Ford Explorer - 2014 Fuse Box Diagram

Ford Explorer - 2014 Fuse Box Diagram

PRINCIPLES OF OPERATION
WARNING:
Airbags do not inflate slowly or gently, and the risk
of injury from a deploying airbag is the greatest close to the trim
covering the airbag module.
WARNING:
All occupants of your vehicle, including the driver,
should always properly wear their safety belts, even when an
airbag supplemental restraint system is provided. Failure to properly
wear your safety belt could seriously increase the risk of injury or
death.
WARNING:
Airbags can kill or injure a child in a child seat.
Always transport children 12 years old and under in the back
seat and always properly use appropriate child restraints.
WARNING:
Never place your arm over the airbag module, as a
deploying airbag can result in serious arm fractures or other
injuries.
WARNING:
Airbags can kill or injure a child in a child seat.
Never place a rear-facing child seat in front of an active airbag. If
you must use a forward-facing child seat in the front seat, move the
seat upon which the child seat is installed all the way back.
WARNING:
Do not attempt to service, repair, or modify the
airbag supplemental restraint systems or its fuses as you could be
seriously injured or killed. Contact your authorized dealer as soon as
possible.
WARNING:
Several airbag system components get hot after
inflation. Do not touch them after inflation as this may result in
serious injury.
Supplementary Restraints System
49
2014 Explorer
(exp)
Owners Guide gf, 1st Printing, April 2013
USA
(fus)
WARNING:
Do not attempt to service, repair, or modify the
airbag, its fuses or the seat cover on a seat containing an airbag,
as you could be seriously injured or killed. Contact your authorized
dealer as soon as possible.
WARNING:
If the side airbag has deployed, the airbag will not
function again. The side airbag system (including the seat) must
be inspected and serviced by an authorized dealer. If the airbag is not
replaced, the unrepaired area will increase the risk of injury in a crash.
The side airbags are located on the outboard side of the seat backs of
the front seats. In certain sideways crashes, the airbag on the side
affected by the crash will be inflated. The airbag was designed to inflate
between the door panel and occupant to further enhance the protection
provided occupants in side impact crashes.
The system consists of the
following:
a tag on the seat back indicating
that side airbags are found on
your vehicle
side airbags located inside the
seat back of the driver and front
passenger seats.
crash sensors and monitoring system with readiness
indicator. See
Crash Sensors and Airbag Indicator
later in
this chapter.
front passenger sensing system.
Note:
The passenger sensing system will deactivate the passenger
seat-mounted side airbag if it detects an empty passenger seat.
The design and development of the side airbag system included
recommended testing procedures that were developed by a group of
automotive safety experts known as the Side Airbag Technical Working
Group. These recommended testing procedures help reduce the risk of
injuries related to the deployment of side airbags.
56
Supplementary Restraints System
2014 Explorer
(exp)
Owners Guide gf, 1st Printing, April 2013
USA
(fus)
SAFETY CANOPY® CURTAIN AIRBAGS
WARNING:
Do not place objects or mount equipment on or near
the headliner at the siderail that may come into contact with a
deploying curtain airbag. Failure to follow these instructions may
increase the risk of personal injury in the event of a crash.
WARNING:
Do not lean your head on the door. The curtain
airbag could injure you as it deploys from the headliner.
WARNING:
Do not attempt to service, repair, or modify the
curtain airbags, its fuses, the A, B, C or D pillar trim, or the
headliner on a vehicle containing curtain airbags, as you could be
seriously injured or killed. Contact your authorized dealer as soon as
possible.
WARNING:
All occupants of your vehicle including the driver
should always wear their safety belts even when an airbag
supplemental restraint system and curtain airbag is provided. Failure to
properly wear your safety belt could seriously increase the risk of injury
or death.
WARNING:
To reduce risk of injury, do not obstruct or place
objects in the deployment path of the curtain airbag.
WARNING:
If the curtain airbags have deployed, the curtain
airbags will not function again. The curtain airbags (including the
A, B, C or D pillar trim and headliner) must be inspected and serviced
by an authorized dealer. If the curtain airbag is not replaced, the
unrepaired area will increase the risk of injury in a crash.
Supplementary Restraints System
57
2014 Explorer
(exp)
Owners Guide gf, 1st Printing, April 2013
USA
(fus)
AUXILIARY POWER POINTS
WARNING:
Do not plug optional electrical accessories into the
cigarette lighter socket (if equipped). Improper use of the lighter
can cause damage not covered by your warranty, and can result in fire
or serious injury.
Note:
If used when the engine is not running, the battery will discharge.
There may be insufficient power to restart your engine.
Note:
Do not insert objects other than an accessory plug into the power
point. This will damage the outlet and blow the fuse.
Note:
Do not hang any type of accessory or accessory bracket from the
plug.
Note:
Do not use the power point over the vehicle capacity of 12 volts
DC180 watts or a fuse may blow.
Note:
Do not use the power point for operating a cigarette lighter
element.
Note:
Improper use of the power outlet can cause damage not covered
by your warranty.
Note:
Always keep the power point caps closed when not being used.
Run the engine for full capacity use of the power point . To prevent the
battery from being discharged:
Do not use the power point longer than necessary when the engine is
not running.
Do not leave devices plugged in overnight or when the vehicle is
parked for extended periods.
Locations
Power points may be found:
on the front of the center console
inside the utility compartment
on the rear of the console, accessible from the rear seats
in the cargo area.
Auxiliary Power Points
183
2014 Explorer
(exp)
Owners Guide gf, 1st Printing, April 2013
USA
(fus)
TOWING A TRAILER
WARNING:
Do not exceed the GVWR or the GAWR specified on
the certification label.
WARNING:
Towing trailers beyond the maximum recommended
gross trailer weight exceeds the limit of your vehicle and could
result in engine damage, transmission damage, structural damage, loss
of vehicle control, vehicle rollover and personal injury.
Note:
For information on electrical items such as fuses or relays, see the
Fuses
chapter.
Your vehicle’s load capacity designation is by weight, not by volume, so
you cannot necessarily use all available space when loading a vehicle.
Towing a trailer places an extra load on your vehicle’s engine,
transmission, axle, brakes, tires and suspension. Inspect these
components periodically during, and after, any towing operation.
Load Placement
To help minimize how trailer movement affects your vehicle when
driving:
Load the heaviest items closest to the trailer floor.
Load the heaviest items centered between the left and right side
trailer tires.
Load the heaviest items above the trailer axles or just slightly forward
toward the trailer tongue. Do not allow the final trailer tongue weight
to go above or below 10–15% of the loaded trailer weight.
Select a tow bar with the correct rise or drop. When both the loaded
vehicle and trailer are connected, the trailer frame should be level, or
slightly angled down toward your vehicle, when viewed from the side.
When driving with a trailer or payload, a slight takeoff vibration or
shudder may be present due to the increased payload weight. You can
find more information about proper trailer loading and setting your
vehicle up for towing under
Load limit
in the
Load Carrying
chapter
and in the
RV & Trailer Towing Guide,
available at an authorized
dealer.
Towing
275
2014 Explorer
(exp)
Owners Guide gf, 1st Printing, April 2013
USA
(fus)
CHANGING A FUSE
Fuses
WARNING:
Always replace a fuse with one that has the
specified amperage rating. Using a fuse with a higher amperage
rating can cause severe wire damage and could start a fire.
If electrical components in your
vehicle are not working, a fuse may
have blown. Blown fuses are identified
by a broken wire within the fuse.
Check the appropriate fuses before
replacing any electrical components.
Standard Fuse Amperage Rating and Color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
Yellow
70A
Tan
Brown
80A
Natural
Black
Black
15
302
Fuses
2014 Explorer
(exp)
Owners Guide gf, 1st Printing, April 2013
USA
(fus)
FUSE SPECIFICATION CHART
Power Distribution Box
WARNING:
Always disconnect the battery before servicing high
current fuses.
WARNING:
To reduce risk of electrical shock, always replace the
cover to the power distribution box before reconnecting the
battery or refilling fluid reservoirs.
The power distribution box is located in the engine compartment. It has
high-current fuses that protect your vehicle’s main electrical systems
from overloads.
If the battery has been disconnected and reconnected, see
Changing the
Vehicle Battery
in the
Maintenance
chapter.
The high-current fuses are coded as follows:
Fuse or relay
number
Fuse amp
rating
Protected components
1
Not used
2
Not used
3
30A**
Trailer brake control module
97
98
77
96
95
94
93 92 91 90 89
88
66
44
78
56
39
26
18
16
17
3
1
2
4
5
6
7
8
9
19
20
21
22
23
24
27
28
29
30
31
40
41
42
43
55
57
58
59
60
61
62
63
64
65
79
80
81
82
83
84
85
86
87
67
45
32
10
11
12
13
33
34
35
46
47
48
49
50
51
68
69
70
71
72
74
73
76
75
53
37
36
54
38
25
15
14
52
Fuses
303
2014 Explorer
(exp)
Owners Guide gf, 1st Printing, April 2013
USA
(fus)
Fuse or relay
number
Fuse amp
rating
Protected components
4
30A**
Wipers, Front washer
5
50A**
Anti-lock brake system pump
6
Not used
7
30A**
Power liftgate
8
20A**
Moonroof
9
20A**
Power point #2 (console rear)
10
3rd row rear seat release relay
11
Rear window defroster relay
12
Trailer tow battery charge relay
13
Starter motor relay
14
Engine cooling fan #2 high speed
relay
15
Fuel pump relay
16
Not used
17
40A**
110-volt AC power point
18
40A**
Front blower motor
19
30A**
Starter motor
20
20A**
Power point #1, cigar lighter
21
20A**
Power point #3 (cargo area)
22
30A**
Third row seat module
23
30A**
Driver power seat, Memory
module
24
30A**
Trailer tow battery charge
25
Not used
26
40A**
Rear window defroster, Heated
mirrors
27
20A**
Power point (console)
28
30A**
Climate controlled seats
29
40A**
Engine cooling fan #1 high speed
power, Engine cooling fan #1 and
#2 low speed primary fuse
304
Fuses
2014 Explorer
(exp)
Owners Guide gf, 1st Printing, April 2013
USA
(fus)
Fuse or relay
number
Fuse amp
rating
Protected components
30
40A**
Engine cooling fan #2 high speed
fuse
31
25A**
Engine cooling fan #1 and #2 low
speed secondary fuse
32
Auxiliary blower motor relay
33
Engine cooling fan #1 and #2 low
speed relay #2
34
Blower motor relay
35
Engine cooling fan #1 high speed
relay, Engine cooling fan #1 and
#2 low speed relay #1
36
Not used
37
Trailer tow right stop/turn lamps
relay
38
Trailer tow backup relay
39
40A**
Auxiliary blower motor
40
Not used
41
30A**
Second row heated seats
42
30A**
Passenger seat
43
40A**
Anti-lock brake system valves
44
Rear washer relay
45
5A*
Rain sensor
46
Not used
47
Not used
48
Not used
49
Not used
50
15A*
Heated mirrors
51
Not used
52
Not used
53
Trailer tow left stop/turn lamps
relay
54
Not used
Fuses
305
2014 Explorer
(exp)
Owners Guide gf, 1st Printing, April 2013
USA
(fus)
Fuse or relay
number
Fuse amp
rating
Protected components
55
Wiper relay
56
15A*
Transmission control module
57
20A*
Left high-intensity discharge
headlamps
58
10A*
Alternator sensor
59
10A*
Brake on/off switch
60
10A*
Trailer tow back-up lamps
61
20A*
Second row seat release
62
10A*
Air conditioning clutch
63
15A*
Trailer tow stop/turn lamps
64
15A*
Rear wipers
65
30A*
Fuel pump
66
Powertrain control module relay
67
20A*
Vehicle power #2 (emission
related powertrain components)
68
20A*
Vehicle power #4 (ignition coils)
69
20A*
Vehicle power #1 (powertrain
control module)
70
10A*
Vehicle power #3 (coil),
All-wheel drive module, Air
conditioning variable compressor
control
71
Not used
72
Not used
73
Not used
74
Not used
75
Not used
76
Not used
77
Trailer tow park lamps relay
78
20A*
Right high-intensity discharge
headlamps
79
5A*
Adaptive cruise control
306
Fuses
2014 Explorer
(exp)
Owners Guide gf, 1st Printing, April 2013
USA
(fus)
Fuse or relay
number
Fuse amp
rating
Protected components
80
Not used
81
Not used
82
15A*
Rear washer
83
Not used
84
20A*
Trailer tow park lamps
85
Not used
86
7.5A*
Powertrain control module
keep-alive power, Powertrain
control module relay, Canister
vent solenoid
87
5A*
Run/start relay coil
88
Run/start relay
89
5A*
Front blower relay coil,
Electronic power assist steering
module
90
10A*
Powertrain control module,
Transmission control module,
Engine control module (2.0L
engine)
91
10A*
Adaptive cruise control
92
10A*
Anti-lock brake system module,
Plant EVAC and fill
93
5A*
Rear blower motor, Rear
defroster, Trailer tow battery
charge relays
94
30A**
Passenger compartment fuse
panel run/start
95
Not used
96
Not used
97
Not used
98
Air conditioning clutch relay
*Mini Fuses **Cartridge Fuses
Fuses
307
2014 Explorer
(exp)
Owners Guide gf, 1st Printing, April 2013
USA
(fus)
Passenger Compartment Fuse Panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the panel cover to access the fuses.
To remove a fuse use the fuse puller tool provided on the fuse panel
cover.
The fuses are coded as follows:
Fuse or relay
number
Fuse amp
rating
Protected components
1
30A
One-touch up and down driver
front window
2
15A
Not used (spare)
3
30A
One-touch up and down
passenger front window
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
33
41
42
43
44
45
34
35
36
37
23
24
25
26
27
28
38
46
39
47
29
32
40
31
30
48
49
308
Fuses
2014 Explorer
(exp)
Owners Guide gf, 1st Printing, April 2013
USA
(fus)
Fuse or relay
number
Fuse amp
rating
Protected components
4
10A
Interior demand lamps (overhead
console, second row, cargo),
Glove box lamp, Second and third
row seat release, Visor lamps
5
20A
Amplifier
6
5A
Not used (spare)
7
7.5A
Memory seat module logic feed
8
10A
Not used (spare)
9
10A
4-inch radio display, Power
liftgate logic, Electronic finish
panel, SYNC
10
10A
Run/accessory relay (wipers, rear
washer), Rain sensor
11
10A
Instrument cluster, Heads-up
display
12
15A
Interior courtesy lamps (overhead
console, Second row, cargo),
Puddle lamps, Console bin LED,
Backlighting
13
15A
Right turn lamps, Right trailer tow
turn/stop lamps
14
15A
Left turn lamps, Left trailer tow
turn/stop lamps
15
15A
Reverse lamps, Stop lamps,
High-mounted stop lamp
16
10A
Low beam headlamps (right)
17
10A
Low beam headlamps (left)
18
10A
Keypad illumination, Brake shift
interlock, Start button run
indicator, Passive anti-theft
system, Powertrain control
module wake-up, Rear seat power
enable
Fuses
309
2014 Explorer
(exp)
Owners Guide gf, 1st Printing, April 2013
USA
(fus)
Fuse or relay
number
Fuse amp
rating
Protected components
19
20A
Memory seat power
20
20A
Locks
21
10A
Intelligent access, Keypad
22
20A
Horn relay
23
15A
Steering wheel control module,
Intelligent access, Headlamp
switch
24
15A
Datalink connector, Steering
wheel control module
25
15A
Liftgate release
26
5A
Radio frequency module
27
20A
Intelligent access module
28
15A
Ignition switch, Push-button start
switch
29
20A
Radio, Global positioning system
module
30
15A
Front park lamps
31
5A
Trailer tow brake controller
32
15A
110-volt AC power point, Power
folding mirror, Power mirrors,
One-touch up and down front
windows, Door lock illumination,
Memory switch illumination
33
10A
Occupant classification sensor
34
10A
Blind spot monitor, Rearview
camera, Reverse sensing system,
Lane departure warning module,
Second row heated seats module
310
Fuses
2014 Explorer
(exp)
Owners Guide gf, 1st Printing, April 2013
USA
(fus)
Fuse or relay
number
Fuse amp
rating
Protected components
35
5A
Heads-up display, Climate control
humidity sensor, Terrain
management system, Hill descent
switch, Headlamp switch ignition
sensor
36
10A
Heated steering wheel
37
10A
Restraints control module
38
10A
Auto-dimming rearview mirror,
Moonroof
39
15A
High beam headlamp shutters
40
10A
Rear park lamps, License plate
lamps, Trailer tow park lamps
41
7.5A
Overdrive cancel, Tow/haul
42
5A
Not used (spare)
43
10A
Not used (spare)
44
10A
Not used (spare)
45
5A
Not used (spare)
46
10A
Climate control module
47
15A
Fog lamps, left and right turn
signal mirror feed
48
30A Circuit
Breaker
Rear power windows, Passenger
power window, One-touch down
(driver side only), Driver window
switch
49
Delayed
accessory relay
Body control module
Fuses
311
2014 Explorer
(exp)
Owners Guide gf, 1st Printing, April 2013
USA
(fus)