Ford Expedition - 1999 Fuse Box Diagram

Ford Expedition - 1999 Fuse Box Diagram

Steps you can take to properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the Air Bag
Supplemental Restraint System or its fuses. See your Ford or
Lincoln-Mercury dealer.
Children and air bags
For additional important safety
information, read all information on
safety restraints in this guide.
Children must always be properly
restrained. Accident statistics
suggest that children are safer when
properly restrained in the rear
seating positions than in the front
seating position. Failure to follow
these instructions may increase the
risk of injury in a collision.
Air bags can kill or injure a
child in a child seat.
NEVER
place a rear-facing child
seat in front of an active air bag. If
you must use a forward-facing
child seat in the front seat, move
the seat all the way back.
Seating and safety restraints
90
To avoid injury, never run the engine with one wheel off the
ground, such as when changing a tire.
TRANSMISSION OPERATION
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift from being moved from P (Park) unless the brake pedal is
depressed.
If you cannot move the gearshift out of P (Park) with the brake pedal
depressed:
1. Apply the parking brake, turn ignition key to LOCK, then remove the
key.
2. Insert the key and turn it to OFF. Apply the brake pedal and shift to N
(Neutral).
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift, it is
possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
If your vehicle gets stuck in mud or snow it may be rocked out by
shifting from forward and reverse gears, stopping between shifts, in a
steady pattern. Press lightly on the accelerator in each gear.
Do not rock the vehicle for more than a few minutes. The
transmission and tires may be damaged or the engine may
overheat.
Always set the parking brake fully and make sure the gearshift is
latched in P (Park). Turn off the ignition whenever you leave
your vehicle.
Driving
111
The fuel pump shut-off switch is
located in the passenger’s foot well,
behind the kick panel.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause
severe wire damage and could start a fire.
15
Roadside emergencies
129
Standard fuse amperage rating and color
COLOR
Fuse
Rating
Mini
Fuses
Standard
Fuses
Maxi
Fuses
Cartridge
Maxi
Fuses
Fuse Link
Cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the panel cover to access the fuses.
To remove a fuse use the fuse puller tool provided on the fuse panel
cover.
Roadside emergencies
130
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Description
1
25A
Audio
2
5A
Overhead Trip Computer, Electronic
Automatic Temperature Control (EATC),
Powertrain Control Module (PCM), Cluster
3
20A
Cigar Lighter, OBD-II Scan Tool Connector
4
15A
Autolamp Module, Remote Entry Module,
Mirrors, Air Suspension Switch
5
15A
AC Clutch Relay, Speed Control Module,
Reverse Lamp, EVO Module, Climate Mode
Switch (Front Blower Relay), Daytime
Running Lamp Relay
6
5A
Cluster, Overhead Trip Computer, Compass,
Brake Shift Interlock Solenoid, Air
Suspension Module, GEM Module, EVO
Steering Sensor
FUSE1
12
22
2
13
23
6
17
27
7
18
28
8
19
29
9
30
20
31
21
11
10
RELAY
5
RELAY
4
RELAY
3
RELAY
2
RELAY
1
3
14
24
4
15
25
5
16
26
Roadside emergencies
131
Fuse/Relay
Location
Fuse Amp
Rating
Description
7
5A
Aux A/C Blower Relay, Console Blower
8
5A
Radio, Remote Entry Module, GEM Module
9
Not Used
10
Not Used
11
30A
Front Washer Pump Relay, Wiper Run/Park
Relay, Wiper Hi/LO Relay, Windshield Wiper
Motor, Rear Washer Pump Relay
12
Not Used
13
20A
Stop Lamp Switch (Lamps), Turn/Hazard
Flasher, Speed Control Module
14
15A
Rear Wipers, Running Board Lamps,
Battery Saver Relay, Interior Lamp Relay,
Accessory Delay Relay (Power Windows)
15
5A
Stop Lamp Switch, (Speed Control, Brake
Shift Interlock, ABS, PCM Module Inputs),
GEM Module
16
20A
Headlamps (Hi Beams), Cluster (Hi Beam
Indicator)
17
10A
Heated Mirrors, Heated Grid Switch
Indicator
18
5A
Instrument Illumination (Dimmer Switch
Power)
19
Not Used
20
5A
Audio, Four Wheel Air Suspension (4WAS)
Module, GEM Module
21
15A
Starter Relay, Fuse 20
22
10A
Air Bag Module
23
10A
Aux A/C, Heated Seats, Trailer Tow Battery
Charge, Turn/Hazard Flasher, Console
Blower Door Actuator
24
10A
Climate Mode Switch (Blower Relay),
EATC (via fuse 7), EATC Blower Relay
25
5A
4 Wheel Anti-Lock Brake System (4WABS)
Module
Roadside emergencies
132
Fuse/Relay
Location
Fuse Amp
Rating
Description
26
10A
Right Side Low Beam Headlamp
27
5A
Foglamp Relay and Foglamp Indicator
28
10A
Left Side Low Beam Headlamp
29
5A
Autolamp Module, Transmission Overdrive
Control Switch
30
30A
Passive Anti Theft Transceiver, Cluster,
Ignition Coils, Powertrain Control Module
Relay
31
10A
Rear Integrated Control Panel (Audio), CD
Player
Relay 1
Interior Lamp Relay
Relay 2
Battery Saver Relay
Relay 3
Rear Window Defroster Relay
Relay 4
One Touch Down Window Relay
Relay 5
ACC Delay Relay
Power distribution box
The power distribution box is
located in the engine compartment.
The power distribution box contains
high-current fuses that protect your
vehicle’s main electrical systems
from overloads.
Always disconnect the battery before servicing high current
fuses.
Always replace the cover to the Power Distribution Box before
reconnecting the battery or refilling fluid reservoirs.
Roadside emergencies
133
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Care
chapter.
The high-current fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Description
1
25A *
Power Point
2
30A*
Powertrain Control Module
3
30A*
Headlamps/Autolamps
4
25A*
Console Powerpoint
5
20A*
Trailer Tow Backup/Park Lamps
6
15A*
Parklamps/Autolamps
7
20A*
Horn
8
30A*
Power Door Locks
9
15A*
Daytime Running Lamps (DRL), Fog Lamps
10
20A*
Fuel Pump
11
20A*
Alternator Field
MAXI
FUSE
115
MAXI
FUSE
116
MAXI
FUSE
117
MAXI
FUSE
118
MAXI
FUSE
111
MAXI
FUSE
112
MAXI
FUSE
113
MAXI
FUSE
114
MAXI
FUSE
107
MAXI
FUSE
108
MAXI
FUSE
109
MAXI
FUSE
110
MAXI
FUSE
103
MAXI
FUSE
104
MAXI
FUSE
105
MAXI
FUSE
106
MAXI
FUSE
101
MAXI
FUSE
102
CB601
CB602
FUSE 17
FUSE 18
FUSE 21
FUSE 22
FUSE 19
FUSE 20
FUSE 23
FULL
RELAY 302
R 401
D 501
FUSE 24
FUSE 15
FUSE 16
FUSE 13
FUSE 14
FUSE 11
FUSE 12
FUSE 9
FUSE 10
FUSE 7
FUSE 8
FUSE 5
FUSE 6
FUSE 3
FUSE 4
FUSE 1
FUSE 2
D 503
D 502
FULL
RELAY 301
HALF
RELAY
207
FULL
RELAY 303
FULL
RELAY 304
HALF
RELAY
201
HALF
RELAY
202
HALF
RELAY 208
HALF
RELAY 209
HALF
RELAY 205
HALF
RELAY 206
HALF
RELAY
203
HALF
RELAY
204
HALF
RELAY
212
HALF
RELAY
210
HALF
RELAY
213
HALF
RELAY
211
Roadside emergencies
134
Fuse/Relay
Location
Fuse Amp
Rating
Description
12
10A*
Rear Wipers
13
Not Used
14
Not Used
15
10A*
Running Board Lamps
16
Not Used
17
Not Used
18
15A*
Powertrain Control Module, Fuel Injectors,
Fuel Pump, Mass Air Flow Sensor
19
10A*
Trailer Tow Stop and Right Turn Lamp
20
10A*
Trailer Tow Stop and Left Turn Lamp
21
Not Used
22
Not Used
23
15A*
Powertrain Control Module, HEGO Sensors,
Canister Vent
24
15A*
Powertrain C ontrol Module, Automatic
Transmission, CMS Sensor
101
30A**
Trailer Tow Battery Charge
102
50A**
Four Wheel Antilock Brake Module
103
50A**
Junction Block Battery Feed
104
30A**
4x4 Shift Motor & Clutch
105
40A**
Climate Control Front Blower
106
Not Used
107
Not Used
108
30A**
Trailer Tow Electric Brake
109
50A**
Air Suspension Compressor
110
30A**
Moonroof, Flip Windows and Heated Seats
111
50A**
Ignition Switch Battery Feed (Start Circuit)
112
30A**
Drivers Power Seat, Adjustable Pedals
113
50A**
Ignition Switch Battery Feed (Run and
Accessory Circuits)
114
30A**
Climate Control Auxiliary Blower
115
Not Used
Roadside emergencies
135
Fuse/Relay
Location
Fuse Amp
Rating
Description
116
40A**
Rear Window Defroster, Heated Mirrors
117
Not Used
118
Not Used
201
Trailer Tow Park Lamp Relay
202
Front Wiper Run/Park Relay
203
Trailer Tow Backup Lamp Relay
204
A/C Clutch Relay
205
Horn Relay
206
Foglamp Relay
207
Front Washer Pump Relay
208
Rear Washer Pump Relay
209
Front Wiper Hi/Lo Relay
210
Not Used
211
Not Used
212
Rear Wiper Up Relay
213
Rear Wiper Down Relay
301
Fuel Pump Relay
302
Trailer Tow Battery Charge Relay
303
Not Used
304
Powertrain Control Module Relay
401
Not Used
501
Powertrain Control Module Diode
502
A/C Clutch Diode
503
Not Used
601
30A
Delayed Accessory (Power Windows, Flip
Windows, Moonroof)
602
Not Used
*Mini fuses **Maxi fuses
Relays
Relays are located in the power distribution box and should be replaced
by qualified technicians.
Roadside emergencies
136