Ford Escort - 1999 Fuse Box Diagram

Ford Escort - 1999 Fuse Box Diagram

National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 25 cm
(ten [10] inches) between an occupant’s chest and the driver air bag
module.
Never place your arm over the air bag module as a deploying air
bag can result in serious arm fractures or other injuries.
Steps you can take to properly position yourself away from the airbag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the Air Bag
Supplemental Restraint System or its fuses. See your Ford or
Lincoln-Mercury dealer.
Seating and safety restraints
72
1. Continue depressing the brake
pedal, and remove the shift-lock
override cap with a 2.5 cm (1 inch)
or longer screwdriver.
2. Insert the screwdriver into the
shift-lock override opening and push
down.
3. Push and hold the thumb button.
4. Move the gearshift.
If it is necessary to use the above
procedure to move the gearshift, it
is possible that a fuse has blown and
the vehicle’s brakelamps may not be
operating properly. Refer to
Fuses
and relays
in the
Roadside
emergencies
chapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
If your vehicle gets stuck in mud or snow it may be rocked out by
shifting from forward and reverse gears, stopping between shifts, in a
steady pattern. Press lightly on the accelerator in each gear.
Do not rock the vehicle for more than a few minutes. The
transaxle and tires may be damaged or the engine may overheat.
P
R
N
D
D
L
P
R
N
D
D
L
Driving
96
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause
severe wire damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
Rating
Mini
Fuses
Standard
Fuses
Maxi
Fuses
Cartridge
Maxi
Fuses
Fuse Link
Cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
15
Roadside emergencies
107
Coupe
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Description
DRL
10A
Daytime Running Lamps
HAZARD
15A
Hazard Flasher
ROOM
10A
Engine Controls, RAP System, Radio, Shift
Lock, Courtesy Lamps, Starting System,
Warning Chime, Instrument Cluster
ENGINE
15A
Electronic Automatic Transaxle, Ignition
System, Constant Control Relay Module
(PCM Relay)
RADIO
5A
Power Mirrors, Radio, RAP System
DOOR LOCK
30A
Power Door Locks
HORN
15A
Horn, Shift Lock
AIR COND
15A
A/C-Heater, ABS
METER
10A
Backup Lamps, Engine Coolant Level Switch,
Instrument Cluster, Rear Window Defrost,
Shift Lock, Warning Chime, Turn Signal Switch
WIPER
20A
Wiper/Washer, Blower Motor Relay
STOP
20A
Stop Lamps, Brake Pressure Switch
TAIL
15A
Exterior Lamps, Instrument Illumination
(DRL)
(DOOR LK)
STOP
HAZARD
HORN
TAIL
ROOM
(AIR COND)
(SUN ROOF)
ENGINE
METER
(ASC)
RADIO
WIPER
P. Window (C.B.)
(FOG)
CIGAR
(AUDIO)
AIR BAG
FUEL INJ
HEATER
Roadside emergencies
108
Fuse/Relay
Location
Fuse Amp
Rating
Description
SUN ROOF
15A
Power Moonroof
ASC
10A
Speed Control
P. WINDOW
30A CB
Power Windows
CIGAR
20A
Cigar Lighter
AIR BAG
10A
Air Bags
FOG
10A
Fog Lamps, Daytime Running Lamps (DRL)
AUDIO
15A
Premium Sound Amplifier, CD Changer
FUEL INJ.
10A
H02S, Evaporative Emission Purge Flow
Sensor
BLOWER
30A CB
Blower Motor Relay
Sedan/Wagon
The fuses are coded as follows:
Fuse/Relay
Location
Fuse Amp
Rating
Description
R.WIPER
10A
Daytime Running Lamps, Liftgate
Wiper/Washer
HAZARD
15A
Hazard Lamps
R. WIPER
(DOOR LK)
STOP
HAZARD
HORN
TAIL
ROOM
(AIR COND)
SUNROOF
ENGINE
METER
(ASC)
MIRROR
WIPER
P. Window (C.B.)
(FOG)
CIGAR
(AUDIO)
AIR BAG
FUEL INJ
HEATER
Roadside emergencies
109
Fuse/Relay
Location
Fuse Amp
Rating
Description
ROOM
10A
Engine Controls, Remote Anti-Theft
Personality (RAP) Module, Radio, Shift
Lock, Courtesy Lamps, Starting System,
Warning Chime
ENGINE
15A
Air Bag, Engine Controls, TR Sensor
MIRROR
5A
Power Mirrors, Radio, Remote Keyless
Entry (RKE)
DOOR
LOCK
30A
Power Door Locks
HORN
15A
Horn
AIR COND
15A
A/C-Heater, ABS
METER
10A
Backup Lamps, Engine Controls,
Instrument Cluster, Rear Window Defrost,
Shift Lock, Warning Chime, Turn Signal
Switch
WIPER
20A
Wiper/Washer, Blower Relay
STOP
15A
Stop Lamps
TAIL
15A
Exterior Lamps, Instrument Illumination
SUN ROOF
15A
Power Moonroof
ASC
10A
Speed Control
CIGAR
20A
Cigar Lighter
AIR BAG
10A
Joint Connector, Air Bag Diagnostic
Monitor
FOG
10A
Fog Lamps, Daytime Running Lamps (DRL)
AUDIO
15A
Radio
FUEL
INJECTOR
10A
HO2S, Evaporative Emission Purge Flow
Sensor
P. WINDOW
30A CB
Power Windows
BLOWER
30A CB
A/C-Heater
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
Roadside emergencies
110
Always disconnect the battery before servicing high current
fuses.
Always replace the cover to the Power Distribution Box before
reconnecting the battery or refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and Care
chapter.
Coupe
The high-current fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Description
FUEL INJ.
30A*
Air Bags, Constant Control Relay Module
(PCM Relay), Generator
DEFOG
30A*
Rear Window Defrost
MAIN
100A*
Overall Circuit Protection
BTN
40A*
Hazard, Stop, Door Lock, Tail, Room and
Horn Fuses of the I/P Fuse Panel
ABS
60A*
ABS Main Relay
COOLING
FAN
40A*
Constant Control Relay Module (Cooling
Fan)
USE THE DESIGNATED FUSES ONLY
FUEL INJ
30A
DEFOG
30A
MAIN
100A
COOLING FAN
40A
(ABS)
60A
BTN
40A
HEADLAMP
RELAY
FUEL PUMP 20A
OBD-II 10A
HEAD RH 10A
HEAD LH 10A
Roadside emergencies
111
Fuse/Relay
Location
Fuse Amp
Rating
Description
OBD-II
10A*
Data Link Connector (DLC), Instrument
Cluster
FUEL
PUMP
20A**
Constant Control Relay Module (Fuel
Pump)
HEAD RH
10A**
Headlamps
HEAD LH
10A**
Headlamps
* Fuse Link Cartridge **Fuse
Sedan/Wagon
The high-current fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Description
FUEL INJ.
30A*
Air Bags, Engine Controls, Generator
DEFOG
30A*
Rear Window Defrost
MAIN
100A*
Charging System, BTN, Cooling Fan, Fuel
Pump, OBD-II, ABS Fuses, Ignition Switch,
Headlamps
BTN
40A*
Hazard
ABS
60A*
ABS Main Relay
USE THE DESIGNATED FUSES ONLY
FUEL INJ
30A
DEFOG
30A
MAIN
100A
COOLING FAN
40A
(ABS)
60A
BTN
40A
HEADLAMP
RELAY
FUEL PUMP 20A
OBD-II 10A
HEAD RH 10A
HEAD LH 10A
Roadside emergencies
112
Fuse/Relay
Location
Fuse Amp
Rating
Description
COOLING
FAN
40A*
Constant Control Relay Module
OBD-II
10A**
Data Link Connector (DLC), Instrument
Cluster
FUEL
PUMP
20A**
Engine Controls
HEAD RH
10A**
Headlamps
HEAD LH
10A**
Headlamps
* Fuse Link Cartridge ** Fuse
Relays
Relays are located in the power distribution box and should be replaced
by qualified technicians.
CHANGING THE TIRES
If you get a flat tire while driving, do not apply the brake heavily.
Instead, gradually decrease your speed. Hold the steering wheel firmly
and slowly move to a safe place on the side of the road.
Temporary spare tire information
The temporary spare tire for your vehicle is labeled as such. It is smaller
than a regular tire and is designed for emergency use only.
If you use the temporary spare tire continuously or do not follow
these precautions, the tire could fail, causing you to lose control
of the vehicle, possibly injuring yourself or others.
When driving with the temporary spare tire
do not:
exceed 80 km/h (50 mph) under any circumstances
load the vehicle beyond maximum vehicle load rating listed on the
Safety Compliance Label
tow a trailer
use tire chains
drive through an automatic car wash, because of the vehicle’s reduced
ground clearance
Roadside emergencies
113