Ford E-250 - 1997 Fuse Box Diagram

Ford E-250 - 1997 Fuse Box Diagram

All occupants of the
vehicle, including the
driver, should always wear their
safety belts, failure to do so may
increase the risk of personal
injury in the event of a collision.
The right front passenger
air bag is not designed to
restrain occupants in the center
front seating position.
Do not place objects or
mount equipment on or
near the dashboard area,
steering wheel or in front of the
passenger that may come in
contact with a deploying air bag.
Failure to follow this instruction
may increase the risk of personal
injury in the event of a collision.
Do not attempt to service,
repair, or modify the Air
Bag Supplemental Restraint
System or its fuses. See your
Ford or Lincoln-Mercury dealer.
If you are close to an
inflating air bag, it could
seriously injure you. Sit against
the seatback and position your
seat such that it is as far back
from the steering wheel as
possible but still allows you to
properly control the vehicle.
Seating and safety restraints
53
5. Shift the transmission to N
(Neutral).
6. Start the vehicle.
If you need to use the above
procedure, it is possible that a fuse
has blown and your brakelamps
may not be functioning. Refer to
the
Roadside emergencies
chapter for instructions on
replacing fuses.
Do not drive your vehicle
until you verify that the
brakelamps are working.
VEHICLE LOADING
It is extremely dangerous
to ride in a cargo area,
inside or outside of a vehicle. In
a collision, people riding in these
areas are more likely to be
seriously injured or killed. Do not
allow people to ride in any area
of your vehicle that is not
equipped with seats and safety
belts. Be sure everyone in your
vehicle is in a seat and using a
safety belt properly.
Before loading a vehicle, familiarize
yourself with the following terms:
Base Curb Weight:
Weight of
the vehicle including any
standard equipment, fluids,
lubricants, etc. It does not
include passengers or
aftermarket equipment.
Driving
86
Commercial stripped chassis
vehicles
4. Turn the ignition switch to the
ON position. Pause for a few
seconds and return the key to the
OFF position.
5. Make a further check for leaks
in the fuel system.
FUSES AND RELAYS
Fuses
If electrical components in the
vehicle are not working, a fuse
may have blown. Check the
appropriate fuses before replacing
any electrical components. Blown
fuses can be identified by a
Roadside emergencies
102
separation in the metal wire inside
the fuse.
Always replace a fuse with
one that has the specified
amperage rating. Using a fuse
with a higher amperage rating
can cause severe wire damage
and could start a fire.
Even after a fuse is replaced, it
will continue to blow if the cause
of the overload is not identified
and corrected. If a fuse continues
to blow, have the vehicle’s
electrical system checked.
Standard fuse amperage rating
and color
Fuse rating
Color
3 amp
Violet
4 amp
Pink
5 amp
Beige
10 amp
Red
15 amp
Blue
20 amp
Yellow
25 amp
Natural
30 amp
Light Green
High current fuse amperage
rating and color
Fuse rating
Color
30 amp
Light Green
40 amp
Amber
50 amp
Red
60 amp
Blue
Roadside emergencies
103
Instrument panel fuse panel
1
2
3
4
5
11
42
10
9
8
7
6
12
13
14
15
16
17
23
43
22
21
20
19
18
24
25
26
27
28
29
44
30
31
32
33
34
35
36
37
38
39
40
41
Roadside emergencies
104
Number
Fuse amperage
rating
Circuits protected
1
20 amp
4WABS or RABS
module
2
15 amp
4WABS relay (coil),
RABS (diode/resistor),
instrument cluster,
warning chime
3
15 amp
Headlamp switch,
radio sense, rear
radio control, Remote
keyless entry module
4
15 amp
Power mirrors,
modified vehicle,
power locks w/RKE,
Headlamp switch
(dome), illuminated
entry, Courtesy lamp
switches, Radio
(KAP), Cluster (KAP),
warning chime
5
20 amp
Remote keyless entry
module, power door
lock switches,
memory lock
6
10 amp
Brake shift interlock,
speed control,
daytime running light
module
7
10 amp
Multi-function switch
Roadside emergencies
105
Number
Fuse amperage
rating
Circuits protected
8
30 amp
Noise supression
capacitor, ignition coil
positive feed, PCM
relay diode/PCM
power relay, fuel
heater (diesel), glow
plug relay (diesel)
9
30 amp
Wiper control module,
wiper motor
10
20 amp
Headlamp switch
(exterior lamps),
Multi-function switch
(flash-to-pass)
11
15 amp
Stoplight switch, brake
pressure switch,
multi-function switch
12
15 amp
Digital transmission
range sensor (backup
lamps), auxiliary
battery relay
13
15 amp
A/C mode switch,
blend door actuator
14
5 amp
Instrument cluster (air
bag and charge
indicator lamps)
15
5 amp
Trailer tow battery
charge relay (coil)
16
30 amp
Power seats
17
-
Not used
18
-
Not used
19
10 amp
Air bag module
20
5 amp
Overdrive cancel
switch
Roadside emergencies
106
Number
Fuse amperage
rating
Circuits protected
21
30 amp
Power windows
22
-
Not used
23
20 amp
Cigar lighter, data link
connector
24
5 amp
Illuminated entry
25
10 amp
Left headlamp (low
beam)
26
-
Not used
27
-
Not used
28
25 amp
Instrument panel
power point
29
-
Not used
30
15 amp
Headlamps (high
beam), Daytime
running lamps (DRL),
high beam indicator
31
10 amp
Right headlamp (low
beam), Daytime
running lamps (DRL)
32
-
Not used
33
-
Not used
34
10 amp
Digital transmission
range sensor (start
control)
35
-
Not used
36
5 amp
Panel illumination
37
-
Not used
38
10 amp
Air bag module
39
-
Not used
40
30 amp
Modified vehicle
41
30 amp
Modified vehicle
42
-
Not used
Roadside emergencies
107
Number
Fuse amperage
rating
Circuits protected
43
-
Not used
44
-
Not used
Power distribution box
Always disconnect the
battery before servicing
high current fuses.
Always replace the cover
to the Power Distribution
Box before reconnecting the
battery or refilling fluid
reservoirs.
Number
Fuse amperage
rating
Circuits protected
1
-
Generator to battery
2
-
Not used
3
-
Not used
1
A
B
2
3
4
6
5
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
E
H
J
F
G
K
24
25
26
27
28
29
C
D
Roadside emergencies
108
Number
Fuse amperage
rating
Circuits protected
4
5 amp
PCM keep alive
memory
5
10 amp
Right trailer turn
signal
6
10 amp
Left trailer turn signal
7
-
Not used
8
60 amp
Instrument panel
fuses
9
30 amp
PCM power relay
10
60 amp
Auxiliary battery
11
-
Not used
12
60 amp
Misc.
13
50 amp
Blower motor relay
14
30 amp
Trailer running lamps,
trailer backup lamps
15
40 amp
Headlamp switch
16
50 amp
Auxiliary A/C, remote
keyless entry module
17
30 amp
Fuel pump relay
(gasoline), injector
driver module relay
(diesel)
18
60 amp
Modified vehicle
power
19
60 amp
Anti-lock brake
system (4WABS)
20
20 amp
Electric brake
controller (trailer tow)
21
50 amp
Modified vehicle
power
22
40 amp
Trailer battery charge
(relay)
Roadside emergencies
109
Number
Fuse amperage
rating
Circuits protected
23
60 amp
Ignition switch feed
24
-
Not used
25
-
Not used
26
10 amp
Alternator (diesel)
27
15 amp
Horn, daytime running
lamp module
28
-
PCM diode
29
-
Not used
Roadside emergencies
110