Ford E-350 - 2000 Fuse Box Diagram

Ford E-350 - 2000 Fuse Box Diagram

Always transport children 12 years old and under in the back
seat and always properly use appropriate child restraints.
National Highway Traffic Safety Administration (NHTSA)
recommends a minimum distance of at least 25 cm (10 inches)
between an occupant’s chest and the driver air bag module.
Never place your arm over the air bag module as a deploying air
bag can result in serious arm fractures or other injuries.
Steps you can take to properly position yourself away from the air bag:
Move your seat to the rear as far as you can while still reaching the
pedals comfortably.
Recline the seat slightly (one or two degrees) from the upright
position.
Do not put anything on or over the air bag module. Placing
objects on or over the air bag inflation area may cause those
objects to be propelled by the air bag into your face and torso causing
serious injury.
Do not attempt to service, repair, or modify the Air Bag
Supplemental Restraint System or its fuses. See your Ford or
Lincoln-Mercury dealer.
Seating and safety restraints
89
Vehicles with a higher center of gravity such as utility and
four-wheel drive vehicles handle differently than vehicles with a
lower center of gravity. Utility and four-wheel drive vehicles are
not
designed for cornering at speeds as high as passenger cars any more
than low-slung sports cars are designed to perform satisfactorily under
off-road conditions. Avoid sharp turns, excessive speed and abrupt
maneuvers in these vehicles. Failure to drive cautiously could result in
an increased risk of vehicle rollover, personal injury and death.
Loaded vehicles, with a higher center of gravity, may handle
differently than unloaded vehicles. Extra precautions, such as
slower speeds and increased stopping distance, should be taken when
driving a heavily loaded vehicle.
Your vehicle has the capability to haul more cargo and people than most
passenger cars. Depending upon the type and placement of the load,
hauling people and cargo may raise the center of gravity of the vehicle.
Use extra caution while becoming familiar with your vehicle. Know the
capabilities and limitations of both you as a driver and your vehicle.
AUTOMATIC TRANSMISSION OPERATION
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the ON position unless brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed:
1. Apply the parking brake, turn ignition key to LOCK, then remove the
key.
2. Insert the key and turn it to OFF. Apply the brake pedal and shift to N
(Neutral).
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer to
Fuses and relays
in the
Roadside
emergencies
chapter.
Driving
114
For commercial stripped chassis
vehicles, the fuel pump shut-off
switch is located on a bracket above
the brake pedal.
Use the following procedure to reset the fuel pump shut-off switch.
1. Turn the ignition to the OFF position.
2. Check the fuel system for leaks.
3. If no fuel leak is apparent, reset the fuel pump shut-off switch by
pushing in on the reset button.
4. Turn the ignition to the ON position. Pause for a few seconds and
return the key to the OFF position.
5. Make a further check for leaks in the fuel system.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire within
the fuse. Check the appropriate
fuses before replacing any electrical
components.
15
Roadside emergencies
130
Always replace a fuse with one that has the specified amperage
rating. Using a fuse with a higher amperage rating can cause
severe wire damage and could start a fire.
Standard fuse amperage rating and color
COLOR
Fuse
Rating
Mini
Fuses
Standard
Fuses
Maxi
Fuses
Cartridge
Maxi
Fuses
Fuse Link
Cartridge
2A
Grey
Grey
3A
Violet
Violet
4A
Pink
Pink
5A
Tan
Tan
7.5A
Brown
Brown
10A
Red
Red
15A
Blue
Blue
20A
Yellow
Yellow
Yellow
Blue
Blue
25A
Natural
Natural
30A
Green
Green
Green
Pink
Pink
40A
Orange
Green
Green
50A
Red
Red
Red
60A
Blue
Yellow
70A
Tan
Brown
80A
Natural
Black
Passenger compartment fuse panel
The fuse panel is located below and to the left of the steering wheel by
the brake pedal. Remove the panel cover to access the fuses.
To remove a fuse use the fuse puller tool provided on the fuse panel
cover.
Roadside emergencies
131
The fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment
Fuse Panel Description
1
20A
4WABS Module
2
15A
Brake Warning Diode/Resistor, Instrument
Cluster, Warning Chime, 4WABS Relay,
Warning Indicators
3
15A
Main Light Switch, RKE Module, Radio
4
15A
Power Locks w/RKE, Illuminated Entry,
Warning Chime, Modified Vehicle, Power
Mirrors, Main Light Switch, Courtesy Lamps
5
20A
RKE Module, Power Lock Switches,
Memory Lock, Power Locks with RKE
6
10A
Shift Interlock, Speed Control, DRL Module
7
10A
Multi-Function Switch, Turn Signals
1
2
3
4
5
7
6
8
9
10
11
42
43
44
13
12
14
15
16
17
19
18
20
21
22
23
25
24
26
27
28
29
31
30
32
33
34
35
37
36
38
39
40
41
Roadside emergencies
132
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment
Fuse Panel Description
8
30A
Radio Capacitor(s), Ignition Coil, PCM
Diode, PCM Power Relay, Fuel Heater,
Glow Plug Relay (Diesel Only)
9
30A
Wiper Control Module, Windshield Wiper
Motor
10
20A
Main Light Switch, (External Lamps)
Multi-Function Switch (Flash-to-pass)
11
15A
Brake Pressure Switch, Multi-Function
Switch (Hazards), RABS, Brake Pedal
Position Switch
12
15A
Transmission Range (TR) Sensor, Auxiliary
Battery Relay
13
15A
Blend Door Actuator, Function Selector
Switch
14
5A
Instrument Cluster (Air Bag and Charge
Indicator)
15
5A
Trailer Battery Charge Relay
16
30A
Power Seats
17
Not Used
18
Not Used
19
10A
Air Bag Diagnostic Monitor
20
5A
Overdrive Cancel Switch
21
30A
Power Windows*
22
15A
Memory Power Radio
23
20A
Cigar Lighter, Data Link Connector (DLC)
24
Not Used
25
10A
Left Headlamp (Low Beam)
26
Not Used
27
5A
Radio
28
20A
Power Plug
29
Not Used
30
15A
Headlamps (High Beam Indicator), DRL10A
31
10A
Right Headlamp (Low Beam), DRL
Roadside emergencies
133
Fuse/Relay
Location
Fuse Amp
Rating
Passenger Compartment
Fuse Panel Description
32
5A
Power Mirrors
33
Not Used
34
10A
Transmission Range (TR) Sensor
35
30A
RKE Module
36
5A
(Cluster, A/C, Illumination, Radio), Steering
Column Assembly
37
Not Used
38
10A
Air Bag Diagnostic Monitor
39
Not Used
40
30A
Modified Vehicle
41
30A
Modified Vehicle
42
Not Used
43
20A C.B.
Power Windows*
44
Not Used
* Either Fuse 21 or Circuit breaker 43 will be present for power
windows.
Power distribution box
The power distribution box is located in the engine compartment. The
power distribution box contains high-current fuses that protect your
vehicle’s main electrical systems from overloads.
Always disconnect the battery before servicing high current
fuses.
Always replace the cover to the Power Distribution Box before
reconnecting the battery or refilling fluid reservoirs.
If the battery has been disconnected and reconnected, refer to the
Battery
section of the
Maintenance and care
chapter.
Roadside emergencies
134
The high-current fuses are coded as follows.
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
1
Not Used
2
Not Used
3
Not Used
4
10A*
PCM Keep Alive Memory, Instrument
Cluster
5
10A*
Right Trailer Turn Signal
6
10A*
Left Trailer Turn Signal
7
Not Used
8
60A**
I/P Fuses 5, 11, 23, 38, 4, 10, 16, 22, 28
9
30A**
PCM Power Relay, Engine Compartment
Fuse 4
10
60A**
Auxiliary Battery Relay, Engine
Compartment Fuses 14, 22
11
30A**
IDM Relay
12
60A**
Engine Compartment Fuses 26, 27
13
50A**
Blower Motor Relay (Blower Motor)
A
B
3
2
1
4
6
5
7
15
14
13
12
11
10
9
8
23
22
21
20
19
18
17
16
24
26
25
27
29
C
D
G
F
E
K
J
H
28
Roadside emergencies
135
Fuse/Relay
Location
Fuse Amp
Rating
Power Distribution Box Description
14
30A**
Trailer Running Lamps Relay, Trailer
Backup Lamps Relay
15
40A**
Main Light Switch
16
50A**
RKE Module, Auxiliary Blower Motor Relay
17
30A**
Fuel Pump Relay, IDM (Diesel)
18
60A**
I/P Fuses 40, 41
19
60A**
4WABS Module
20
20A**
Electric Brake Controller
21
50A**
Modified Vehicle Power
22
40A**
Trailer Battery Charge Relay (Modified
Vehicles Only)
23
60A**
Ignition Switch
24
Not Used
25
20A*
NGV Module
26
10A*
Generator/Voltage Regulator (Diesel Only)
27
15A*
DRL Module, Horn Relay
28
PCM Diode
29
Not Used
A
Not Used
B
Not Used
C
Trailer Backup Lamps Relay
D
Trailer Running Lamps Relay
E
Trailer Running Lamps Relay
F
IDM Relay
G
PCM Relay
H
Blower Motor Relay
J
Horn Relay
K
Fuel Pump Relay, IDM Relay (Diesel)
* Mini Fuses ** Maxi Fuses
Roadside emergencies
136