
15A
Climate control, Rear climate control
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
29
30
35
36
31
32
33
34
27
28
Roadside Emergencies
127
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse Panel
Description
13
15A
Stop lamps, Speed control, Auxiliary
Center High-Mounted Stop Lamp
(CHMSL)
14
10A
Air bags
15
15A
4x4 module
16
7.5A
Turn signals, Park interlock, Overhead
console, Climate control, 4x4, Speed
control
17
20A
Cigar lighter, On-Board Diagnostics (OBD)
II
18
20A
Power locks, Keyless entry
19
15A
Trailer tow park lamps
20
15A
Daytime Running Lamps (DRL), Reverse
lamps, PCM
21
20A
Heated seats
22
20A
I/P power point
23
10A
Front/Rear washers
24
30A
Front wiper
25
7.5A
Cluster, GEM
26
10A
Interior illumination, Battery saver
27
7.5A
Audio, Windows, GEM, Moonroof, Rear
window
28
15A
Rear wiper (on glass)
29
20A
Audio, Rear audio
30
25A
Seats
31
5A
Instrument panel dimming (XLS)/Rear
audio control (XLT)
32
Not used
33
15A
Highbeam headlamps
34
5A
Rear audio
35
5A
ABS module
36
Not used
Roadside Emergencies
128
Power distribution box
The power distribution box is in the
engine compartment. It contains
high-current fuses that protect the
main electrical systems from
overloads.
Note:
Always disconnect the
battery before servicing high-current
fuses.
Note:
Always replace the cover to
the power distribution box before
reconnecting the battery or refilling
fluid reservoirs.
If the battery has been disconnected
and reconnected, refer to the
Battery
section.
Roadside Emergencies
129
The high-current fuses are:
Fuse/Relay
Location
Fuse Amp Rating
Power Distribution Box
Description
1
50A Cartridge fuse
Fuse Panel
2
Not Used
3
20A Cartridge fuse
Moonroof (if equipped)
4
Not Used
5
Not Used
6
50A Cartridge fuse
ABS Pump Motor
7
30A Cartridge fuse
Powertrain Control
8
Not Used
9
Not Used
10
Not Used
11
50A Cartridge fuse
Ignition Switch
12
Not Used
13
20A Cartridge fuse
4X4 Motor
14
Not Used
15
Not Used
16
40A Cartridge fuse
Blower Motor
17
30A Cartridge fuse
Rear Defroster
18
Not Used
19
Not Used
20
Not Used
21
10A Mini fuse
PCM Memory
22
15A Mini fuse
Horn
23
20A Mini fuse
Fuel Pump Motor
24
25A Mini fuse
Headlamps
25
10A Mini fuse
A/C Clutch Solenoid
26
Not Used
27
20A Mini fuse
Rear power point
28
30A Mini fuse
4WABS Module
29
15A Mini fuse
Foglamps
30
Not Used
Roadside Emergencies
130
Fuse/Relay
Location
Fuse Amp Rating
Power Distribution Box
Description
31
15A Mini fuse
Daytime Running Lamps
32
Not Used
33
Not Used
34
Not Used
35
Not Used
36
Not Used
37
Not Used
38
10A Mini fuse
Left Low Beam
39
Not Used
40
Not Used
41
15A Mini fuse
Heated Oxygen Sensors
42
10A Mini fuse
Right Low Beam
43
Not Used
44
2A
Speed control
45A
Wiper Hi/Low Relay
45B
Wiper Run/Park Relay
46A
Not Used
46B
Rear Wiper Up Relay
47A
20A CB
Windows
47B
Not Used
48
Window Safety Relay
49
Starter Relay
50A
Not Used
50B
Fuel Pump Relay
51
Not Used
52
Not Used
53
PCM Diode
54
PCM Relay
55
Blower Relay
56A
Horn relay
56B
A/C clutch solenoid
Roadside Emergencies
131
AUXILIARY POWER POINT
The power point is an additional power source for electrical accessories.
NOTE:
Power outlets are designed for accessory plugs only. Do not hang
any type of accessory or accessory bracket from the plug. Improper use
of the power outlet can cause damage not covered by your warranty.
With a full console:
Without a full console:
Do not plug optional electrical accessories into the cigarette lighter. Use
the power point.
Do not use the power point for operating the cigarette lighter element.
The Maximum power each power point can supply depends on the fuse
rating. For example: a 20A fuse should supply a maximum of 240 Watts.
Exceeding these limits will result in a blown fuse.
Always keep the power point caps closed when not being used.
Driver Controls
44
To properly position yourself away from the air bag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly one or two degrees from the upright position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the air bag
supplemental restraint systems or its fuses. See your Ford or
Lincoln Mercury dealer.
Modifying or adding equipment to the front end of the vehicle
(including frame, bumper, front end body structure and tow
hooks) may affect the performance of the air bag system, increasing
the risk of injury. Do not modify the front end of the vehicle.
Children and air bags
Children must always be properly
restrained; accident statistics
suggest that children are safer when
properly restrained in the rear
seating positions than in the front
seating position. Failure to follow
these instructions may increase the
risk of injury in a collision.
Air bags can kill or injure a
child in a child seat.
NEVER
place a rear-facing child
seat in front of an active air bag. If
you must use a forward-facing
child seat in the front seat, move
the seat all the way back.
Seating and Safety Restraints
83
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed:
1. Apply the parking brake, turn ignition key to LOCK, then remove the
key.
2. Insert the key and turn it to OFF.
Apply the brake pedal and shift
to N (Neutral)
.
When the key is in the ignition OFF position, the automatic
transmission shift lever can be moved from the P (Park) position
without the brake pedal depressed. To avoid unwanted vehicle
movement, always set the parking brake.
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle
s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
Always set the parking brake fully and make sure the gearshift is
latched in P (Park). Turn the ignition to the LOCK position and
remove the key whenever you leave your vehicle.
If the parking brake is fully released, but the brake warning lamp
remains illuminated, the brakes may not be working properly.
See your dealer or a qualified service technician.
Driving
104
This switch is located in the front
passenger
s footwell, by the kick
panel access cover.
To reset the switch:
1. Turn the ignition OFF.
2. Check the fuel system for leaks.
3. If no leaks are apparent, reset the
switch by pushing in on the reset
button.
4. Turn the ignition ON.
5. Wait a few seconds and return
the key to OFF.
6. Make another check of leaks.
FUSES AND RELAYS
If electrical components are not
working, a fuse may have blown. If a
fuses is blown the wire in the fuse
will be broken.
Note:
Always replace a fuse with
one that has the specified amperage
rating.
Replacing a blown fuse with a fuse that has a higher amperage
can cause severe wire damage and could start a fire.
15
Roadside Emergencies
126
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is behind the end
cover at the left side of the
instrument panel. Pull the cover
outward to access the fuses.
To remove a fuse, use the tool on
the panel cover.
Roadside Emergencies
127
The fuses are:
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
1
5A
Mirrors, Autolamp
2
7.5A
Cluster, Autolamp. Generic
Electronic Module (GEM),
Keyless entry, 4x4
3
7.5A
Trailer tow right-hand stop/turn
lamps
4
7.5A
Starter
5
15A
Park lamps, Autolamps, I/P
dimming, Trailer tow
6
7.5A
Air bags, Cluster
7
7.5A
Trailer tow left-hand stop/turn
lamps
8
7.5A
Cluster, Audio, GEM
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
29
30
35
36
31
32
33
34
27
28
Roadside Emergencies
128
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
9
7.5A
Speed control, Anti-lock Brake
System (ABS), 4x4, Powertrain
Control Module (PCM), Park
interlock, Keyless entry
10
15A
Ignition, IPATS
11
15A
Subwoofer
12
15A
Climate control, Rear climate
control
13
15A
Stop lamps, Speed control,
Auxiliary Center High-Mounted
Stop Lamp (CHMSL)
14
10A
Air bags
15
15A
4x4 module
16
7.5A
Turn signals, Park interlock,
Overhead console, Climate
control, 4x4, Speed control
17
20A
Cigar lighter, On-Board
Diagnostics (OBD) II
18
20A
Power locks, Keyless entry
19
15A
Trailer tow park lamps
20
15A
Daytime Running Lamps (DRL),
Reverse lamps, PCM
21
20A
Heated seats
22
20A
I/P power point
23
10A
Front/Rear washers
24
30A
Front wiper
25
7.5A
Cluster, GEM
26
10A
Interior illumination, Battery saver
27
7.5A
Audio, Windows, GEM, Moonroof,
Rear window
28
15A
Rear wiper (on glass)
29
20A
Audio, Rear audio
Roadside Emergencies
129
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
30
25A
Seats
31
5A
Instrument panel dimming
(XLS)/Rear audio control (XLT)
32
Not used
33
15A
Highbeam headlamps
34
5A
Rear audio
35
5A
ABS module
36
Not used
Power distribution box
The power distribution box is in the
engine compartment. It contains
high-current fuses that protect the
main electrical systems from
overloads.
Note:
Always disconnect the
battery before servicing high-current
fuses.
Note:
Always replace the cover to
the power distribution box before
reconnecting the battery or refilling
fluid reservoirs.
If the battery has been disconnected
and reconnected, refer to the
Battery
section.
Roadside Emergencies
130
The high-current fuses are:
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
1
50A Cartridge
fuse
Fuse Panel
2
Not Used
3
20A Cartridge
fuse
Moonroof (if equipped)
4
Not Used
5
Not Used
6
50A Cartridge
fuse
ABS Pump Motor
7
30A Cartridge
fuse
Powertrain Control
8
Not Used
9
Not Used
10
Not Used
11
50A Cartridge
fuse
Ignition Switch
Roadside Emergencies
131
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
12
Not Used
13
20A Cartridge
fuse
4X4 Motor
14
Not Used
15
Not Used
16
40A Cartridge
fuse
Blower Motor
17
30A Cartridge
fuse
Rear Defroster
18
Not Used
19
Not Used
20
Not Used
21
10A Mini fuse
PCM Memory
22
15A Mini fuse
Horn
23
20A Mini fuse
Fuel Pump Motor
24
25A Mini fuse
Headlamps
25
10A Mini fuse
A/C Clutch Solenoid
26
Not Used
27
Not used
28
30A Mini fuse
4WABS Module
29
15A Mini fuse
Foglamps
30
Not Used
31
15A Mini fuse
Daytime Running Lamps
32
Not Used
33
Not Used
34
Not Used
35
Not Used
36
Not Used
37
Not Used
38
10A Mini fuse
Left Low Beam
39
Not Used
Roadside Emergencies
132
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
40
Not Used
41
15A Mini fuse
Heated Oxygen Sensors
42
10A Mini fuse
Right Low Beam
43
Not Used
44
2A
Speed control
45A
Wiper Hi/Low Relay
45B
Wiper Run/Park Relay
46A
Not Used
46B
Rear Wiper Relay
47A
20A CB
Windows
47B
Not Used
48
Window Safety Relay
49
Starter Relay
50A
Not Used
50B
Fuel Pump Relay
51
Not Used
52
Not Used
53
PCM Diode
54
PCM Relay
55
Blower Relay
56A
Horn relay
56B
A/C clutch solenoid
CHANGING A FLAT TIRE
If you get a flat tire while driving:
do not brake heavily.
gradually decrease the vehicle
s speed.
hold the steering wheel firmly.
slowly move to a safe place on the side of the road.
The use of tire sealants is not recommended and may
compromise the integrity of your tires. The use of tire sealants
may also affect your tire pressure monitoring system (if equipped).
Roadside Emergencies
133