Ford Escort - 2002 Fuse Box Diagram

Ford Escort - 2002 Fuse Box Diagram

Always transport children 12 years old and under in the back
seat and always properly use appropriate child restraints.
National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 25 cm (10 inches)
between an occupant’s chest and the driver air bag module.
Never place your arm over the air bag module as a deploying air
bag can result in serious arm fractures or other injuries.
Steps you can take to properly position yourself away from the air bag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the air bag
supplemental restraint systems or its fuses. See your Ford or
Lincoln Mercury dealer.
Modifications to the front end of the vehicle, including frame,
bumper, front end body structure and tow hooks may affect the
performance of the air bag sensors increasing the risk of injury. Do not
modify the front end of the vehicle.
Seating and Safety Restraints
86
3. Push and hold the thumb button.
4. Move the gearshift lever.
If it is necessary to use the above
procedure to move the gearshift
lever, it is possible that a fuse has
blown and the vehicle’s brakelamps
may not be operating properly.
Refer to
Fuses and relays
in the
Roadside emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
If your vehicle gets stuck in mud or snow it may be rocked out by
shifting from forward and reverse gears, stopping between shifts, in a
steady pattern. Press lightly on the accelerator in each gear.
Do not rock the vehicle for more than a few minutes. The
transaxle and tires may be damaged or the engine may overheat.
Always set the parking brake fully and make sure the gearshift
lever is latched in P (Park). Turn off the ignition whenever you
leave your vehicle.
If the parking brake is fully released, but the brake warning lamp
remains illuminated, the brakes may not be working properly.
See your dealer or a qualified service technician.
Understanding gearshift positions
Hold the brake pedal down while you move the gearshift lever
from P (Park) to another position. If you do not hold the brake
pedal down, your vehicle may move unexpectedly and injure someone.
P
R
N
D
D
L
Driving
106
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Note:
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause severe wire
damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
rating
Mini
fuses
Standard
fuses
Maxi
fuses
Cartridge
maxi
fuses
Fuse link
cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
15
Roadside Emergencies
121
Passenger compartment fuse panel
Coupe
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
DRL
10A
Daytime Running Lamps
HAZARD
15A
Hazard Flasher
ROOM
10A
Engine Controls, RAP System,
Radio, Shift Lock, Courtesy
Lamps, Starting System, Warning
Chime, Instrument Cluster
ENGINE
15A
Electronic Automatic Transaxle,
Ignition System, Constant Control
Relay Module (PCM Relay)
RADIO
5A
Power Mirrors, Radio, RAP
System
DOOR LOCK
30A
Power Door Locks
HORN
15A
Horn, Shift Lock
AIR COND
15A
A/C-Heater, ABS
(DRL)
(DOOR LK)
STOP
HAZARD
HORN
TAIL
ROOM
(AIR COND)
(SUN ROOF)
ENGINE
METER
(ASC)
RADIO
WIPER
P. Window (C.B.)
(FOG)
CIGAR
(AUDIO)
AIR BAG
FUEL INJ
HEATER
Roadside Emergencies
122
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
METER
10A
Backup Lamps, Engine Coolant
Level Switch, Instrument Cluster,
Rear Window Defrost, Shift Lock,
Warning Chime, Turn Signal
Switch
WIPER
20A
Wiper/Washer, Blower Motor Relay
STOP
20A
Stop Lamps, Brake Pressure
Switch
TAIL
15A
Exterior Lamps, Instrument
Illumination
SUN ROOF
15A
Power Moonroof
ASC
10A
Speed Control
P. WINDOW
30A CB
Power Windows
CIGAR
20A
Cigar Lighter
AIR BAG
10A
Air Bags
FOG
10A
Fog Lamps, Daytime Running
Lamps (DRL)
AUDIO
15A
Premium Sound Amplifier, CD
Changer
FUEL INJ.
10A
H02S, Evaporative Emission
Purge Flow Sensor
BLOWER
30A CB
Blower Motor Relay
Roadside Emergencies
123
Sedan
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
R.WIPER
10A
Daytime Running Lamps, Liftgate
Wiper/Washer
HAZARD
15A
Hazard Flasher, Engine Controls
ROOM
10A
Remote Anti-Theft Personality
(RAP) Module, Radio, Shift Lock,
Courtesy Lamps, Starting System,
Warning Chime
ENGINE
15A
Air Bag, Engine Controls, TR
Sensor
MIRROR
5A
Power Mirrors, Radio, Remote
Keyless Entry (RKE)
DOOR LOCK
30A
Power Door Locks
HORN
15A
Horn
AIR COND
15A
A/C-Heater, ABS
R. WIPER
(DOOR LK)
STOP
HAZARD
HORN
TAIL
ROOM
(AIR COND)
SUNROOF
ENGINE
METER
(ASC)
MIRROR
WIPER
P. Window (C.B.)
(FOG)
CIGAR
(AUDIO)
AIR BAG
FUEL INJ
HEATER
Roadside Emergencies
124
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment Fuse
Panel Description
METER
10A
Backup Lamps, Engine Controls,
Instrument Cluster, Rear Window
Defrost, Shift Lock, Warning
Chime, Turn Signal Switch
WIPER
20A
Wiper/Washer, Blower Relay
STOP
15A
Stop Lamps
TAIL
15A
Exterior Lamps, Instrument
Illumination
SUN ROOF
15A
Power Moonroof
ASC
10A
Speed Control
CIGAR
20A
Cigar Lighter
AIR BAG
10A
Joint Connector, Air Bag
Diagnostic Monitor
FOG
10A
Fog Lamps, Daytime Running
Lamps (DRL)
AUDIO
15A
Radio
FUEL
INJECTOR
10A
HO2S, Evaporative Emission
Purge Flow Sensor
P. WINDOW
30A CB
Power Windows
BLOWER
30A CB
A/C-Heater
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
Always replace the cover to the power distribution box before
reconnecting the battery or refilling fluid reservoirs
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and specifications
chapter.
Roadside Emergencies
125
Coupe
The high-current fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
FUEL INJ.
30A*
Air Bags, Constant Control Relay
Module (PCM Relay), Generator
DEFOG
30A*
Rear Window Defrost
MAIN
100A*
Overall Circuit Protection
BTN
40A*
Hazard, Stop, Door Lock, Tail,
Room and Horn Fuses of the I/P
Fuse Panel
ABS
60A*
ABS Main Relay
COOLING FAN
40A*
Constant Control Relay Module
(Cooling Fan)
OBD-II
10A*
Data Link Connector (DLC),
Instrument Cluster
FUEL PUMP
20A**
Constant Control Relay Module
(Fuel Pump)
HEAD RH
10A**
Headlamps
HEAD LH
10A**
Headlamps
* Fuse Link Cartridge **Fuse
USE THE DESIGNATED FUSES ONLY
FUEL INJ
30A
DEFOG
30A
MAIN
100A
COOLING FAN
40A
(ABS)
60A
BTN
40A
HEADLAMP
RELAY
FUEL PUMP 20A
OBD-II 10A
HEAD RH 10A
HEAD LH 10A
Roadside Emergencies
126
Sedan
The high-current fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box
Description
FUEL INJ.
30A*
Air Bags, Engine Controls,
Generator
DEFOG
30A*
Rear Window Defrost
MAIN
100A*
Charging System, BTN, Cooling
Fan, Fuel Pump, OBD-II, ABS
Fuses, Ignition Switch, Headlamps
BTN
40A*
Hazard
ABS
60A*
ABS Main Relay
COOLING FAN
40A*
Constant Control Relay Module
OBD-II
10A**
Data Link Connector (DLC),
Instrument Cluster
FUEL PUMP
20A**
Engine Controls
HEAD RH
10A**
Headlamps
HEAD LH
10A**
Headlamps
* Fuse Link Cartridge ** Fuse
USE THE DESIGNATED FUSES ONLY
FUEL INJ
30A
DEFOG
30A
MAIN
100A
COOLING FAN
40A
(ABS)
60A
BTN
40A
HEADLAMP
RELAY
FUEL PUMP 20A
OBD-II 10A
HEAD RH 10A
HEAD LH 10A
Roadside Emergencies
127